LORD CORP -- CHEMLOK AP-134
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BXZNS
MSDS NAME: CHEMLOK AP-134
Responsible Party
Name: LORD CORP
Address: 2000 W GRANDVIEW BLVD
City: ERIE PA 16514
Info Phone: 814-868-3611
Emergency Phone Number: 814-763-2345
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LORD CORP
Address: 2000 W GRANDVIEW BLVD
Box: 10038
City: ERIE PA 16514
Phone: 814-868-3611
Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514-0038
Phone: 814-868-3611
=======================================================
Ingredients
=======================================================
Name: OTHER PROT EQUIP:ANSI APPRVD EMERGENCY EYE WASH AND DELUGE SHOWER (FP N).
-----------------------------
Name: ING 7: FORMING ORGANS. CHRONIC SKIN CONTACT MAY CAUSE DERMATITIS.
-----------------------------
Name: FIRST AID PROC: GIVE VICTIM ONE OR TWO GLASSES OF WATER/MILK. CALL MD OR
POISON CONTROL CTR IMMED FOR FURTHER
-----------------------------
Name: ING 9: INSTRUCTIONS. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON.
-----------------------------
Name: SPILL PROC:CONTAIN & REMOVE W/INERT ABSORB MATL & NON-SPARKING
TOOLS. AVOID CONTACT. BEFORE ATTEMPTING CLEANUP,
-----------------------------
Name: ING 11: REFER TO HAZARD CAUTION INFO IN OTHER SECTIONS OF MSDS.
-----------------------------
Name: HNDLG/STOR PRECS: ONLY IN WELL-VENT AREAS. DO NOT PUNCTURE, DRAG OR SLIDE
CNTNR. KEEP CNTNR CLOSED WHEN NOT IN USE.
-----------------------------
Name: OTHER PRECS: & UNDERSTOOD. EMPTY CNTNRS SHOULD NOT BE RE-USED. USE
W/ADEQ VENT. BECAUSE EMPTY CNTNRS MAY RETAIN
-----------------------------
Name: ING 14: PROD RESIDUE & FLAMM VAPS, KEEP AWAY FROM HEAT, SPKS &
FLAME; DO NOT CUT, PUNCTURE OR WELD ON OR NEAR
-----------------------------
Name: ING 15: EMPTY CONTAINER. DO NOT SMOKE WHERE THIS PRODUCT IS USED OR
STORED.
-----------------------------
Name: RESP PROT: USE A NIOSH/MSHA APPROVED AIR-SUPPLIED RESPIRATOR. OBSERVE
OSHA REGS (29 CFR 1910.134) FOR RESPIRATOR USE.
-----------------------------
Name: VENT: EXPOS LIMS. CAUTION: SOLV VAPS ARE HVR/AIR & COLLECT IN LOWER
LEVELS OF WORK AREA. SUFFICIENT VENT (USING
-----------------------------
Name: ING 18: EXPLOSION-PROOF EQUIP) SHOULD BE PROVIDED TO PREVENT FLAMMABLE
VAPOR/AIR MIXTURES FROM ACCUMULATING.
-----------------------------
Name: HYGIENE PRACT: OR BEVERAGES SHOULD NOT BE CONSUMED ANYWHERE PRODUCT IS
HANDLED OR STORED. WASH THORO AFTER HANDLING.
-----------------------------
Name: ING 6: MAY CAUSE LIVER/KIDNEY DMG. RPTD/PRLNG SOLV OVEREXP MAY RSLT IN
PERM CNS DMG. MAY AFFECT BLOOD & BLOOD-
-----------------------------
Cas: 64-17-5
RTECS #: KQ6300000
Name: ETHYL ALCOHOL
% Wt: <4
OSHA PEL: 1000 PPM
ACGIH TLV: 1000 PPM
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
Name: TOLUENE (SARA 313) (CERCLA)
% Wt: <75
OSHA PEL: 200 PPM
ACGIH TLV: 50 PPM, S
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 71-36-3
RTECS #: EO1400000
Name: BUTYL ALCOHOL; (N-BUTANOL) (SARA 313) (CERCLA)
% Wt: <5
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM, S, C
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 111-76-2
RTECS #: KJ8575000
Name: ETHANOL, 2-BUTOXY-; (2-BUTOXYETHANOL)
% Wt: <4
OSHA PEL: 50 PPM, S
ACGIH TLV: 25 PPM, S
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
Name: 2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (HEXONE) (SARA 313)
(CERCLA)
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM; 75 STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Name: SUPDAT:BLOOD, KIDNEYS & LIVER ASSOC W/2-BUTOXYETHANOL. (EXTRACTED
FROM DHHS (NIOSH) PUBLICATION NO 90-118)(FPN).
