MINOLTA CORPORATION -- CF, TONER, K1, CF910
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJKXH
MSDS NAME: CF, TONER, K1, CF910
Responsible Party
Name: MINOLTA CORPORATION
Address: 101 WILLIAMS DRIVE
City: RAMSEY NJ 07446
Info Phone: 201-825-4000
Emergency Phone Number: 201-825-4000
Resp. Party Other MSDS No.: PPC-032
Proprietary Ind: Y
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: MINOLTA CORPORATION
Address: 101 WILLIAMS DRIVE
City: RAMSEY NJ 07446
Phone: 201-825-4000
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50: (ORAL, RAT) >2 G/KG
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: THIS TONER IS NOT CLASSIFIED AS A HUMAN CARCINOGEN. NO
SYMPTOMS EXPECTED WITH INTENDED USE.
Explanation Of Carcinogenicity: CARBON BLACK: IARC MONOGRAPHS, VOL 69, PG 149,
1996: GROUP 2B.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: INHAL: IF SYMPTOMS ARE EXPERIENCED, REMOVE SOURCE OF CONTAM OR MOVE
VICTIM TO FRESH AIR & OBTAIN MED ADVICE. SKIN CNTCT: FLUSH W/GENTLY
FLOWING WATER (PREFERABLY LUKEWARM) & SOAP FOR 15 MIN OR UNTIL P ARTICLE
IS REMOVED. IF IRRIT DOES OCCUR, OBTAIN MED ADVICE. EYE CNTCT: DO NOT ALLOW
VICTIM TO RUB EYE(S). FLUSH W/GENTLY FLOWING WATER (PREFERABLY LUKEWARM) FOR
AT LEAST 15 MIN OR UNTIL PARTICLE IS RE MOVED. HAVE VICTIM LOOK RIGHT &
LEFT, &, THEN UP & DOWN. IF IRRIT DOES OCCUR, OBTAIN MED ATTN. DO NOT
ATTEMPT TO MANUALLY REMOVE ANYTHING STUCK TO THE EYE(S). INGEST: IF IRRIT OR
DISCOMFORT OCCURS, OB TAIN MED ATTN IMMED. NOTE TO MD: NONE.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PERSONAL PRECAUTIONS: NONE. ENVIRONMENTAL
PRECAUTIONS: NONE. METHODS FOR CLEANING UP: WIPE OFF WITH PAPER OR CLOTH. DO
NOT USE VACUUM CLEANER WHEN A LARGE AMOUNT IS RELEASED. IT, LIKE MOST FINELY
DIVI DED ORGANIC POWDERS, MAY CREATE A DUST EXPLOSION. FURTHER INFORMATION:
NONE.
Waste Disposal Methods: PREPARATION (COMMUNITY PROVISIONS): WASTE MAY BE
DISPOSED OR INCINERATED UNDER CONDITIONS WHICH MEET ALL FEDERAL, STATE AND
LOCAL ENVIRONMENTAL REGULATIONS. CONTAMINATED PACKAGING: WASTE MAY BE DISPOS
ED OR INCINERATED UNDER CONDITIONS WHICH MEET ALL FEDERAL, STATE AND LOCAL
ENVIRONMENTAL REGULATIONS .
Handling And Storage Precautions: HANDLING: TECHNICAL MEASURES:NONE. PRECS:
NONE. SAFE HANDLING ADVICE: TRY NOT TO DISPERSE PARTICLES. STORAGE: TECHNICAL
MEASURES:NONE. STORAGE CNDTNS: KEEP CNTNR CLOSED. STORE IN COOL & DRY
PLACE. INC OMPAT PRODS:NONE. PACKING MATLS: BOTTLES OR CARTRIDGE DESIGNATED
BY MINOLTA. FURTHER INFO:NONE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Text: NONE
Extinguishing Media: CARBON DIOXIDE, WATER SPRAY, FOAM AND DRY CHEMICAL. AVOID
FULL WATER JET.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). SPECIAL FIREFIGHTING PROCEDURES: NONE.
Unusual Fire/Explosion Hazard: IF DISPERSED IN AIR, LIKE MOST FINELY DIVIDED
ORGANIC POWDERS, MAY FORM AN EXPLOSIVE MIXTURE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NONE REQUIRED WHEN USED AS INTENDED IN MINOLTA EQUIPMENT.
