PPG INDUSTRIES INC -- W/R EPOXY COMPONENT B, 98-98
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CDLCP
MSDS NAME: W/R EPOXY COMPONENT B, 98-98
Responsible Party
Name: PPG INDUSTRIES INC
Address: 4325 ROSANNA DRIVE
Box: 9
City: ALLISON PARK PA 15101
Info Phone: 412-492-5555
Emergency Phone Number: 304-843-1300
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: PPG INDUSTRIES INC
Address: UNKNOWN
Box: UNKNOW
City: UNKNOWN NK 00000
Phone: UNKNOWN
Name: PPG INDUSTRIES INC. COATINGS & RESINS GP
Address: 4325 ROSEANNA DR PO BOX 9
Box: 9
City: ALLISON PARK PA 15101
Phone: 412-492-5555
=======================================================
Ingredients
=======================================================
Cas: 12174-11-7
RTECS #: RT6400000
Name: PALYGORSKITE; (ALUMINUM MAGNESIUM SILICATE)
% Wt: 1-2
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 25068-38-6
RTECS #: SL6475000
Name: BISPHENOL A-EPICHLOROHYDRIN COPOLYMER; (EPOXY RESIN)
% Wt: 35-40
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7732-18-5
RTECS #: ZC0110000
Name: WATER; (DEIONIZED WATER)
% Wt: 50-55
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 2807-30-9
RTECS #: KM2800000
Name: ETHANOL, 2-PROPOXY-; (ETHYLENE GLYCOL MONOPROPYL ETHER)
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Name: GLYCOL ETHERS
% Wt: 5-10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: EFTS OF OVEREXP:BE HARMFUL/FATAL. CHRONIC:AVOID LONG TERM & RPTD
CONT. THIS PROD CONTAINS AN ETHYLENE SERIES
-----------------------------
Name: ING 6:GLYCOL ETHER &/OR ACETATE WHICH HAS BEEN SHOWN TO CAUSE ADVERSE
EFTS ON KIDNEYS, LIVER, BLOOD &/OR BLOOD-
-----------------------------
Name: ING 7:FORMING TISS. THERE IS NO CONCLUSIVE EVID OF THESE EFTS IN HUMANS.
-----------------------------
Name: RESP PROT:DETERMINE TYPE OF AIRBORNE CONTAMS AGAINST WHICH RESP IS EFTIVE
& HOW IT IS TO BE PROPERLY FITTED.
-----------------------------
Name: VENT:BELOW STATED LIMIT & TO REMOVE DECOMPOSITION PRODUCTS DURING
WELDING OR FLAME CUTTING.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:INGEST:HARMFUL/FATAL IF SWALLOWED. EYE CONT:CAUSES
SEV IRRIT. REDNESS, ITCH, BURNING SENSATION & VISUAL DISTURBS MAY
INDICATE EXCESSIVE CONT. SKIN CONT:MAY CAUSE SLIGHT IRRIT. MAY BE ABSORBED TH
RU SKIN. DRYNESS, TEARING, CRACKING, BURNING, REDNESS & SWELL ARE CNDTNS
ASSOC W/EXCESSIVE CONT. INHAL:(EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: HLTH HAZ:EYE WATERING, HDCHS, NAUS, DIZZ
& LOSS OF COORD ARE INDICATIONS THAT SOLV LEVELS ARE TOO HIGH. VAP &
SPRAY MIST HARMFUL IF INHALED. VAP IRRITS EYES, NOSE & THROAT. RPTD EXPOS
TO HIGH VAP CONC S MAY CAUSE IRRIT OF RESP SYS & PERM BRAIN & NERV
SYS DMG. INTENTIONAL MISUSE BY DELIB CONC & INHAL CONTENTS CAN
First Aid: INGEST:DO NOT INDUCE VOMIT. EYES:FLUSH IMMED W/PLENTY OF WATER FOR
AT LST 15 MINS. SKIN:FLUSH IMMED W/PLENTY OF WATER FOLLOWED BY WASHING W/SOAP
& WATER. INHAL:REMOVE TO FRESH AIR. APPLY ARTF RESP & O THER
SUPPORTIVE MEASURES AS REQD. OTHER:IF INGEST, ANY TYPE OF OVEREXP/SYMPS OF
OVEREXP OCCUR DURING/FOLLOWING USE OF THIS PROD, CONT POIS CTL CTR, EMER
ROOM/MD IMMED; HAVE MSDS AVAILABLE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PROVIDE MAX VENT. ONLY PERS EQUIPPED W/PROPER NIOSH
APPRVD RESP & SKIN & EYE PROT SHOULD BE PERMITTED IN AREA. REMOVE ALL
SOURCES OF IGNIT. TAKE UP SPILLED MATL W/SAWDUST, VERMICULITE/OTHER ABSORB
MAT L & PLACE INTO CNTNR FOR DISP.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: WASTE MATERIAL MUST BE DISPOSED OF I/A/W FEDERAL,
STATE, PROVINCIAL & LOCAL ENVIRONMENTAL CONTROL REGULATIONS. EMPTY
CONTAINERS SHOULD BE RECYCLED OR DISPOSED OF THROUGH AN APPROVED WASTE
MANAGEMENT F ACILITY.
