COMMODORE POLYMER TECHNOLOGIES -- CERASET SN INORGANIC POLYMER
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJLCT
MSDS NAME: CERASET SN INORGANIC POLYMER
Responsible Party
Name: COMMODORE POLYMER TECHNOLOGIES
Address: 1475 DALASHMUT AVE
City: COLUMBUS OH 43212
Info Phone: 614-297-0365
Emergency Phone Number: 614-297-0365
Proprietary Ind: Y
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: COMMODORE POLYMER TECHNOLOGIES
Address: 1475 DALASHMUT AVE
City: COLUMBUS OH 43212
Phone: 614-297-0365
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Name: *** PROPRIETARY ***
-----------------------------
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYES: IRRITATION WITH REDNESS, PAIN AND BLURRED VISION.
SKIN: IRRITATION WITH REDNESS, PAIN AND BLISTERING. INHALATION: IRRITATION.
INGESTION: NONE KNOWN. NOTE: CONTACT OF THIS PRODUCT OR ITS VAPORS W ITH
MOISTURE CAN PRODUCE AMMONIA, WHICH CAN CAUSE IRRITATION OF THE EYES, SKIN,
NOSE, THROAT, LUNGS, ETC.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE KNOWN.
First Aid: INHALATION: REMOVE TO FRESH AIR. TREAT ANY IRRITATION
SYMPTOMATICALLY. CONTACT A PHYSICIAN. EYES: IN CASE OF CONTACT, IMMEDIATELY
FLUSH WITH PLENTY OF LOW PRESSURE WATER FOR AT LEAST 15 MINUTES. REMOV E ANY
CONTACT LENSES TO ENSURE THOROUGH FLUSHING. CONTACT A PHYSICIAN. SKIN:
PROMPTLY WASH WITH SOAP AND RUNNING WATER. REMOVE CONTAMINATED CLOTHING. WASH
CLOTHING BEFORE REUSE. INGESTION: IF SUBJECT IS CONSCIOUS, GIVE SUBJECT
LARGE QUANTITIES OF WATER TO DILUTE THIS PRODUCT. CONTACT A PHYSICIAN. NEVER
GIVE LIQUIDS TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: SMALL SPILLS: ADD INERT ABSORBENT, SWEEP UP, AND
PLACE THE MATERIAL IN COMBUSTIBLE CONTAINERS FOR DISPOSAL. LARGE SPILLS: DIKE
TO CONTAIN AND PUMP INTO DRUMS FOR USE OR DISPOSAL. WORKERS SHOULD WEAR T HE
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT WHEN HANDLING ANY SPILLS.
Waste Disposal Methods: INCINERATION OF COMBUSTIBLE WASTE MATERIAL IN A
PERMITTED FACILITY IN ACCORDANCE WITH LOCAL, STATE & FEDERAL REGULATIONS
IS THE RECOMMENDED DISPOSAL METHOD; NOTE, HOWEVER, THAT THIS MATERIAL IS NOT
CO NSIDERED AN RCRA HAZARDOUS WASTE. REFER TO SECTION 12 FOR SPECIFIC FEDERAL
ENVIRONMENTAL & REGULATOR Y DATA REGARDING USE OR DISPOSAL OF THIS
PRODUCT.
Handling And Storage Precautions: STORE IN A COOL, DRY PLACE. KEEP CONTAINER
TIGHTLY CLOSED. KEEP AWAY FROM HEAT AND FLAME. THIS PRODUCT MAY REACT WITH
WATER, MINERAL ACIDS, ALKALIES OR OXIDIZING AGENTS AND SHOULD NOT BE STORED
NEAR S UCH MATERIALS.
Other Precautions: PROTECTIVE MEASURES DURING REPAIR AND MAINTENANCE:
COMPLETELY ISOLATE AND THOROUGHLY CLEAN ALL EQUIPMENT, PIPING OR VESSELS WITH
HIGH FLASH POINT NONPOLAR SOLVENTS BEFORE BEGINNING MAINTENANCE OR REPA IRS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point: =75.C, 167.F
Extinguishing Media: WATER SPRAY, DRY CHEMICAL, FOAM, CARBON DIOXIDE OR HALON.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N).
