DOW CHEMICAL U.S.A. -- 03386, BRAKE FLUID 1000
=======================================================
Material Safety Data Sheet
=======================================================
NIIN: 01-052-6762
MSDS Num: CLHCJ
MSDS NAME: 03386, BRAKE FLUID 1000
Responsible Party
Name: DOW CHEMICAL U.S.A.
City: MIDLAND MI 48674
Info Phone: 800-258-2436
Emergency Phone Number: 517-636-4400
Resp. Party Other MSDS No.: 002266
=======================================================
Item Description Information
=======================================================
Item Manager: S9G
Item Name: BRAKE FLUID,AUTOMOTIVE
Specification Number: VV-B-680
Type/Grade/Class: 1 SIZE
Unit of Issue: QT
UI Container Qty: 0
Type of Container: PPP-C-96
=======================================================
Ingredients
=======================================================
Name: *** PROPRIETARY ***
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50 (ORAL, RAT) > 2,000 MG/KG
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: EYE: MAY CAUSE MODERATE IRRITATION, CORNEAL INJURY. SKIN:
PROLONGED/REPEATED EXPOSURE MAY CAUSE IRRITATION. MAY BE ABRADEDED THROUGH
SKIN. PROLONGED/REPEATED CONTACT WITH VERY LARGE AMOUNTS OF COMPONE NTS MAY
CAUSE NARCOSIS (DROWSINESS). MASSIVE CONTACT WITH DAMAGED SKIN/OF MATERIAL
SUFFICIENTLY HOT TO BURN SKIN MAY RESULT IN ABSORPTION OF LETHAL AMOUNTS.
INGESTION: SINGLE DOSE ORAL TOXICITY IS LOW . SMALL AMOUNTS SWALLOWED
INCIDENTALLY NOT LIKELY TO CAUSE INJURY; SWALLOWING LARGE AMOUNTS MAY CAUSE
INJURY. NHALATION: AT ROOM TEMPERATURES, VAPORS ARE MINIMAL DUE TO PHYSICAL
PROPERTIES; A SINGLE E XPOSURE IS NOT LIKELY TO BE HAZARDOUS
Explanation Of Carcinogenicity: NO RELEVANT INFORMATION FOUND FOR MAJOR
COMPONENTS. CONTAINS COMPONENT( S) WHICH DID NOT CAUSE CANCER IN LABORATORY
ANIMALS
Signs And Symptions Of Overexposure: EYE: MAY CAUSE MODERATE IRRITATION. SKIN:
PROLONGED/REPEATED EXPOSURE MAY CAUSE IRRITATION. PROLONGED/REPEATED CONTACT
WITH VERY LARGE AMOUNTS OF COMPONENTS MAY CAUSE NARCOSIS (DROWSINESS).
MASSIVE CO NTACT WITH DAMAGED SKIN/OF MATERIAL SUFFICIENTLY HOT TO BURN SKIN
MAY RESULT IN ABSORPTION OF LETHAL AMOUNTS.
Medical Cond Aggravated By Exposure: NOT PROVIDED
First Aid: EYE: IRRIGATE WITH FLOWING WATER IMMEDIATELY AND CONTINUOUSLY FOR 15
MINUTES. CONSULT MEDICAL PERSONNEL. SKIN: WASH OFF IN FLOWING WATER OR
SHOWER. INGESTION: IF SWALLOWED, SEEK MEDICAL ATTENTION. DO NOT INDUCE
VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL PERSONNEL. INHALATION: REMOVE TO
FRESH AIR IF EFFECTS OCCUR. CONSULT A PHYSICIAN.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: PROTECT PEOPLE: ISOLATE AREA. PROTECT THE
ENVIRONMENT: CONTAIN LIQUID TO PREVENT CONTAMINATION OF SOIL, SURFACE WATER
OR GROUND WATER. CLEANUP: CLEAN UP WITH ABSORBENT MATERIAL. COLLECT MATERIAL
IN SU ITABLE AND PROPERLY LABELED OPEN CONTAINERS.
