| MSDS | : | 15-015, KWIK SEAL INTERIOR CLEAR POLYURETHANE(SUPDAT) | | CAS | : | 96-29-7
8052-41-3 | | NAME | : | 2-butanone, oxime; (methyl ethyl ketoxime)
stoddard solvent
synthetic resin complex
exting media: if leak/spill has ignited, use water spray to disperse vaps
ing 5: minimize breathing gases, vapors, fumes or decomposition products.
efts of overexp: efts observed in male rats have significant implications
ing 7: in workplace. skin: prlngd/rptd cont can cause mod irrit, defat
ing 8: redness, tearing, blurred vision. ingest: can cause gi irrit,
ing 9: lungs can cause chem pneum which can be fatal. hlth studies have
ing 10: synthetic lubricants pose potntl human hlth risks which may vary
ing 11: to liqs, vaps, mists/fumes should be min. lab animal studies have
ing 12: light hydrocarbon vaps in same naphtha boiling range as prod can
ing 13: however, efts were not observed in similar studies w/female rats
ing 14: studies w/other animal species. additionally, in number of human
ing 15: of such effects at normal occup levels. methyl ethyl ketoxime is
ing 16: toxicological study. lev of chem in prod is at/slightly above
ing 17: used to pvnt skinning of coating in cntnr. avoid cont w/eyes,
ing 18: remove contaminated clothing and shoes. wash clothing before
spill proc: assure conformity w/applic governmental regs. continue to
ing 22: from absorbed material.
other precautions: all label warnings must be observed until container
|
| |
|
|
DURON INC -- 15-015, KWIK SEAL INTERIOR CLEAR POLYURETHANE
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CFSBH
MSDS NAME: 15-015, KWIK SEAL INTERIOR CLEAR POLYURETHANE(SUPDAT)
Responsible Party
Name: DURON INC
Address: 10406 TUCKER ST
City: BELTSVILLE MD 20705-2297
Info Phone: 301-937-4600
Emergency Phone Number: 800-228-5635
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DURON INC
Address: 10406 TUCKER ST
City: BELTSVILLE MD 20705-2297
Phone: 301-937-4600
Name: DURON INC AMERICAN DIV
Address: 10406 TUCKER ST
City: BELTSVILLE MD 20705-2201
Phone: UNKNOWN
=======================================================
Ingredients
=======================================================
Cas: 96-29-7
RTECS #: EL9275000
Name: 2-BUTANONE, OXIME; (METHYL ETHYL KETOXIME)
% Wt: >0.1
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 8052-41-3
RTECS #: WJ8925000
Name: STODDARD SOLVENT
% Wt: <58.4
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM
------------------------------
Name: SYNTHETIC RESIN COMPLEX
% Wt: <40.7
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Name: EXTING MEDIA: IF LEAK/SPILL HAS IGNITED, USE WATER SPRAY TO DISPERSE VAPS
& TO PROT MEN ATTEMPTING TO STOP LEAK.
-----------------------------
Name: ING 5: MINIMIZE BREATHING GASES, VAPORS, FUMES OR DECOMPOSITION PRODUCTS.
-----------------------------
Name: EFTS OF OVEREXP: EFTS OBSERVED IN MALE RATS HAVE SIGNIFICANT IMPLICATIONS
FOR HUMANS AT/BELOW RECOM VAP LIMITS
-----------------------------
Name: ING 7: IN WORKPLACE. SKIN: PRLNGD/RPTD CONT CAN CAUSE MOD IRRIT, DEFAT
&/OR DERM. EYE: CAN CAUSE SEV IRRIT,
-----------------------------
Name: ING 8: REDNESS, TEARING, BLURRED VISION. INGEST: CAN CAUSE GI IRRIT,
NAUS, VOMIT & DIARR. ASPIR OF MATL INTO
-----------------------------
Name: ING 9: LUNGS CAN CAUSE CHEM PNEUM WHICH CAN BE FATAL. HLTH STUDIES HAVE
SHOWN THAT MANY PETRO HYDROCARBONS AND
-----------------------------
Name: ING 10: SYNTHETIC LUBRICANTS POSE POTNTL HUMAN HLTH RISKS WHICH MAY VARY
FROM PERSON TO PERSON. AS PREC, EXPOS
-----------------------------
Name: ING 11: TO LIQS, VAPS, MISTS/FUMES SHOULD BE MIN. LAB ANIMAL STUDIES HAVE
SHOWN THAT PRLNGD & RPTD INHAL TO
-----------------------------
Name: ING 12: LIGHT HYDROCARBON VAPS IN SAME NAPHTHA BOILING RANGE AS PROD CAN
PRDCE ADVERSE KIDNEY EFTS IN MALE RATS.