Unusual Fire/Explosion Hazard: CAUTION! COMBUSTIBLE LIQUID. HAZARDOUS PRODUCTS
OF COMBUSTION: DEPENDING ON COMBUSTION CONDITIONS, CARBON DIOXIDE, CARBON
MONOXIDE, INCOMPLETELY BURNED CARBON PRODUCTS, NITROGEN OXIDES AND SILICON
DIO XIDE MAY BE PRODUCED.
=======================================================
Control Measures
=======================================================
Respiratory Protection: WHEN AIR CONTAMINANTS EXCEED ACCEPTABLE CRITERIA, USE
NIOSH APPROVED RESPIRATORY PROTECTION EQUIPMENT. RESPIRATORS SHOULD BE
SELECTED BASED ON THE FORM AND CONCENTRATION OF CONTAMINANTS IN AIR IN ACCO
RDANCE WITH OSHA 29 CFR 1910.134 OR OTHER APPLICABLE STANDARDS OR GUIDELINES.
Ventilation: PROVIDE ADEQ GEN OR LOC EXHST VENT OT MAINTAIN AIR CONTAMINANTS AT
AN ACCEPTABLY LOW LEVEL. SEE 29 CFR 1910.94 (VENT) & 29 CFR 1910.1000
(SUPDAT)
Protective Gloves: IMPERVIOUS GLOVES.
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: EYE WASH AND DELUGE SHOWER MEETING ANSI DESIGN
CRITERIA (FP N). A LONG-SLEEVE SHIRT AND AN APRON ARE RECOMMENDED ATTIRE.
Supplemental Safety and Health: VENT: (AIR CONTAMINANTS). DISCHARGE FROM VENT
SYS SHOULD COMPLY W/APPLIC AIR POLLUTION CONTROL REGS. APPEAR/ODOR: TO
AMMONIA-LIKE SMELL. FED REG INFO: LISTED ON THE EPA/TSCA INVENTORY OF
CHEMICAL SUBS TANCES.
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: NOT DETERMINED
Melt/Freeze Pt: <-78.C, -108.4F
Vapor Pres: NOT DETERMINED
Spec Gravity: 0.9-1.0
Evaporation Rate & Reference: SLOWER THAN BUTYL ACETATE
Solubility in Water: MODERATE; REACTS SLOWLY
Appearance and Odor: CLEAR, COLORLESS TO YELLOW LIQUID; ODOR RANGES FROM "MUSTY
AMINE" (SUPDAT)
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STABLE IN DRY AIR AT ATMOSPHERIC PRESSURES FROM
AT LEAST FREEZING POINT (
Materials To Avoid: INCOMPATIBLE WITH MINERAL ACIDS, ALKALIES, WATER OR
OXIDIZING AGENTS.
Hazardous Decomposition Products: AMMONIA, SILOXANES, METHANE AND ETHYLENE.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: REPORTED HUMAN EFTS: USE OF RECOM PROT EQUIP SHOULD
PVNT ANY ADVERSE EFTS. REPORTED ANIMAL EFTS: THIS SILAZANE-BASED POLYMER HAS
NOT BEEN TESTED, BUT SIMILAR SILAZANE POLYMER HAD ORAL LD50 IN RATS BET WEEN
500 & 5000 MG/KG & DERMAL LD50 INRABBITS BETWEEN 700 & 2000
MG/KG. IT WAS SEV PRIMARY SKIN IRRITANT CAUSING IMMED & LONG LASTING
(>14 DAYS) REDNESS, SWELL & SCABBING FOLLOWING SINGLE 24-HR EXPOS.
HOWEVER, IT CAUSED ONLY SLIGHT TO MOD EYE IRRIT W/OUT CORNEAL INVOLVEMENT.