Handling And Storage Precautions: DO NOT STORE >120F. STORE LG QTYS IN BLDGS
DESIGNED & PROTECTED FOR STOR OF NFPA CLASS II COMBUST LIQS. CNTNRS
SHOULD BE GROUNDED WHEN POURING.
Other Precautions: IF THIS MATL IS PART OF MULTIPLE COMPONENT SYS, READ MSDS(S)
FOR OTHER COMPONENT(S) BEFORE BLENDING AS RESULTING MIXT MAY HAVE HAZS OF ALL
OF ITS PARTS. AVOID FREE FALL OF LIQS IN EXCESS OF A FEW INCH ES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 130F,54C
Extinguishing Media: USE NFPA CLASS B EXTINGS (CARBON DIOXIDE, DRY
CHEM/UNIVERSAL AQ FILM FORMING FOAM) DESIGNED TO EXTING NFPA CLASS(SUPDAT)
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER SPRAY MAY BE INEFT. WATER SPRAY MAY BE USED TO COOL CLSD CNTNRS TO PVNT
PRESS BUILD-UP & POSS (SUPP DATA)
Unusual Fire/Explosion Hazard: COMBUST. KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, ELEC EQUIP, SPKS & OPEN FLAMES. CLSD CNTNRS MAY EXPLODE WHEN EXPOS
TO EXTREME HEAT. DO NOT APPLY (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: OVEREXP TO VAPS MAY BE PREVENTED BY ENSURING VENT
CONTROLS, VAP EXHST/FRESH AIR ENTRY. NIOSH APPROVD (TC-23C-) AIR
PURIFYING/AIR SUPPLIED (TC-19C-) RESPS MAY ALSO REDUCE EXPOS. READ RESP MFR'S
INSTRUC TIONS & LITERATURE CAREFULLY TO
Ventilation: PROVIDE GEN DILUTION/LOC EXHST VENT IN VOL & PATTERN TO KEEP
CONC OF INGS BELOW LOWEST SUGGESTED EXPOS LIMS, LEL
Protective Gloves: NITRILE RUBBER/NEOPRENE RUBBER GLOVES.
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH FOUNTAIN & DELUGE SHOWER (FP
N). WEAR PROTECTIVE CLOTHING, INCLUDING IMPERMEABLE APRON.
Work Hygienic Practices: CLEAN OR DISCARD CONTAMINATED CLOTHING & SHOES.
Supplemental Safety and Health: EXTING MEDIA:II COMBUST LIQ FIRES. FIRE FIGHT
PROC:AUTOIGNIT/EXPLO WHEN EXPOS TO EXTREME HEAT. IF WATER IS USED, FOG NOZZ
ARE PREF. EXPLO HAZ:ON HOT SURFS. TOX GASES MAY FORM WHEN PROD IS CONTACTED
BY FLAME/HOT SURFS. HAZ DECOMP PROD:OXIDES OF NITROGEN.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
Vapor Pres: 17.1
Vapor Density: HVR/AIR
Spec Gravity: 1.07
Evaporation Rate & Reference: 34 (BUOAC=100)
Solubility in Water: 61.4%
Appearance and Odor: VISCOUS LIQUID W/ODOR CHARACTERISTIC OF SOLVENTS LISTED IN
INGREDIENTS.
Percent Volatiles by Volume: 66.3
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: AVOID CONTACT W/STRONG ALKALIES, STRONG MINERAL ACIDS OR
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY PRDCE HAZ DECOMP PRODS WHEN HEATED.
WELDING, BRAZING/FLAME-CUTTING MAY PRDCE FUMES INCL: CARBON MONOXIDE,
(SUPDAT)
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: W/R EPOXY COMPONENT B, 98-98
Assigned IND: Y
Company: PPG INDUSTRIES INC. COATINGS & RESINS GP
Street: 4325 ROSEANNA DR PO BOX 9
PO Box: 9
City: ALLISON PARK PA
Zipcode: 15101
Health Emergency Phone: 304-843-1300
Label Required IND: Y
Date Of Label Review: 02/24/1997
Status Code: C
Label Date: 02/24/1997
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:INGESTION:HARMFUL OR FATAL IF
SWALLOWED. EYE CONTACT:CAUSES SEVERE IRRITATION. REDNESS, ITCHING, BURNING
SENSATION AND VISUAL DISTURBANCES MAY INDICATE EXCESSIVE CONTACT. SKIN CONTA
CT:MAY CAUSE SLIGHT IRRITATION. MAY BE ABSORBED THROUGH SKIN. DRYNESS,
TEARING, CRACKING, BURNING, REDNESS AND SWELLING ARE CONDITIONS ASSOCIATED
WITH EXCESSIVE CONTACT. INHALATION:EYE WATERING, HEADA CHES, NAUSEA,
DIZZINESS, LOSS OF COORDINATION, IRRITATION. CHRONIC:MAY ADVERSELY AFFECT
LIVER, KIDNEYS, BLOOD OR BLOOD FORMING TISSUES. MAY CAUSE PERMANENT BRAIN OR
NERVOUS SYSTEM DAMAGE.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|