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: MAY CAUSE IRRIT. SKIN: MAY BE ABSORBED THRU SKIN IN
HARMFUL AMTS. MAY CAUSE SKIN IRRIT. MAY CAUSE DERM. INHAL: POSS IRRIT OF RESP
SYS CAN OCCUR CAUSING VARIETY OF SYMPS SUCH AS DRYNESS OF THROAT , TIGHTNESS
OF CHEST & SHORTNESS OF BREATH. MAY CAUSE CNS DEPRESS CHARACT BY
FOLLOWING PROGRESSIVE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ: STEPS: HDCH, DIZZ, STAG GAIT,
CONFUSN, UNCON OR COMA. MAY CAUSE HDCH & NAUS. INGEST: HARMFUL IF
SWALLOWED. INGEST IS NOT EXPECTED ROUTE OF ENTRY IN INDUS/COMMERCIAL USES.
CHRONIC: TOLUENE AP PEARS ON NAVY OCCUP CHEM REPRO HAZS LIST. SEEK
CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST (SUPDAT)
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYES: FLUSH IMMED W/LG AMT OF WATER FOR AT LEAST 15 MIN HOLDING LIDS
OPEN WHILE FLUSHING. GET PROMPT MED ATTN. SKIN: FLUSH CONTAMD SKIN W/LG AMTS
OF WATER WHILE REMOVING CONTAMD CLTHG. WASH AFFECTED A REAS W/SOAP &
WATER. GET MED ATTN IF SYMPS OCCUR. INHAL: MOVE TO FRESH AIR. RESTORE &
SUPPORT CONTINUED BRTHG. IF BRTHG IS DFCLT, GIVE OXYGEN. GET IMMED MED ATTN.
INGEST: DO NOT INDUCE VOMIT.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP NON-ESSNTL PERS A SAFE DIST AWAY FROM SPILL
AREA. REMOVE ALL SOURCES OF IGNIT (FLAME, HOT SURFS & ELEC,
STATIC/FRICTIONAL SPKS). AVOID BRTHG VAPS. USE NIOSH/MSHA APPRVD
SELF-CONTAINED BREATHING E QUIPMENT. NOTIFY APPROP AUTHS IF NEC.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH FEDERAL (40
CFR PART 261), STATE, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. IF WASTE
IS DETERMINED TO BE HAZARDOUS, USE LICENSED HAZARDOUS WASTE TRANSPORT ER AND
DISPOSAL FACILITY.
Handling And Storage Precautions: DO NOT STORE/USE NEAR HEAT, SPKS OR OPEN
FLAME. REFER TO OSHA 29CFR PART 1910.106 "FLAMM & COMBUST LIQS" FOR
SPECIFIC STORAGE REQS. STORE
Other Precautions: KEEP CLOSURE TIGHT & CNTNR UPRIGHT TO PVNT LEAKAGE.
GROUND & BOND CNTNRS WHEN TRANSFERRING MATL. AVOID SKIN & EYE CNTCT.
WASH THORO AFTER HANDLG. AVOID BRTHG OF VAP/SPRAY MISTS. DO NOT HANDLE UNTIL
AL L SFTY PRECS HAVE BEEN READ
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 35.0F,1.7C
Lower Limits: 1.1%
Upper Limits: 19.0%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures: USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP
N). WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZS ARE PREF. DURING
FIRE, IRRIT &/OR TOX (SUPDAT)
Unusual Fire/Explosion Hazard: FLAMM LIQ & VAP. KEEP CNTNRS TIGHTLY CLSD.
