**** SECTION 2 - COMPOSITION, INFORMATION ON INGREDIENTS ****
+----------------+--------------------------------------+----------+-----------+
| CAS# | Chemical Name | % | EINECS# |
|----------------|--------------------------------------|----------|-----------|
| 95-48-7 |o-Cresol | >98 | 202-423-8 |
+----------------+--------------------------------------+----------+-----------+
Hazard Symbols: T C
Risk Phrases: 34 24/25
**** SECTION 3 - HAZARDS IDENTIFICATION ****
EMERGENCY OVERVIEW
Causes burns. Toxic in contact with skin and if
swallowed.Corrosive.Toxic.Hygroscopic (absorbs moisture from the
air).Light sensitive.
Potential Health Effects
Eye:
May result in corneal injury. Causes eye irritation and burns.
May cause conjunctivitis and keratitis.
Skin:
May be absorbed through the skin in harmful amounts. Causes severe
skin irritation and burns.
Ingestion:
Causes gastrointestinal irritation with nausea, vomiting and
diarrhea. Causes gastrointestinal tract burns. May cause liver and
kidney damage. Cresols may cause abnormalities of the central
nervous system, respiratory system, spleen and pancreas.
Inhalation:
May be fatal if inhaled. Causes severe irritation of upper
respiratory tract with coughing, burns, breathing difficulty, and
possible coma. May cause headache. May cause nausea and possible
vomiting.
Chronic:
May cause liver and kidney damage. May cause appetite loss,
diarrhea, skin abnormalities, and digestive tract disturbances.
**** SECTION 4 - FIRST AID MEASURES ****
Eyes:
Get medical aid immediately. Do NOT allow victim to rub eyes or keep
eyes closed. Extensive irrigation with water is required (at least 30
minutes).
Skin:
Get medical aid immediately. Immediately flush skin with plenty of
water for at least 15 minutes while removing contaminated clothing
and shoes. Discard contaminated clothing in a manner which limits
further exposure. Destroy contaminated shoes.
Ingestion:
Never give anything by mouth to an unconscious person. Get medical
aid immediately. Do NOT induce vomiting. If conscious and alert,
rinse mouth and drink 2-4 cupfuls of milk or water.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh
air immediately. If breathing is difficult, give oxygen.
Notes to Physician:
**** SECTION 5 - FIRE FIGHTING MEASURES ****
General Information:
As in any fire, wear a self-contained breathing apparatus in
pressure-demand, MSHA/NIOSH (approved or equivalent), and full
protective gear. Vapors can travel to a source of ignition and flash
back. Vapors may be heavier than air. They can spread along the
ground and collect in low or confined areas.
Extinguishing Media:
For small fires, use dry chemical, carbon dioxide, or water spray.
For large fires, use dry chemical, carbon dioxide, alcohol-resistant
foam, or water spray.
**** SECTION 6 - ACCIDENTAL RELEASE MEASURES ****
General Information: Use proper personal protective equipment as indicated
in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth),
then place in suitable container.
**** SECTION 7 - HANDLING and STORAGE ****
Handling:
Wash thoroughly after handling. Remove contaminated clothing and
wash before reuse. Use only in a well-ventilated area. Ground and
bond containers when transferring material. Do not get in eyes, on
skin, or on clothing. Empty containers retain product residue,
(liquid and/or vapor), and can be dangerous. Do not ingest or inhale.
Do not pressurize, cut, weld, braze, solder, drill, grind, or expose
empty containers to heat, sparks or open flames.
Storage:
Keep away from heat, sparks, and flame. Keep away from sources of
ignition. Store in a tightly closed container. Store in a cool, dry,
well-ventilated area away from incompatible substances. Corrosives
area.
**** SECTION 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION ****
Engineering Controls:
Use adequate ventilation to keep airborne concentrations low.
Personal Protective Equipment
Eyes:
Wear appropriate protective eyeglasses or chemical
safety goggles as described by OSHA's eye and face
protection regulations in 29 CFR 1910.133 or European
Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin
exposure.
Clothing:
Wear appropriate protective clothing to prevent skin
exposure.
Respirators:
Follow the OSHA respirator regulations found in 29
CFR 1910.134 or European Standard EN 149. Always use
a NIOSH or European Standard EN 149 approved
respirator when necessary.
**** SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES ****
Physical State: Solid
Color: white to pale yellow
Odor: Phenolic.
pH: Not available.