OTHER POLYSILAZANES ARE SIMILARLY REPORTED TO HAVE POTNTL TO IRRITATE EYES
& SKIN.
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA (2) TITLE III: SEC 304/EHS/TPQ (LBS): N/A. SEC
304/EHS/RQ (LBS): N/A. SEC 311/312 HAZARD CATEGORY: HC-1, HC-3. SEC 313 TOXIC
CHEMICAL: NO.
Federal Regulatory Information: PROD DOES NOT CNTN ANY HAZ SUBSTANCES LISTED IN
40 CFR 302.4. FURTHER, IT DOES NOT EXHIBIT ANY HAZ CHARACTS LISTED IN 40 CFR
261 C. THUS, PROD IS NOT SUBJECT TO FED REG UNDER CERCLA AS HAZ SUBSTANCE.
STATE/LOC HAZ SUBSTANCE REGS MAY APPLY IF THEYDIFFER FROM FED REG. PROD IS
NOT LISTED IN FED HAZ WASTE REG 40 CFR 261.33(E) OR (F) - IE, CHEM PRODS
CONSIDERED HAZ IF THEY BECOME WASTES. IT DOES NOT EX HIBIT ANY OF HAZ
CHARACTS LISTED IN 40 CFR 261 C. THUS, PROD IS NOT SUBJECT TO FED REG UNDER
RCRA AS HAZ WASTE. STATE/LOC HAZ WASTE REGS MAY APPLY IF THEY DIFFER FROM
FED REG. THIS MATL COMPRISES CHEM SUBSTANCE WHICH IS (SUPDAT)
State Regulatory Information: THIS MATERIAL IS NOT LISTED AS HAZARDOUS
SUBSTANCE IN THE PENNSYLVANIA DEPARTMENT OF LABOR AND INDUSTRY'S PUBLICATION
RTKY691, REV 1-90, DATED JANUARY 1990. MOREOVER, THIS MATERIAL IS NOT ON THE
CALIF ORNIA PROPOSITION 65 LIST, IE CHEMICALS WHICH ARE KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
=======================================================
Other Information
=======================================================
Other Information: RATINGS: HEALTH HAZARD-3 (SERIOUS); FLAMMABILITY HAZARD: 2
(MODERATE); REACTIVITY HAZARD: 1 (SLIGHT).
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: CERASET SN INORGANIC POLYMER
Assigned IND: Y
Company: COMMODORE POLYMER TECHNOLOGIES
Street: 1475 DALASHMUT AVE
City: COLUMBUS OH
Zipcode: 43212
Health Emergency Phone: 614-297-0365
Label Required IND: Y
Date Of Label Review: 06/02/1999
Status Code: A
Origination Code: F
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE: EYES: IRRITATION WITH REDNESS, PAIN AND BLURRED
VISION. SKIN: IRRITATION WITH REDNESS, PAIN AND BLISTERING. INHALATION:
IRRITATION. INGESTION: NONE KNOWN. NOTE: CONTACT OF THIS PRODUCT OR ITS V
APORS WITH MOISTURE CAN PRODUCE AMMONIA, WHICH CAN CAUSE IRRITATION OF THE
EYES, SKIN, NOSE, THROAT, LUNGS, ETC. CHRONIC: NONE SPECIFIED BY MANUFACTURER
(FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 51147
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 51299
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 51991
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 110
| |
