PPG INDUSTRIES INC -- PITT-TECH DTM HIGH GLOSS, 90A
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CJSLM
MSDS NAME: PITT-TECH DTM HIGH GLOSS, 90A
Responsible Party
Name: PPG INDUSTRIES INC
Address: 4325 ROSANNA DR
Box: 9
City: ALLISON PARK PA 15101
Info Phone: 412-492-5555
Emergency Phone Number: 304-843-1300
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: PPG INDUSTRIES INC
Address: ONE PPG PLACE
City: PITTSBURGH PA 15272
Phone: 1-800-245-2974 (CAL HYPO)
=======================================================
Item Description Information
=======================================================
=======================================================
Ingredients
=======================================================
Cas: 108419-35-8
Name: ACETIC ACID, C11-14-BRANCHED ALKYL ESTERS, C13-RICH; (OXO-TRIDECYL
ACETATE)
% Wt: 1 - <5
------------------------------
Cas: 111-77-3
RTECS #: KL6125000
Name: DIETHYLENE GLYCOL MONOMETHYL ETHER
% Wt: 1 - <5
------------------------------
Cas: 112-34-5
RTECS #: KJ9100000
Name: DIETHYLENE GLYCOL MONOBUTYL ETHER
% Wt: 1 - <5
------------------------------
Cas: 1309-37-1
RTECS #: NO7400000
Name: RED IRON OXIDE
% Wt: 1 - <5
OSHA PEL: 10 MG/M3
ACGIH TLV: 5 MG/M3;2 PPM
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 1333-86-4
RTECS #: FF5800000
Name: CARBON BLACK
% Wt: 1 - <5
OSHA PEL: 3.5 MG/M3
ACGIH TLV: 3.5 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 13463-67-7
RTECS #: XR2275000
Name: TITANIUM DIOXIDE
% Wt: 30 - <40
OSHA PEL: 15 MG/M3
ACGIH TLV: 10 MG/M3
ACGIH STEL: NOT ESTABLISHED
------------------------------
Cas: 21645-51-2
RTECS #: BD0940000
Name: ALUMINUM HYDROXIDE
% Wt: 1 - <5
------------------------------
Cas: 29911-28-2
RTECS #: UA8200000
Name: DIPROPYLENE GLYCOL BUTOXY ETHER
% Wt: 1-<5
------------------------------
Cas: 3468-63-1
RTECS #: QL3854000
Name: DINITROANILINE ORANGE; (DINITROANILINE PIGMENT ORANGE 5)
% Wt: 1 - <5
------------------------------
Cas: 7631-86-9
RTECS #: VV7565000
Name: SILICON DIOXIDE; (SILICA)
% Wt: 1 - <5
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Effects of Exposure: ACUTE: HARMFUL IF SWALLOWED. EYE: CAUSES SEVERE EYE IRRIT.
SKIN: MAY CAUSE SLIGHT SKIN IRRIT. MAY BE HARFMUL IF ABSORBED THROUGH SKIN.
INHAL: VAP &/SPRAY MIST MAY BE HARMFUL IF INHALED. RPTD EXPOS TO HIGH
VAP CONC MAY CAUSE IRRIT OF RESP SYS & PERM BRAIN & NERVOUS SYS DMG.
CHRONIC: AVOID LONG-TERM & RPTD CNTCT. POSSIBLE MUTAGENIC HAZ.
PREDICTIVE LAB TESTS W/CULTURED MEDIA ON INGREDIENT(S) CONTAIN ED IN THIS
PROD INDICATED POTENTIAL DMG TO GENETIC MATL. THIS PROD CONTAINS ETHYLENE
SERIES GLYCOL ETHER &/ACETATE WHICH HAS BEEN SHOWN TO CAUSE ADVERSE EFTS
ON SKIN, LIVER, BLOOD &/BLOOD-FORMING TIS SUE. THIS PROD CNTNS (EFTS OF
OVEREXP)
Explanation Of Carcinogenicity: CARBON BLACK: IARC MONOGRAPHS ON THE EVALATION
OF CARCINOGENIC RISK OF CHEMICALS TO MAN, VOLUME 65, PAGE 149, 1996: GROUP
2B.