Ventilation: NONE REQUIRED W/INTENDED USE. CONTROL PARAMETERS (AS TOTAL DUST):
OSHA-PEL(USA): 15MG/M3; ACGIH-TLV(USA): 10MG/M3. DFG-MAK(EC): 6MG/M3;
WORKSAFE-TWA (SUPDAT)
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: EYE WASH & DELUGE SHOWER MTG ANSI DESIGN CRITERIA
(FP N). FOR USE OTHER THAN NORMAL CUSTOMER-OPERATING PROCEDURES (SUCH AS IN
BULK TONER PROCESSING FACILITIES), GOGGLES & NIOSH APPRVD RESPS MAY BE RQD.
Work Hygienic Practices: WASH HANDS AFTER HANDLING.
Supplemental Safety and Health: VENT: (AUSTL.): 10 MG/M3. TOXICOLOGICAL INFO:
TYPICAL TONER, MILD TO MOD DEGREE OF LUNG FIBROSIS OBSERVED IN 92% OF RATS IN
HIGH CONC (16MG/M3) EXPOS GROUP, & MINIMAL TO MILD DEGREE OF FIBROSIS
NOTED IN 22% OF ANIMALS IN MIDDLE (4MG/M3) EXPOS GROUP. BUT NO PULM CHANGE
REPORTED IN LOWEST (1MG/M3) (TRANSPORT INFO)
=======================================================
Physical/Chemical Properties
=======================================================
M.P/F.P Text: NO DATA AVAIL
Spec Gravity: 1.1
Solubility in Water: NEGLIGIBLE
Appearance and Odor: BLACK POWDER; FAINT ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ELECTRONIC DISCHARGE, THROWING INTO FIRE.
Materials To Avoid: OXIDIZING MATERIALS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE. HAZARDOUS
REACTIONS: DUST EXPLOSION, LIKE MOST FINELY DIVIDED ORGANIC POWDERS.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: ACUTE TOX: INHAL, LC50 (G/M3/4H): >5.02 (RATS).
(THIS WAS HIGHEST ATTAINABLE CONC.) INGEST (ORAL), LD50 (G/KG): >2 (RATS).
DERMAL, LD50 (G/KG): NO DATA AVAIL. EYE IRRIT: MINIMAL IRRITANT (RABBITS). SK
IN IRRIT: NOT AN IRRITANT (RABBITS). SKIN SENSIT: NO SIGNS (GUINEA PIG).
MUTAGENICITY: NEG (AMES TEST). CHRONIC TOX OR LONG TERM TOX: PRLNGD INHAL OF
EXCESSIVE DUST MAY CAUSE LUNG DMG. IT IS ATTRIBUTE D TO "LUNG OVERLOADING,"
GENERIC RESPONSE TO EXCESSIVE AMTS OF ANY DUST RETAINED IN LUNGS FOR PRLNGD
INTERVAL. USE OF PROD, AS INTENDED, DOES NOT RSLT IN INHAL OF EXCESSIVE DUST.
IN STUDY IN RATS BY C HRONIC INHAL EXPOS TO (SUPDAT)
=======================================================
Ecological Information
=======================================================
Ecological: MOBILITY: NO DATA AVAIL ON ADVERSE EFTS OF THIS MATL ON
ENVIRONMENT. PERSISTENCE/DEGRADABILITY: NO DATA AVAIL ON ADVERSE EFTS OF MATL
ON ENVIRONMENT. BIOACCUMULATION:NO DATA AVAIL ON ADVERSE EFTS OF M ATL ON
ENVIRONMENT. BEHAVIOR IN SEWAGE WORKS:NO DATAL AVAIL ON ADVERSE EFTS OF MATL
ON ENVIRONMENT. AQ TOX:NO DATA AVAIL ON ADVERSE EFTS OF MATL ON ENVIRONMENT.
ECOLOGICAL DATA (EC) - CSB VALUE (EC) N O DATA AVAIL ON ADVERSE EFTS OF MATL
ON ENVIRONMENT. AOX-REMARD (EC):NO DATA AVAIL ON ADVERSE EFTS OF MATL ON
ENVIRONMENT. BSB5 VALUE (EC):NO DATA AVAIL ON ADVERSE EFTS OF MATL ON
ENVIRONMENT. SIGNIFI CANT COMPONENTS (EC):NOT APPLIC.
