LORD CORPORATION -- LORD 206
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJLNZ
MSDS NAME: LORD 206
Responsible Party
Name: LORD CORPORATION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514
Info Phone: 814-868-3611
Emergency Phone Number: 814-763-2345
Proprietary Ind: Y
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514-0038
Phone: 814-868-3611
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Name: *** PROPRIETARY ***
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NO DATA.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: EYES: CAUSES EYE IRRITATION. SKIN: MAY BE ABSORBED
THROUGH THE SKIN IN HARMFUL AMOUNTS. MAY CAUSE SKIN SENSITIZATION. MAY CAUSE
DERMATITIS. CAUSES SKIN IRRITATION. INHALATION: MAY CAUSE HEADACH E AND
NAUSEA. CAUSES RESPIRATORY TRACT IRRITATION. INGESTION: HARMFUL IF SWALLOWED.
INGESTION IS NOT AN EXPECTED ROUTE OF ENTRY IN INDUSTRIAL OR COMMERCIAL USES.
CHRONIC: MAY CAUSE LIVER OR KIDNEY DAM AGE. CHRONIC SKIN CONTACT MAY CAUSE
DERMATITIS.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: EYES: FLUSH IMMEDIATELY W/LARGE AMOUNT OF WATER FOR AT LEAST 15
MINUTES HOLDING EYELIDS OPEN WHILE FLUSHING. GET PROMPT MEDICAL ATTN. SKIN:
FLUSH CONTAMINATED SKIN W/LARGE AMOUNTS OF WATER WHILE REMOV ING CONTAMINATED
CLOTHING. WASH AFFECTED SKIN AREAS W/SOAP & WATER. GET MEDICAL ATTN IF
SYMPTOMS OCCUR. INHAL: MOVE TO FRESH AIR. RESTORE & SUPPORT CONTINUED
BREATHING. IF BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL
ATTN. INGEST: IF SWALLOWED, DO NOT INDUCE VOMITING. GIVE 1-2 GLASSES OF
WATER/MILK. CALL MD/POISON CONTROL CENTER IMMEDIATELY FOR FURTHER
INSTRUCTIONS. NEVER GIVE ANYTHI NG BY MOUTH TO AN UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP NON-ESSENTIAL PERS A SAFE DIST AWAY FROM SPILL
AREA. REMOVE ALL SOURCES OF IGNIT (FLAME, HOT SURFACES, & ELEC,
STATIC/FRICTIONAL SPARKS). AVOID BREATHING VAPS. USE NIOSH APPRVD
SELF-CONTAINED BRE ATHING EQUIP. NOTIFY APPROP AUTHORITIES IF NEC. AVOID
CONT. USING NON-SPARKING TOOLS, SCOOP SPILLED MATL INTO CONTR FOR PROPER
DISP. (IF NECESSARY, USE INERT ABSORB MATL TO AID IN CONTAINING SPILL.)
Waste Disposal Methods: DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH FEDERAL (40
CFR PART 261), STATE AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS. IF WASTE IS
DETERMINED TO BE HAZARDOUS, USE LICENSED HAZARDOUS WASTE TRANSPORTE R AND
DISPOSAL FACILITY.
Handling And Storage Precautions: KEEP CLOSURE TIGHT AND CONTAINER UPRIGHT TO
PREVENT LEAKAGE. GROUND AND BOND CONTAINERS WHEN TRANSFERRING MATERIAL. AVOID
SKIN AND EYE CONTACT. AVOID BREATHING OF VAPOR OR SPRAY MISTS. DO NOT HANDLE
U NTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. USE WITH
ADEQUATE VENTILATION.
Other Precautions: BECAUSE EMPTY CONTRS MAY RETAIN PROD RESIDUE & FLAMM
VAPS, KEEP AWAY FROM HEAT, SPKS & FLAME; DO NOT CUT, PUNCTURE/WELD
ON/NEAR EMPTY CONTR. DO NOT SMOKE WHERE USED/STORED. REFER TO OSHA 29 CFR
PART 1 910.106 "FLAMM & COMBUST LIQS" FOR SPECIFIC STOR REQS. STORE ONLY
IN WELL-VENTD AREAS. KEEP CONTR CL SD WHEN NOT IN USE.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point: =18.3C, 65.F
Lower Limits: 1.0%
Upper Limits: 8.8%
Extinguishing Media: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures: WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT (FP N). IF WATER IS USED, FOG NOZZLES ARE PREFERABLE. DURING A
FIRE, IRRITATING AND/OR TOXIC GASES AND PARTICULATES MAY BE GENERATED BY
THERMAL D ECOMPOSITION OR COMBUSTION.
Unusual Fire/Explosion Hazard: FLAMMABLE LIQUID & VAPOR. KEEP CONTRS
TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS, OPEN FLAME,
& OTHER SOURCES OF IGNITION. CLOSED CONTAINERS MAY RUPTURE WHEN EXPOSED
TO EXTREME HE AT. USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL. OSHA
FLAMMABILITY CLASSIFICATION: FLAMMABLE LIQUID - CLASS IB.