Signs And Symptions Of Overexposure: HLTH HAZ: TITANIUM DIOXIDE. ANIMALS
INHALING MASSIVE QTIES OF TITANIUM DIOXIDE DUST IN LONG-TERM STUDY DEVELOPED
LUNG TUMORS. STUDIES W/HUMANS INVOLVED IN MFR OF THIS PIGMENT INDICATE NO
INCREASED RIS K OF CANCER FROM EXPOSURE. POTENTIAL FORINHAL OF TITANIUM
DIOXIDE DUST FROM COATING IS VERY LIMITED. SINCE OVEREXPS ARE NOT EXPECTED,
THERE IS NO SIGNIFICANT HAZ TO MAN. THIS PROD CNTNS DIETHYLENE GLY COL
MONOBUTYL ETHER (DEGBE), DEGBE CONSUMED IN DRINKING WATER AT LOW LEVELS BY
RATS FOR 30 DAYS CAUSED INJURY TO EITHER LIVER, KIDNEY, SPLEEN/TESTES.
(SUPDAT)
First Aid: INGEST: IF SWALLOWED, DO NOT INDUCE VOMIT. GENTLY WIPE OUT INSIDE
MOUTH TO REMOVE ANY RESIDUAL MATL. EYE: IN CASE OF EYE CONTACT, REMOVE
CONTACT LENSES & FLUSH EYES IMMED W/GENTLE STREAM OF LUKE WARM WATER FOR
AT LEAST 15 MIN. SKIN: FLUSH IMMED W/PLENTY OF H*2O FOR AT LEAST 15 MIN
FOLLOWED BY WASHING W/SOAP & WATER. INHAL: IF AFFECTED BY INHAL OF
VAP/SPRAY MIST, REMOVE TO FRESH AIR. APPLY ARTF RES P & OTHER SUPPORT
MEASURES AS REQUIRED. OTHER: IF INGEST, ANY TYPE OF OVEREXP/SYMPS OF OVEREXP
OCCUR DURING/FOLLOWING USE OF THIS PROD, CNCT POISON CONTROL CENTER,
EMERGENCY ROOM/PHYSICIAN IMMED; HAVE MSDS INFO AVAIL.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PROVIDE MAXIMUM VENTILATION. ONLY PERSONNEL EQUIPPED
WITH PROPER RESPIRATORY, SKIN, AND EYE PROTECTION SHOULD BE PERMITTED IN THE
AREA. REMOVE ALL SOURCES OF IGNITION. TAKE UP SPILLED MATERIAL WITH SA ND,
VERMICULITE, OR OTHER NONCOMBUSTIBLE ABSORBENT MATERIAL AND PLACE IN CLEAN
EMPTY CONTAINERS FOR DISPOSAL. ONLY THE SPILLED MATERIAL AND THE ABSORBENT
SHOULD BE PLACED IN THIS CONTAINER.
Waste Disposal Methods: WASTE MATERIAL MUST BE DISPOSED OF IN ACORDANCE WITH
FEDERAL, STATE, PROVINCIAL, AND LOCAL ENVIRONMENTAL CONTROL REGULATIONS.
EMPTY CONTAINERS SHOULD BE RECYCLED OR DISPOSED OF THORUGH AN APPROVED WAS TE
MANAGEMENT FACILITY.
Handling And Storage Precautions: PROTECT FROM FREEZING.