=======================================================
MSDS Transport Information
=======================================================
Transport Information: SPECIAL PRECS: NONE. INFO ON CODE & CLASSIFICATIONS
ACCORDING TO INTERNATIONAL REGS. UN CLASSIFICATION: NONE. LAND - RID (EC):
NONE. ADR (EC): NONE. DOT (USA): NONE. INLAND WATERWAYS - ADNR (RHINE R):
NONE. SEA - IMDG: NONE. AIR - ICAO-TI: NONE. IATA-DGR: NONE.-- SUPDAT: EXPOS
GROUP, THE MOST RELEVANT LEVEL TO POTNTL HUMAN EXPOS. IN 1996, IARC
REEVALUATED CARBON BLACK AS GROUP 2B CARCIN (POSS HUMA N CARCIN). THIS
EVALUATION IS GIVEN TO CARBON BLACK, FOR WHICH THERE IS INADEQ HUMAN EVID,
BUT SUFFICIENT ANIMAL EVID. LATTER IS BASED UPON DEVELOPMENT OF LUNG TUMORS
IN RATS RECEIVING CHRONIC INHAL E XPOS TO (STATE REG INFO)
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA TITLE III - 302 EXTREMELY HAZ SUBSTANCE: NONE.
311/312 HAZ CATEGORIES: NONE. 313 REPORTABLE INGREDS: NONE.--- TRANSPORT
INFO: FREE CARBON BLACK AT LEVELS THAT INDUCE PARTICLE OVERLOAD OF LUNG. ST
UDIES PERFORMED IN ANIMAL MODELS OTHER THAN RATS HAVE NOT DEMONSTRATED AN
ASSOCIATION BETWEEN CARBON BLACK & LUNG TUMORS. MOVEOVER, A TWO-YEAR
CANCER BIOASSAY USING TYPICAL TONER PREPARATION CONTAININ G CARBON BLACK
DEMONSTRATED NO ASSOCIATION BETWEEN TONER EXPOS & TUMOR DEVELOPMENT IN
RATS.
Federal Regulatory Information: INFO ON LABEL: NOT REQD. TSCA (TOX SUBSTANCES
CONTROL ACT): ALL CHEM SUBSTANCES IN PROD COMPLY W/ALL APPLIC RULES/ORDERS
UNDER TSCA. EU INFO: INFO ON LABEL (88/379/EEC & 67/548/EEC): SYMBOL
& INDICATI ON: NOT REQD. R/S-PHRASE: NOT REQD. 76/769/EEC: ALL CHEM
SUBSTANCES IN PROD COMPLY W/ALL APPLIC RULES/ORDER UNDER 76/769/EEC.-- OTHER
INFO: H. MULHE, B. BELLMAN, O. CREUTZENBER, C. DASENBROCK, H. ERNS T, R.
KILPEPPER, J.C. MACKENZIE, P. MORROW, U. MOHR, S. TAKENAKA, & R.
MERMELSTEIN (1991), PULM RESP ONSE TO TONER UPON CHRONIC INHAL EXPOS IN RATS.
FUNDAMENTAL & APPLIED TOXICOLOGY 17, PP 280-299.
State Regulatory Information: THIS PRODUCT CONTAINS NO CHEMICAL SUBSTANCES
SUBJECT TO CALIFORNIA PROPOSITION 65.
=======================================================
Other Information
=======================================================
Other Information: NFPA HAZ RATING: NATL FIRE PROT AGENCY (USA): HEALTH: 1;
FLAMMABILITY: 1; REACTIVITY: 0. RATING: NATIONAL PAINT & COATING ASSOC
(USA): HEALTH: 1; FLAMM: 1; REACTIVITY: 0. LITERATURE REFS: ANSI Z4
00.1-1993. TRGS 220: SICHERHEITSDATENBLATT FUR GEFAHRLICHE STOFFE UND
ZUBEREITUNGEN. ISO 11014-1. COMMISSION DIRECTIVE 91/155/EEC. MSDS: PRACT
GUIDE TO FIRST AID: CANADIAN CENTRE FOR OCCUP HLTH & SFTY 'S PUB,
IMPLEMENTATION MANUAL: NATIONAL PAINT & COATINGS ASSOC. IARC (1996): IARC
MONO ON EVAL OF CARCIN RISK OF CHEMS TO HUMANS, VOL 65, PRINTING PROCESS
& PRINTING INKS, CARBON BLACK & SOME NIT RO CMPDS, LYON, PP 149-26.