Vapor Pressure: .25 mm Hg @ 25C
Viscosity: 4.75 cP 35 deg C
Boiling Point: 191 deg C @ 760 mm Hg
Freezing/Melting Point: 32 - 34 deg C
Autoignition Temperature: 598 deg C ( 1,108.40 deg F)
Flash Point: 81 deg C ( 177.80 deg F)
Explosion Limits, lower: 1.30 vol %
Explosion Limits, upper: Not available.
Decomposition Temperature:
Solubility in water: 30.8 g/L @ 40C
Specific Gravity/Density: 1.04g/cm3
Molecular Formula: C7H8O
Molecular Weight: 108.14
**** SECTION 10 - STABILITY AND REACTIVITY ****
Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
High temperatures, light, ignition sources, excess heat.
Incompatibilities with Other Materials:
Strong oxidizing agents, strong acids, bases, aliphatic amines,
chlorosulfonic acid, oleum.
Hazardous Decomposition Products:
Carbon monoxide, carbon dioxide.
Hazardous Polymerization: Has not been reported.
**** SECTION 11 - TOXICOLOGICAL INFORMATION ****
RTECS#:
CAS# 95-48-7: GO6300000
LD50/LC50:
CAS# 95-48-7: Draize test, rabbit, eye: 105 mg Severe; Draize test,
rabbit, skin: 524 mg/24H Severe; Inhalation, mouse: LC50 = 179
mg/m3/2H; Inhalation, rat: LC50 = >1220 mg/m3/1H; Oral, mouse: LD50 =
344 mg/kg; Oral, rat: LD50 = 121 mg/kg; Skin, rabbit: LD50 = 890
mg/kg; Skin, rat: LD50 = 620 mg/kg.
Carcinogenicity:
o-Cresol -
Not listed by ACGIH, IARC, NIOSH, NTP, or OSHA.
See actual entry in RTECS for complete information.
**** SECTION 12 - ECOLOGICAL INFORMATION ****
Ecotoxicity:
Goldfish (soft water) TLm=49.1-19ppm/24-96H Bluegill (soft water)
TLm=22.2-20.8ppm/24-96H Fathead minnow (hard water)
TLm=18-13.4ppm/24-96H Guppy (hard water) TLm=18-50ppm/24-96H
**** SECTION 13 - DISPOSAL CONSIDERATIONS ****
Dispose of in a manner consistent with federal, state, and local regulations.
**** SECTION 14 - TRANSPORT INFORMATION ****
IATA
Shipping Name: CRESOLS
Hazard Class: 6.1
UN Number: 2076
Packing Group: II
IMO
Shipping Name: CRESOLS, LIQUID or SOLID
Hazard Class: 6.1
UN Number: 2076
Packing Group: II
RID/ADR
Shipping Name: CRESOLS
Hazard Class: 6.1
UN Number: 2076
Packing group: II
**** SECTION 15 - REGULATORY INFORMATION ****
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: T C
Risk Phrases:
R 24/25 Toxic in contact with skin and if swallowed.
R 34 Causes burns.
Safety Phrases:
S 36/37/39 Wear suitable protective clothing, gloves
and eye/face protection.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 95-48-7: 2
United Kingdom Occupational Exposure Limits
United Kingdom Maximum Exposure Limits
Canada
None of the chemicals in this product are listed on the DSL/NDSL list.
CAS# 95-48-7 is not listed on Canada's Ingredient Disclosure List.
Exposure Limits
CAS# 95-48-7: OEL-DENMARK:TWA 5 ppm (22 mg/m3);Skin
OEL IN BULGARIA, COLOMBIA, JORDAN, KOREA check ACGIH TLV
OEL IN NEW ZEALAND, SINGAPORE, VIETNAM check ACGI TLV
US FEDERAL
TSCA
CAS# 95-48-7 is not listed on the TSCA inventory.
It is for research and development use only.
**** SECTION 16 - ADDITIONAL INFORMATION ****
MSDS Creation Date: 10/15/1997 Revision #4 Date: 3/04/2004
The information above is believed to be accurate and represents the best
information currently available to us. However, we make no warranty of
merchantability or any other warranty, express or implied, with respect to
such information, and we assume no liability resulting from its use. Users
should make their own investigations to determine the suitability of the
information for their particular purposes. In no way shall the company be
liable for any claims, losses, or damages of any third party or for lost
profits or any special, indirect, incidental, consequential or exemplary
damages, howsoever arising, even if the company has been advised of
the possibility of such damages.
--------------------------------------------------------------------------------
--------------------------------------------------------------------------------
|
|
|