=======================================================
Control Measures
=======================================================
Respiratory Protection: CONTAINS SML AMT OF DIMETHYLANILINE (DMA) WHICH HAS
POOR ODOR-WARNING PROPERTIES. IF EXPOS LIM FOR DMA IS EXCEEDED, A NIOSH
APPRVD AIR-SUPP RESP IS REC. OTHERWISE, A PROPERLY-FITTED NIOSH APPRVD ORG V
AP, AIR-PURIFYING RESP IS REC. FOR EMER SITUATIONS, CONFINED SPACE USE/OTHER
CNDTNS WHERE EXPOS LIMS MAY BE GREATLY EXCEEDED, USE NIOSH APPRVD (SUP DAT)
Ventilation: SUFFICIENT VENT IN PATTERN & VOL SHOULD BE PROVIDED IN ORDER
TO MAINTAIN AIR CONTAMINANT LEVELS BELOW REC EXPOS LIMS. SUFFICIENT VENT
(USING EXPLO- (SUP DAT)
Protective Gloves: USE NEOPRENE, NITRILE, OR RUBBER GLOVES TO PREVENT SKIN
CONTACT.
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPROVED EMERGENCY EYEWASH AND DELUGE SHOWER
(FP N). USE DISPOSABLE OR IMPERVIOUS CLOTHING IF WORK CLOTHING CONTAMINATION
IS LIKELY.
Work Hygienic Practices: REMOVE & WASH CONTAMD CLTHG BEFORE REUSE. WASH HANDS
BEFORE EATING, SMOKING/USING TOILET FACILITY. FOOD/BEVERAGES SHOULD NOT BE
CONSUMED ANYWHERE THIS PROD IS HANDLED/STORED. WASH THORO AFTER HANDLING.
Supplemental Safety and Health: RESP PROT: AIR-SUPP RESP. OBSERVE OSHA REGS (29
CFR 1910.134) FOR RESP USE. VENT: PROOF EQUIP) SHOULD BE PROVIDED TO PVNT
FLAMM VAP/AIR MIXTS FROM ACCUMULATING. PHYSICAL/CHEM PROPERTIES: VOLAT BY WT:
0.0%; COEFFICIENT OF WATER/OIL DISTRIBUTION: N/K; ODOR THRESHOLD: N/K;
DENSITY: 8.76 LBS/GAL.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >101.1C, 214.F
B.P. Text: 214F - 379F
Vapor Density: HVR/AIR
Spec Gravity: 1.05
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: OFF-WHITE LIQUID WITH SWEET ODOR.
Percent Volatiles by Volume: 0.0
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: STORAGE ABOVE 100F AND BELOW 32F. EXPOSURE TO
SUNLIGHT, ULTRAVIOLET LIGHT IRRADATION. AVOID DROPPING OR PUNCTURE OF
CONTAINERS.
Materials To Avoid: INORGANIC ACIDS, ORGANIC ACIDS, CAUSTICS, AMINES,
PEROXIDES, POLYMERIZATION INHIBITORS.
Hazardous Decomposition Products: CARBON MONOXIDE, CARBON DIOXIDE, OXIDES OF
NITROGEN.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
Toxicological Information: PRODUCT LD50 (ORAL, DERMAL): NO DATA. PRODUCT LC50:
NO DATA.
=======================================================
Ecological Information
=======================================================
Ecological: NO INFORMATION.
=======================================================
MSDS Transport Information
=======================================================
Transport Information: DOT PROPER SHIPPING NAME: ADHESIVE. DOT HAZARD CLASS: 3.
DOT UN/NA NUMBER: UN1133. EMERGENCY RESPONSE GUIDE NUMBER: 127. PACKING
GROUP: II.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA SECTION 313: THIS PRODUCT CONTAINS THE
FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND 40
CF R PART 372: METHYL METHACRYLATE, CAS # 80-62-6, LESS THAN 50% IN WEIGHT;
N/N-DIMETHYLANILINE, CAS # 121-69-7, LESS THAN 2% IN WEIGHT.
Federal Regulatory Information: U.S. FEDERAL REGULATIONS: TOXIC SUBSTANCES
CONTROL ACT: INVENTORY STATUS: THE CHEMICAL SUBSTANCES IN THIS PRODUCT ARE ON
THE TSCA SECTION 8 INVENTORY. INTERNATIONAL REGULATIONS: CANADIAN W: THIS M
SDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED PRODUCT REGULATIONS
EXCEPT FOR USE OF THE 16 HEADINGS. CANADIAN W CLASS: NO INFORMATION
AVAILABLE.
State Regulatory Information: RATINGS: HEALTH: 2 (CHRONIC HAZARD; SEE HEALTH
HAZARDS SECTION); FLAMMABILITY: 3; REACTIVITY: 1. VOLATILE ORGANIC COMPOUNDS
(CALCULATED): 0.00 LBS/GAL, 0 GRAMS/LTR. PRODUCT USE/CLASS: ADHESIVE.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: LORD 206
Company: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Street: 2000 WEST GRANDVIEW BLVD
City: ERIE PA
Zipcode: 16514-0038
Health Emergency Phone: 814-763-2345
Label Required IND: Y
Date Of Label Review: 08/27/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE! ACUTE: EYES: CAUSES EYE IRRITATION. SKIN:
MAY BE ABSORBED THROUGH THE SKIN IN HARMFUL AMOUNTS. MAY CAUSE DERMATITIS.
CAUSES SKIN IRRITATION. INHALATION: MAY CAUSE HEADACHE AND NAUSEA. CAUSE S
RESPIRATORY TRACT IRRITATION. INGESTION: HARMFUL IF SWALLOWED. INGESTION IS
NOT AN EXPECTED ROUTE OF ENTRY IN INDUSTRIAL OR COMMERCIAL USES. CHRONIC: MAY
CAUSE LIVER OR KIDNEY DAMAGE. CHRONIC SKIN C ONTACT MAY CAUSE DERMATITIS.
MAY CAUSE SKIN SENSITIZATION.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|