ISOLATE FROM HEAT, ELEC EQUIP, SPKS, OPEN FLAME & OTHER SOURCES OF IGNIT.
CLSD CNTNRS MAY RUPTURE WHEN EXPOS (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE A NIOSH/MSHA APPRVD CHEM/MECH FILTER RESP DESIGNED
TO REMOVE A COMBINATION OF PARTICULATES & ORG VAP IF OCCUP LIMS ARE
EXCEEDED. FOR EMER SITUATIONS, CONFINED SPACE USE OR OTHER CNDTNS WHERE EXPOS
LIMS MAY BE GREATLY EXCEEDED,
Ventilation: SUFFICIENT VENT IN PATTERN & VOL SHOULD BE PROVIDED IN ORDER
TO MAINTAIN AIR CONTAMINANT LEVELS BELOW RECOM
Protective Gloves: NEOPRENE, NITRILE OR RUBBER GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: USE DISPOSABLE/IMPERVIOUS CLTHG IF WORK CLTHG
CONTAM IS LIKELY. REMOVE & WASH CONTAMD CLTHG BEFORE REUSE.
Work Hygienic Practices: WASH HANDS BEFORE EATING, SMOKING OR USING TOILET
FACILITY. DO NOT SMOKE IN ANY CHEM HNDLG/STORAGE AREA. FOOD
Supplemental Safety and Health: FIRE FIGHT PROC: GASES & PARTICULATE MAY BE
GENERATED BY THERMAL DECOMP/COMBUST. EXPLO HAZ: TO EXTREME HEAT. USE WATER
SPRAY TO KEEP FIRE EXPOS CNTNRS COOL. EFTS OF OVEREXP: HAZ LIST INFO &
SAFE HNDLG & EXPOS INFO (FP N). ANIMAL STUDIES HAVE CLEARLY SHOWN
DOSE-RELATED ADVERSE EFTS TO CNS, HEMATOPOIETIC TISS,
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >172F,>78C
Vapor Density: HVR/AIR
Spec Gravity: 0.89
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: CLEAR LIQUID; SOLVENT ODOR.
Percent Volatiles by Volume: 90.4
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES. SOURCES OF IGNITION.
Materials To Avoid: STRONG ACIDS, BASES AND STRONG OXIDIZERS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: CHEMLOK AP-134
Assigned IND: Y
Company: LORD CORP
Street: 2000 W GRANDVIEW BLVD
PO Box: 10038
City: ERIE PA
Zipcode: 16514
Health Emergency Phone: 814-763-2345
Label Required IND: Y
Date Of Label Review: 06/19/1995
Status Code: C
Label Date: 06/19/1995
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Slight
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: EXTREMELY FLAMMABLE. ACUTE: EYES: MAY CAUSE IRRIT.
SKIN: MAY BE ABSORBED IN HARMFUL AMOUNTS. MAY CAUSE IRRIT, DERMATITIS. INHAL:
POSS IRRIT OF RESPIRATORY TACT W/DRYNESS OF THROAT, TIGHTNESS OF CHEST &
SHORTNESS OF BREATH. MAY CAUSE CNS DEPRESSION W/HEADACHE, DIZZINESS,
STAGGERING GAIT, CONFUSION, UNCONSCIOUSNESS OR COMA. INGEST: HARMFUL IF
SWALLOWED. CHRONIC: TOLUENE APPEARS ON NAVY OCCUP CHEM RE PRO HAZARDS LIST
(FP N). ANIMAL STUDIES HAVE CLEARLY SHOWN DOSE-RELATED ADVERSEEFFECTS TO CNS,
BLOOD FORMING TISSUES, BLOOD, KIDNEYS & LIVER ASSOCIATED W/ADMINISTRATION
OF 2-BUTOXYETHANOL (FP N). MAY CAUSE DERMATITIS.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|