-----------------------------
Name: ING 13: HOWEVER, EFTS WERE NOT OBSERVED IN SIMILAR STUDIES W/FEMALE RATS
& MALE & FEMALE MICE & IN LIMITED
-----------------------------
Name: ING 14: STUDIES W/OTHER ANIMAL SPECIES. ADDITIONALLY, IN NUMBER OF HUMAN
STUDIES, THERE WAS NO CLINICAL EVIDENCE
-----------------------------
Name: ING 15: OF SUCH EFFECTS AT NORMAL OCCUP LEVELS. METHYL ETHYL KETOXIME IS
LISTED AS POTNTL CARCIN BASED ON
-----------------------------
Name: ING 16: TOXICOLOGICAL STUDY. LEV OF CHEM IN PROD IS AT/SLIGHTLY ABOVE
0.1% ON TOTAL WEIGHT OF COATING. PROD IS
-----------------------------
Name: ING 17: USED TO PVNT SKINNING OF COATING IN CNTNR. AVOID CONT W/EYES,
SKIN & CLTHG. WASH THORO AFTER HNDLG.
-----------------------------
Name: ING 18: REMOVE CONTAMINATED CLOTHING AND SHOES. WASH CLOTHING BEFORE
REUSE.
-----------------------------
Name: SPILL PROC: ASSURE CONFORMITY W/APPLIC GOVERNMENTAL REGS. CONTINUE TO
OBSERVE PRECS FOR VOLATILE, COMBUST VAPS
-----------------------------
Name: ING 22: FROM ABSORBED MATERIAL.
-----------------------------
Name: OTHER PRECAUTIONS: ALL LABEL WARNINGS MUST BE OBSERVED UNTIL CONTAINER
HAS BEEN CLEANED OR DISPOSED OF.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: INHAL: EXCESSIVE INHAL OF VAPS CAN CAUSE NASAL & RESP
IRRIT, DIZZ, WEAKNESS, FATIGUE, NAUS, HDCH. HIGH VAP CONCS MAY RSLT IN CNS
DEPRESS. LAB ANIMAL STUDIES HAVE SHOWN THAT PRLNGD & RPTD INHAL EXPOS T O
LIGHT HYDROCARBON VAPS IN SAME NAPHTHA BOILING RANGE AS THIS PROD CAN PRDCE
ADVERSE KIDNEY EFTS IN (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: MALE RATS. HOWEVER, THESE EFTS
WERE NOT OBSERVED IN SIMILAR STUDIES W/FEMALE RATS & MALE & FEMALE
MICE & IN LIMITED STUDIES W/OTHER ANIMAL SPECIES. ADDITIONALLY, IN NUMBER
OF HUMAN STUDIES, THERE WAS NO CLINICAL EVIDENCE OF SUCH EFTS AT NORMAL
OCCUP LEVS. IT IS THEREFORE HIGHLY UNLIKELY THAT KIDNEY
Medical Cond Aggravated By Exposure: HIGH VAP CONCS (GREATER THAN APPROX 1000
PPM) ARE IRRIT TO EYES & RESP TRACT, MAY CAUSE HEADACHES AND DIZZINESS,
ARE ANESTHETIC, AND MAY HAVE OTHER CENTRAL NERVOUS SYSTEM EFFECTS INCLUDING
DEATH.
First Aid: INHAL: REMOVE VICTIM TO FRESH AIR & PROVIDE OXYGEN IF BRTHG IS
DFCLT. IF BRTHG STOPS, BEGIN ARTF RESP & SEEK IMMED MED ATTN. SKIN:
REMOVE CONTAMD CLTHG/SHOES. FLUSH SKIN W/WATER. FOLLOW BY WASHING W/S OAP
& WATER. IF IRRIT OCCURS, GET MED ATTN. DO NOT REUSE CLTHG UNTIL CLEANED.
EYES: FLUSH W/CLEAR WATER FOR AT LST 15 MINS/UNTIL IRRIT SUBSIDES. IF IRRIT
PERSISTS, CALL PHYS. INGEST: DO NOT (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ELIM ALL IGNIT SOURCES (FLARES, FLAMES INCL PILOT
LIGHTS, ELEC SPARKS). RECOVER FREE PROD. ADD SAND, EARTH/OTHER SUITABLE
ABSORB TO SPILL AREA. MIN SKIN CONT. VENT CONFINED SPACES. KEEP PROD OUT OF
SE WERS & WATERCOURSES BY DIKING/IMPOUNDING.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF PRODUCT IN ACCORDANCE WITH APPLICABLE LOCAL,
COUNTY, STATE AND FEDERAL REGULATIONS.
