MATERIAL SAFETY DATA SHEET
SECTION 1: CHEMICAL PRODUCT IDENTIFICATION
: Kobo Products, Inc.
Manufacturer/Distributor
: 690 Montrose Avenue
Address
South Plainfield, NJ 07080
: (908) 757-0033
Emergency Telephone #
: (908) 757-0905
Facsimile Number
Trade Name : WSJ22ERAMP
INCI Name : Water (And) Acrylates/Ethylhexyl Acrylate Copolymer (And) Iron Oxides (C.I.
77491) (And) Sodium Acrylate/Sodium Acryloyldimethyl Taurate Copolymer (And)
Aminomethyl Propanol
SECTION 2: COMPOSITION / INFORMATION ON INGREDIENTS
Ingredient: CAS #: EINECS #:
Water 7732-18-5 231-791-2
Acrylates/Ethylhexyl Acrylate Copolymer 42398-14-1
Iron Oxides (C.I. 77491) 1309-37-1 215-168-2
Sodium Acrylate/Sodium Acryloyldimethyl Taurate Copolymer 77019-71-7
Aminomethyl Propanol 124-68-5 204-709-8
Laureth-21
SECTION 3: HAZARD IDENTIFICATION
No particular dangers associated with this product.
SECTION 4: FIRST AID MEASURES
Effects and Symptoms:
Medical Conditions Aggravated by Exposure : No specific effect.
Primary Route(s) of Entry : Skin and eye contact.
Emergency First Aid:
Eye Contact : Flush eyes with water for at least 15 min. See physician if irritation persists.
Skin Contact : Flush skin with soap and water for at least 15 min.
Ingestion : None needed for small amounts. For large amounts, if conscious, give water
and call physician. Do not induce vomiting.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point (Closed Cup) : N/A
Flammable Limits LEL/UEL % : Dry chemical foam, CO2
Special Fire Fighting Procedures : Extinguishing on intercepting air preferably
Unusual Fire And Explosion Hazards : None expected
SECTION 6: ACCIDENTAL RELEASE MEASURES
Personal Precautions : Avoid eye contact and excessive skin contact.
Environmental Precautions: : Prevent material from contaminating soil or entering sewerage and drainage
systems.
Spill response : Use appropriate NIOHS/MSHA approved respirator. Wear chemical gloves,
goggles, and lab coat. Carefully contain spilled material. Deposit spilled
material in appropriate waste container. Wash spill area with soap and water.
SECTION 7: HANDLING AND STORAGE
p. 1 of 3
KOBO Products, Inc.
WSJ22ERAMP
Handling : Use with adequate ventilation. Avoid contact with eyes. Wash thoroughly after handling
and before mealtimes. Follow all MSDS and label precautions even after container is
emptied since it may contain residual material.
Storage : Must be kept at ambient conditions (5-30掳C). Must not be allowed to freeze.
SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION
Exposure Levels: OSHA ACGIH
Component TWA PEL TWA TLV
Iron Oxides 15mg/m3 10 mg/m3
Personal Protection:
Eye Protection : Safety glasses with side shields or goggles
Skin Protection : Rubber gloves, wash at meals and end of shifts
Respiratory Protection : Use NIOSH/MSHA approved air purifying respirator as needed to control exposure.
Ventilation : Provide adequate general mechanical exhaust.
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point (掳C) : > 100 Percent Volatile By Vol. (%) : 54 %
Freezing Point (掳C) : <0 Vapor Density (Air=1) : N/A
Melting Point (掳C) : N/A Evaporation Rate (Buac=1) : N/A
Vapor Pressure (mm hg) : N/A Solubility In Water : dispersible
Bulk Density (g/cbi.) : N/A Appearance & Odor : Viscous Red Fluid,
Specific Gravity (H2O=1) : Approx. 1.2 Slight Characteristic Odor
SECTION 10: STABILITY AND REACTIVITY
Stable :
Yes
Hazardous Polymerization :
Will not occur
Conditions To Avoid :
Open flames and sparks, extreme heat, oxidizing materials
Incompatibility :
Avoid contact with peroxides, chlorates, perchlorates, nitrates, and
permanganates.
Hazardous Decomposition Products : Incomplete combustion can form CO, CO2, acrylate monomers and dense
smoke.
SECTION 11: TOXICOLOGICAL INFORMATION
Iron Oxides Acrylates Copolymer
Skin Irritation (rabbit) : No data Not determined
Primary Eye Irritation : Mild-irritant (rabbit) Average Draize score = 0.00 Non-irritating, RC50= 5.5
Acute Oral Toxicity (rat) : Non-toxic, LD50 > 15 g/kg (rat) Not determined
Sensitization : Non-toxic Not determined
Inhalation LC50 : LD50>5,000 g/kg
Chronic Effects on CARCINOGENIC EFFECTS:
Humans Classified None. By NIOSH [Iron Oxides]. Classified A4 (not classifiable for human
or animal.) by AGIH, 3 (not classifiable for human.) by IARC [Iron Oxides].
MUTAGENIC EFFECTS: Not available.
TERATOGENIC EFFECTS: Not available.
SECTION 12: ECOLOGICAL INFORMATION
No Data
SECTION 13: DISPOSAL CONSIDERATIONS
Page 2 of 3
KOBO Products, Inc.
WSJ22ERAMP
Method of Disposal : Dispose of in accordance with all applicable federal, state, and local regulations. Material
may be sent to an approved landfill or licensed treatment, storage, and disposal facility.
SECTION 14: TRANSPORT INFORMATION
DOT Classification Not regulated
ICAO/IATA Not regulated
SECTION 15: REGULATORY INFORMATION
U.S. Federal Regulations Clean Water Act (CWA) 307: No products were found.
Clean Water Act (CWA) 311: No products were found.
Clean Air Act (CAA) 112 accidental release prevention: No products were found.
Clean Air Act (CAA) 112 regulated flammable substances: No products were found.
Clean Air Act (CAA) 112 regulated toxic substances: No products were found.
WHMIS (Canada) Not controlled under WHMIS (Canada)
DSCL (EEC) S25/36- avoid contact with eyes and wear suitable protective clothing.
International List
Australia (NICNAS): IRON OXIDES
JAPAN (MITI): IRON OXIDES
Korea (TCCL): IRON OXIDES
Philippines (RA6969): IRON OXIDES
State Regulations Pennsylvania RTK: IRON OXIDES: (generic environmental hazard)
Massachusetts RTK: IRON OXIDES
New Jersey: IRON OXIDES
SECTION 16: OTHER INFORMATION
Hazardous Material Information System [Ratings Key: 4= Highest hazard, 0= Lowest hazard]
(U.S.A.)
Health 0
Fire Hazard 0
Reactivity 0
Personal Protection C
EU S phrases : S25/36- avoid contact with eyes and wear suitable protective clothing.
Date Prepared : June 28, 2002
Date Revised : January 17, 2003
Date Revised : February 20, 2006
Last Revised : September 11, 2006
By Eric Smith
Note: The statements made here are intended to describe the product with regard to necessary safety precautions.
They do not guarantee special characteristics. This information is furnished without warranty, expressed or implied,
except that it is accurate to the best of our current knowledge.
Page 3 of 3
|