|
ELECTRONIC CLEANER
| 1717-00-6
67-63-0
124-38-9 |
|
PIPEMASTER 70
| 7439-89-6
13463-67-7
546-93-0
14808-60-7
69012-64-2
7439-96-5
7440-02-0
9004-34-6 |
|
PIPEMASTER 90
| 7439-89-6
13463-67-7
546-93-0
14808-60-7
69012-64-2
7439-96-5
7440-02-0
9004-34-6 |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANTS, 111
| |
|
WATERCLEAN, 2200/W
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRICANT, 125
| |
|
C-5A ANTISEIZE, ANTI-SEIZE LUBRIACANT, 126
| |
|
CF, TONER, K1, CF910
| |
|
CF TONER K1, CF911P
| |
|
CC-4 AND CC-55 (CABLE CLEANER - BULK LIQUID)
| 64771-72-8
5989-27-5 |
|
PHOTOCONDUCTOR, CF910
| |
|
AR-GLO 1, AR-GLO 2, AR-GLO 3, AR-GLO 4, LEAK DETECTION
| |
|
SCOTCH-GRIP 847 RUBBER AND GASKET ADHESIVE
| 67-64-1
9003-18-3
9003-35-4
8050-31-5
69-72-7
1314-13-2
68411-46-1 |
|
TELEDYNE BATTERY, GILL AIRCRAFT BATTERY, CENTURION, BIG BEAM
| 7664-93-9
7439-92-1
7440-36-0
7440-38-2
7727-43-7
7440-70-2
1333-86-4
7786-81-4
7440-31-5 |
|
BREAK-FREE CLP LIQUID (NON-CHLORINATED FORMULA)
| |
|
P-D 680A, TYPE III, DRY CLEANING SOLVENT
| |
|
PERMA-SILK G AEROSOL (10-117)
| |
|
46482,DOWELANCO DURSBAN PRO INSECTICIDE
| |
|
"EPA 2000" WCI-140 CM
| |
|
TEMPO 2 EC
| |
|
MERCURY-ZINC, E-1, E-1R, AX-1, AX-1R
| 1313-13-9
1310-58-3
7440-66-6
21908-53-2 |
|
ANTIFREEZE, ETHYLENE GLYCOL, INHIBITED HEAVY DUTY
| |
|
ACRYLIC EXTERIOR PAINT 524-AUTUMN RED
| |
|
MASH, 1799
| |
|
HARDENER HY 837, PART B
| |
|
SEALBRITE, 300/SB
| |
|
DEEP COLORS INTERIOR STAIN FINISH, ACCENT BASE 279
| |
|
FAST-DRYING POLYURETHANE-ALL SHEENS, M060813
| |
|
DEKA RETARDER/FLOW ENHANCER 1001/1002M
| 7732-18-5
56-81-5
57-55-6
63148-62-9 |
|
CERASET SN INORGANIC POLYMER
| |
|
CF STARTER K1, CF910
| |
|
PORTLAND CEMENT, HYDRAULIC CEMENT
| 12168-85-3
10034-77-2
12068-35-8
7778-18-9
12042-78-3
1317-65-3
1309-48-4
1305-78-8
14808-60-7 |
|
QUROX, 1596
| |
|
INDUSTRIAL MAINTENANCE LATEX TRAFFIC MARKING PAINT, 270A100
| |
|
SUPER RR-I ENGINE OIL SAE 40, 3756040000
| |
|
EASY TOUCH ACOUSTIC MEDIUM 4080
| 1317-65-3
10101-41-4
1332-58-7
14807-96-6
93763-70-3
12001-26-2
1318-00-9 |
|
CF STARTER K1, CF911P
| |
|
WINSOR & NEWTON GALERIA ACRYLICS (ALL COLORS IN RANGE)
| 7664-41-7 |
|
ACRYLIC EXTERIOR PAINT 524-AUTUMN RED
| |
|
LS 10 LIQUID SHIELD
| |
|
EXTRACTOR CONCENTRATE, 777
| |
|
MASTER ORGANIC
| |
|
FLUID C MEDIUM DUTY (M-16)
| 102-71-6
61791-00-2
111-42-2
67952-33-4 |
|
89902 TRIAD TRUTRAY CUSTOM TRAY MATERIAL
| |
|
89904 TRIAD TRUTRAY CUSTOM TRAY MATERIAL
| |
|
90130 TRIAD TRUTRAY CUSTOM TRAY MATERIAL
| |
|
|