Other Precautions: IF MATERIAL IS PART OF MULTIPLE COMPONENT SYSTEM, READ MSDS
(S) FOR OTHER COMPONENT/COMPONENTS BEFORE BLENDING AS RESULTING MIXTURES MAY
HAVE HAZARDS OF ALL OF ITS PARTS.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point: =148.3C, 299.F
Extinguishing Media: USE EXTINGUISHERS APPROPRIATE FOR SURROUNDING FIRE.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). WATER SPRAY MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL
CLOSED CONTAINERS THAT ARE EXPOSED TO EXTREME HEAT. IF WATER IS USED, FOG
NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard: CLOSED CONTAINERS MAY EXPLODE OR BURST (DUE TO
THE BUILD-UP OF STREAM PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
=======================================================
Control Measures
=======================================================
Respiratory Protection: OVEREXP TO VAP MAY BE PREVENTED BY ENSURING PROPER VENT
CONTROLS, VAP EXHST/FRESH AIR ENTRY. NIOSH APPRVD AIR PURIFYING RESP W/APPROP
CHEM CARTRIDGES/POSITIVE-PRESS, AIR-SUPPLIED RESP MAY ALSO REDUCE EXPOS.
READ RESP MFR'S INSTRUCTIONS & LITERATURE CAREFULLY TO DETERM TYPE OF
AIRBORNE CONTAM AGAINST WHICH RESP IS EFFECTIVE, ITS (SUPDAT)
Ventilation: PROVIDE GEN DILUTION/LOC EXHST VENT IN VOLUME & PATTERN TO
KEEP CONC OF INGREDS LISTED IN SECTION 2 BELOW LOWEST SUGGESTED EXPOS LIMITS,
LEL BELOW (SUPDAT)
Protective Gloves: NEOPRENE RUBBER, NITRILE RUBBER OR LATEX.
Eye Protection: ANSI APPROVED CHEMICAL WORKERS GOGGLES (FP N).
Other Protective Equipment: ANSI APPRVD EYE WASH & DELUGE SHOWER (FP N). CLEAN
CONTAM CLOTHING & SHOES. WEAR PROT CLTHG TO PVNT SKIN CNTCT. APRON. NO
SPECIFIC PERMEATION/DEGRADATION TESTING HAVE BEEN DONE ON PROT CLTHG OF PROD.
Work Hygienic Practices: RECOMMENDATIONS FOR SKIN PROTECTION ARE BASED ON
INFREQUENT CONTACT WITH THIS PRODUCT. FOR FREQUENT CONTACT/TOTAL IMMERSION,
CONTACT MFR OF PROTECTIVE CLOTHING FOR APPROPRIATE CHEMICAL IMPERVIOUS EQUIP.
Supplemental Safety and Health: EFTS OF OVEREXP: PROD CNTNS CARBON BLACK WHICH
HAS BEEN RATED AN IARC 2B CARCIN DUE TO ANIMAL DATA. VENT: STATED LIMIT &
TO REMOVE DECOMP PRODS DURING WELDING/FLAME CUTTING. RESP PROT: LIMITATION,
& H OW IT IS TO BE PROPERLY FITTED & USED. HAZ DECOMP PROD: INCLS,
BUT IS NOT LIMITED TO, FLAME CUTTING, BRAZING & WELDING.
=======================================================
Physical/Chemical Properties
=======================================================
Boiling Point: >100.C, 212.F
B.P. Text: 212-545F
Vapor Pres: 17.8 MMHG
Vapor Density: HVR/AIR
Spec Gravity: 1.075
PH: N/PN/K
Evaporation Rate & Reference: 33 (BUAC = 100)
Solubility in Water: 72.7%
Appearance and Odor: VISCIOUS LIQUID W/ODOR CHARACTERISTIC OF CHEM FAMILY & ANY
SOLVS IN SECTION 2.
Percent Volatiles by Volume: 62-70
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: AVOID CONTACT WITH STRONG ALKALIES, STRONG MINERAL ACIDS,
OR STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products: MAY PRODUCE FOLLOWING HAZ DECOMP PRODS WHEN
EXPOSED TO EXTREME HEAT: CARBON MONOXIDE; CARBON DIOXIDE; IRON OXIDES; OXIDES
OF ALUMINUM; HYDROGEN CYANIDE; AMMONIA; OXIDES OF NITROGEN; EXTREME
HEAT(SUPDAT)
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA TITLE III & CERCLA CLASSIFICATIONS: SARA
102: ALL INGS NOT ESTABLISHED. SARA 302: ALL INGS NOT ESTABLISHED.