Handling And Storage Precautions: DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF
CHILDREN. USE W/ADEQ VENT. KEEP AWAY FROM HEAT, SPARKS & OPEN FLAMES.
KEEP CNTNR CLSD WHEN NOT IN USE.
Other Precautions: DO NOT STORE ABOVE 120F. BASED ON PRODS FLASH POINT &
VAP PRESS, SUITABLE STORAGE SHOULD BE PROVIDED I/A/W OSHA REG 1910.106. EMPTY
CNTNRS MAY CONTAIN PROD RESIDUE INCL COMBUST/EXPLO VAPS. DO NOT CUT,
PUNCTURE/WELD ON/NEAR CNTNR.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 104F,40C
Lower Limits: 0.9%
Upper Limits: 6%
Extinguishing Media: USE DRY CHEM, FOAM/CARBON DIOXIDE. WATER MAY BE INEFT, BUT
WATER SHOULD BE USED TO KEEP FIRE-EXPOS CNTNRS COOL.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER MAY BE UNSUITABLE AS AN EXTING MEDIA, BUT HELPFUL IN KEEPING ADJACENT
CNTNRS COOL. AVOID SPREADING(SUPDAT)
Unusual Fire/Explosion Hazard: VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, OTHER FLAME
& IGNIT SOURCES AT LOCATIONS DISTANT FROM HNDLG(SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE OF RESPIRATORY PROTECTION DEPENDS ON VAPOR
CONCENTRATION ABOVE TIME WEIGHTED TLV: USE NIOSH APPROVED RESPIRATOR.
Ventilation: PROVIDE SUFFICIENT MECHANICAL (GENERAL) AND/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves: CHEMICAL RESISTANT PLASTIC OR RUBBER.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N).
Work Hygienic Practices: DO NOT EAT, DRINK OR SMOKE WHILE USING PRODUCT.
THOROUGHLY WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health: TRADE NAME/PART #: SEALER/FINISH. FIRE FIGHT
PROC: BURNING LIQ W/WATER USED FOR COOLING. EXPLO HAZ: POINT. NEVER USE
WELDING/CUTTING TORCH ON/NEAR CNTNR (EVEN EMPTY) BECAUSE VAPS MAY IGNITE.
FIRST AID PROC: INDUCE VOMIT. IF VOMIT OCCURS SPONT, KEEP HEAD BELOW HIPS TO
PVNT ASPIR OF LIQ INTO LUNGS. GET MED ATTN.
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: 2 @ 20F
Vapor Density: 4.9
Spec Gravity: .88
VOC Grams/Liter: 517
Evaporation Rate & Reference: 0.1 (BUTYL ACETATE=1)
Solubility in Water: NEGLIGIBLE;
Appearance and Odor: VISCOUS LIQUID, HYDROCARBON ODOR.
Percent Volatiles by Volume: 66.25
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDIZING AGENTS, STRONG ACIDS OR BASES AND SELECTED
AMINES.
Hazardous Decomposition Products: THERMAL DECOMPOSITION IN PRESENCE OF AIR MAY
YIELD CARBON MONOXIDE AND/OR CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: VOLATILE ORGANIC COMPOUND: 4.31 LBS/GAL; 517 GRAMS/LITER
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 15-015, KWIK SEAL INTERIOR CLEAR POLYURETHANE(SUPDAT)
Company: DURON INC
Street: 10406 TUCKER ST
City: BELTSVILLE MD
Zipcode: 20705-2297
Health Emergency Phone: 800-228-5635
Label Required IND: Y
Date Of Label Review: 11/12/1997
Status Code: C
Label Date: 11/12/1997
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE: INHAL: EXCESSIVE INHAL OF VAPS CAN
CAUSE NASAL & RESP IRRIT, DIZZ, WEAKNESS, FATIGUE, NAUS, HDCH. HIGH VAP
CONCS MAY RSLT IN CNS DEPRESS. SKIN: IRRITATION. EYES: SEVERE IRRITATION,
REDNESS, TEARING, BLURRED VISION. INGESTION: GI IRRITATION, NAUSEA, VOMITING,
DIARRHEA. CHRONIC: SKIN: DERMATITIS.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|