(FED REGS)
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: CF, TONER, K1, CF910
Company: MINOLTA CORPORATION
Street: 101 WILLIAMS DRIVE
City: RAMSEY NJ
Zipcode: 07446
Health Emergency Phone: 201-825-4000
Label Required IND: Y
Date Of Label Review: 08/27/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: None
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: NO SYMPTOMS EXPECTED WITH INTENDED USE. CHRONIC:
CANCER HAZARD. CONTAINS CARBON BLACK WHICH IS LISTED AS AN ANIMAL LUNG
CARCINOGEN (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 51147
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 51299
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 51991
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 110
| |
|
ELECTRONIC CLEANER
| 1717-00-6
67-63-0
124-38-9 |
|
PIPEMASTER 70
| 7439-89-6
13463-67-7
546-93-0
14808-60-7
69012-64-2
7439-96-5
7440-02-0
9004-34-6 |
|
PIPEMASTER 90
| 7439-89-6
13463-67-7
546-93-0
14808-60-7
69012-64-2
7439-96-5
7440-02-0
9004-34-6 |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANTS, 111
| |
|
WATERCLEAN, 2200/W
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 125
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRIACANT, 126
| |
|
CF, TONER, K1, CF910
| |
|
CF TONER K1, CF911P
| |
|
CC-4 AND CC-55 (CABLE CLEANER - BULK LIQUID)
| 64771-72-8
5989-27-5 |
|
PHOTOCONDUCTOR, CF910
| |
|
AR-GLO 1, AR-GLO 2, AR-GLO 3, AR-GLO 4, LEAK DETECTION
| |
|
SCOTCH-GRIP 847 RUBBER AND GASKET ADHESIVE
| 67-64-1
9003-18-3
9003-35-4
8050-31-5
69-72-7
1314-13-2
68411-46-1 |
|
TELEDYNE BATTERY, GILL AIRCRAFT BATTERY, CENTURION, BIG BEAM
| 7664-93-9
7439-92-1
7440-36-0
7440-38-2
7727-43-7
7440-70-2
1333-86-4
7786-81-4
7440-31-5 |
|
BREAK-FREE CLP LIQUID (NON-CHLORINATED FORMULA)
| |
|
P-D 680A, TYPE III, DRY CLEANING SOLVENT
| |
|
PERMA-SILK G AEROSOL (10-117)
| |
|
46482,DOWELANCO DURSBAN PRO INSECTICIDE
| |
|
"EPA 2000" WCI-140 CM
| |
|
TEMPO 2 EC
| |
|
MERCURY-ZINC, E-1, E-1R, AX-1, AX-1R
| 1313-13-9
1310-58-3
7440-66-6
21908-53-2 |
|
ANTIFREEZE, ETHYLENE GLYCOL, INHIBITED HEAVY DUTY
| |
|
ACRYLIC EXTERIOR PAINT 524-AUTUMN RED
| |
|
MASH, 1799
| |
|
HARDENER HY 837, PART B
| |
|
SEALBRITE, 300/SB
| |
|
DEEP COLORS INTERIOR STAIN FINISH, ACCENT BASE 279
| |
|
FAST-DRYING POLYURETHANE-ALL SHEENS, M060813
| |
|
DEKA RETARDER/FLOW ENHANCER 1001/1002M
| 7732-18-5
56-81-5
57-55-6
63148-62-9 |
|
CERASET SN INORGANIC POLYMER
| |
|
CF STARTER K1, CF910
| |
|
PORTLAND CEMENT, HYDRAULIC CEMENT
| 12168-85-3
10034-77-2
12068-35-8
7778-18-9
12042-78-3
1317-65-3
1309-48-4
1305-78-8
14808-60-7 |
|
QUROX, 1596
| |
|
INDUSTRIAL MAINTENANCE LATEX TRAFFIC MARKING PAINT, 270A100
| |
|
SUPER RR-I ENGINE OIL SAE 40, 3756040000
| |
|
EASY TOUCH ACOUSTIC MEDIUM 4080
| 1317-65-3
10101-41-4
1332-58-7
14807-96-6
93763-70-3
12001-26-2
1318-00-9 |
|
CF STARTER K1, CF911P
| |
|
WINSOR & NEWTON GALERIA ACRYLICS (ALL COLORS IN RANGE)
| 7664-41-7 |
|
ACRYLIC EXTERIOR PAINT 524-AUTUMN RED
| |
|
LS 10 LIQUID SHIELD
| |
|
EXTRACTOR CONCENTRATE, 777
| |
|
MASTER ORGANIC
| |
|
FLUID C MEDIUM DUTY (M-16)
| 102-71-6
61791-00-2
111-42-2
67952-33-4 |
|
89902 TRIAD TRUTRAY CUSTOM TRAY MATERIAL
| |
|
89904 TRIAD TRUTRAY CUSTOM TRAY MATERIAL
| |
|
90130 TRIAD TRUTRAY CUSTOM TRAY MATERIAL
| |
|
|