CRYSTAL ORGANIC OILS SOAP BASE







Product Name

Crystal Organic Oils Soap Base (CRYSTAL ORGANIC)

Supplier

Just a Soap

South East Lodge

Rede Road

Whepstead

Bury St Edmunds

IP29 4ST

01284 735043

Composition/Ingredients Information

Definition: formulated soap base where 100% of the oils used are certified

organic.

IFRA: not restricted.

Application: cosmetic soaps.

INCI: Glycerine, aqua, sodium palmate, sorbitol, sodium cocoate, palm fatty

acid, coconut fatty acid, pentasodium pentetate, tetrasodium etidronate.

Hazards Identification

Concentrated product. Do not ingest. Observe good housekeeping

procedures.

First Aid Measures

Inhalation: no risk.

Eye contact: flush immediately with plenty of cold water until condition

subsides.

Skin contact: no risk to usual skin types. Flush with plenty of water if irritation

occurs.

Ingestion: rinse mouth out with water. Not toxic no significant risk.

Other: when assessing action take Risk and Safety Phrases into account.

Fire Fighting Measures

Extinguishing media: use CO2 , dry powder or foam type extinguishers,

spraying extinguishing media to base of flames. Do not use direct water jet

on burning material.

Special measures: none required in normal use conditions.

Extinguishing procedures: closed containers may build up pressure when

exposed to heat and should be cooled with water spray.

Accidental Release Measures

Personal precautions: no risks posed in general contact.

Environment precautions: keep away from drains, soils, surface and

groundwaters.

Cleaning up methods: remove all potential ignition sources. Contain spilled

material. Allow to cool if liquid until solidification occurs. Scrape from

surfaces with blunt blade and sweep up and remove to an approved disposal

container. Observe state, federal and local disposal regulations. Residues

may be removed with water to final clean up.

Handling & Storage

Precautions in handling: apply good manufacturing practice and industrial

hygiene practices. No special risks or precautions generally required.







                                   Page 1 of 3

                   CRYSTAL ORGANIC OILS SOAP BASE





Observe good personal hygiene, and do not eat,drink or smoke whilst

handling.

Stoage conditions: Store in tightly closed original container in a cool, dry and

ventilated area away from heat sources and protected from light. Keep air

contact to a minimum.

Fire protection: keep away from ignition sources and naked flames.

Exposure Controls/Personal Protection

Respiratory protection: no risk. In extreme cases remove to fresh air.

Ventilation: ensure good ventilation of working area.

Hand protection: use chemically resistant gloves if required for prolonged

contact.

Eye protection: use safety glasses.

Work/hygiene practices: wash hands with water after handling.

Physical & Chemical Properties

Colour: opaque.

Appearance: solid at ambient. Liquid when heated.

Odour: neutral base has slight odour.

Flash Point ºC: n/a

Specific gravity @ 20ºC: n/a

Refractive index@ 20ºC: n/a

Solubility: freely soluble in water.

Flammability: not flammable.

Water content: 22-30%

FFA: 0.7-1.1%

Microbiological Specification

TVC: <100CFU/GM

Gram Negative Organisms: absent in 1GM

Stability & Reactivity

Reactivity: it presents no significant reactivity hazards, by itself or in contact

with water. Avoid contact with strong acids, alkali or oxidising agents.

Decomposition: liable to cause smoke and acrid fumes during combustion.

No major hazards known in decomposition.

Toxicological Information

Not considered a hazardous substance. NOT TESTED ON ANIMALS but

thought to be Acute Oral LD50rat>5000mg/kg based on similar product type.

Ecological Information

Biodegradability: thought to be readily biodegradable (OECD 301B) based on

tests on similar products.

Precautions: prevent surface contamination of soil, ground and surface water.

Disposal Considerations

Avoid excessive disposal to drainage systems and into the environment.

Seek expert advice. Observe specific local regulations.

Transport Regulations

Road (ADR/RID): n/a

Air (IATA): n/a

SEA(IMDG) n/a

CHIP: see next section









                                   Page 2 of 3

                   CRYSTAL ORGANIC OILS SOAP BASE





Regulatory Information. According to Directive 88/379/EEC

Hazards: n/a

Symbols: n/a

Risk phrases: n/a

Safety phrases: n/a

Other Information

Cosmetics Directive 7th Amendment: not restricted.

Packaging

Type                        Suitability

Glass                       Yes

Lacquer lined steel/tin     No

Aluminium                   Yes

HPPE                        Yes

F/HDPE                      Yes

Other plastic/films         Yes

Shelf Life

When stored within advised conditions, re-test after 12 months then every 3

months up to a maximum shelf life of 24 months.

Q.C. Requirements

In line with general product specification. Always satisfy suitability for specific

application.







This information relates only to the specific product designated and may not

be valid for such product used in combination with any other materials or

processes. Such information is, to the best of Just A Soap s knowledge and

belief, accurate and reliable as of the date indicated. However, no

representation, warranty or guarantee is made as to its accuracy, reliability or

completeness. It is the user's responsibility to satisfy themselves as to the

suitability of such information for their own particular use.









                                   Page 3 of 3

This document was created with Win2PDF available at http://www.win2pdf.com.

The unregistered version of Win2PDF is for evaluation or non-commercial use only.

This page will not be added after purchasing Win2PDF.