SARA 313: DIETHYLENE GLYCOL MONOMETHYL ETHER, DIETHYLENE GLYCOL MONOBUTYL
ETHER. SARA 3 11/312 ACUTE: OXO-TRIDECYL ACETATE, DIETHYLENE GLYCOL
MONOMETHYL ETHER, DIETHYLENE GLYCOL MONOBUTYL ETHER, DIPROPYLENE GLYCOL
MONOBUTYL ETHER, DINITROANILINE PIGMENT ORANGE 5. SARA 311/312 CHRONIC: DI
ETHYLENE GLYCOL MONOMETHYL ETHER, CARBON BLACK. SARA 311/312 FLAMMABILITY:
DIETHYLENE GLYCOL MONOMETHYL ETHER. SARA 311/312 PRESSURE/REACTIVITY: NONE
LISTED.
Federal Regulatory Information: PRODUCT STATUS RELATIVE TO THE U S EPA TOXIC
SUBSTANCES. ALL CHEMICAL SUBSTANCES IN THIS PRODUCT ARE LISTED ON THE U S
TSCA INVENTORY OR ARE OTHERWISE EXEMPT FROM TSCA INVENTORY REPORTING
REQUIREMENTS .
State Regulatory Information: WARNING: THIS PRODUCT CONTAINS A CHEMICAL KNOWN
TO THE STATE OF CALIFORNIA TO CAUSE CANCER.
=======================================================
Other Information
=======================================================
Other Information: CHEM FAMILY: ACRYLIC. THIS MSDS HAS BEEN PREPARED I/A/W/THE
OSHA HAZ COMMUNICATION STD (29 CFR 1910.1200), THE SUPPLIER NOTIFICATION REQS
OF SARA TITLE III, SECTION 313 & OTHER APPLIC RIGHT-TO-KNOW RE GS. PPG
SFTY & HLTH IN-PLANT INDEX SYS(SHIS): HLTH = 3*, FLAMM = 1, REACTIVITY =
0. ACUTE HAZ RATING SYS: 0 = MINIMAL, 1 = SLIGHT, 2 = MODERATE, 3 = SERIOUS,
4 = SEVERE. CHRONIC HAZ RATING SYS: 3* OR 4*. RATINGS ARE ASSIGNED TO
IDENTIFY RELATIVE MAGNITUDE OF PTNTL HAZS. SAFE HNDLG OF PROD REQS THAT ALL
INFO ON MSDS BE EVAL FOR SPECIFIC WORK ENVIRONMENTS.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: PITT-TECH DTM HIGH GLOSS, 90A
Company: PPG INDUSTRIES INC
Street: ONE PPG PLACE
City: PITTSBURGH PA
Zipcode: 15272
Health Emergency Phone: 304-843-1300
Label Required IND: Y
Date Of Label Review: 09/30/1999
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: ACUTE: INGEST: HARMFUL IF SWALLOWED. EYE: CAUSES SEVERE
EYE IRRIT. SKIN: MAY CAUSE SLIGHT SKIN IRRIT. MAY BE HARFMUL IF ABSORBED
THROUGH SKIN. INHAL: VAP &/SPRAY MIST MAY BE HARMFUL IF INHALED. RPTD E
XPOS TO HIGH VAP CONC MAY CAUSE IRRIT OF RESP SYS & PERM BRAIN &
NERVOUS SYS DMG. CHRONIC: CANCER HAZARD. CONTAINS CARBON BLACK WHICH IS
LISTED AS AN ANIMAL LUNG CARCINOGEN (FP N). AVOID LONG-TERM & R PTD
CNTCT. POSSIBLE MUTAGENIC HAZ. CONTAINS ETHYLENE SERIES GLYCOL ETHER
&/ACETATE WHICH HAS BEEN SHOWN TO CAUSE ADVERSE EFTS ON SKIN, LIVER,
BLOOD &/BLOOD-FORMING TISSUE.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|