Neutralizing Agent: NOT RELEVANT
Waste Disposal Methods: DO NOT DUMP INTO ANY SEWERS, ON THE GROUND OR INTO ANY
BODY OF WATER. ALL DISPOSAL METHODS MUST BE IN COMPLIANCE WITH ALL FEDERAL,
STATE/PROVINCIAL AND LOCAL LAWS AND REGULATIONS. REGULATIONS MAY VARY IN
DIFFERENT LOCATIONS. WASTE CHARACTERIZATIONS AND COMPLIANCE WITH APPLICABLE
LAWS ARE THE RESPONS IBILITY SOLELY OF THE WASTE GENERATOR.
Handling And Storage Precautions: WHEN HANDLING HOT MATERIAL, PROTECT SKIN FROM
THERMAL BURNS AS WELL AS FROM SKIN ABSORPTION.
Other Precautions: NOT PROVIDED
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point: =133.3C, 272.F
Autoignition Temp Text: N/D
Lower Limits: N/D
Upper Limits: N/D
Extinguishing Media: WATER FOG/FINE SPRAY, CARBON DIOXIDE, DRY CHEMICAL, FOAM.
ALCOHOL RESISTANT FOAMS (ATC TYPE) ARE PREFERRED IF AVAILABLE. GENERAL
PURPOSE SYNTHETIC FOAMS MAY WORK.
Fire Fighting Procedures: KEEP PEOPLE AWAY. ISOLATE FIRE AREA AND DENY
UNNECESSARY ENTRY. BURNING LIQUIDS MAY BE MOVED BY FLUSHING WITH WATER TO
PROTECT PERSONNEL AND MINIMIZE PROPERTY DAMAGE. BURNING LIQUIDS MAY BE
EXTINGUISH ED BY DILUTION WITH WATER. DO NOT USE DIRECT WATER STREAM. MAY
SPREAD FIRE.
Unusual Fire/Explosion Hazard: VIOLENT STEAM GENERATION OR ERUPTION MAY OCCUR
UPON APPLICATION OF DIRECT WATER STREAM TO HOT LIQUIDS. SPILLS OF THESE
ORGANIC LIQUIDS ON HOT FIBROUS INSULATIONS MAY LEAD TO LOWERING OF THE
AUTOIGNITI ON TEMPERATURES POSSIBLY RESULTING IN SPONTANEOUS COMBUSTION.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NO RESPIRATORY PROTECTION SHOULD BE NEEDED. IF
RESPIRATORY IRRITATION IS EXPERIENCED, USE AN APPROVED AIR-PURIFYING
RESPIRATOR.
Ventilation: GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT FOR MOST CONDITIONS.
LOCAL EXHAUST VENTILATION MAY BE NECESSARY FOR SOME OPERATIONS.
Protective Gloves: IMPERIVOUS GLOVES
Eye Protection: USE CHEMICAL GOGGLES, FACESHIELD
Other Protective Equipment: SELECTION OF SPECIFIC ITEMS SUCH AS FACESHIELD,
GLOVES, BOOTS, APRON, OR FULL-BODY SUIT WILL DEPEND ON OPERATION.
Work Hygienic Practices: NOT PROVIDED
Supplemental Safety and Health: ABBREVIATION: N/A = NOT APPLICABLE. N/AV = NOT
AVAILABLE. N/K = UNKNOWN. N/P = NOT PROVIDED. N/R = NOT RELEVANT. N/D = NOT
DETERMINED. N/E = NOT ESTABLISHED. CNS = CENTRAL NERVOUS SYSTEM. GI = GASTROI
NTESTINAL. SCBA = SELF CONTAINED BREATHING APPARATUS.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: V6
NRC/State LIC No: NOT RELEVANT
Boiling Point: =221.1C, 430.F
B.P. Text: MINIMUM
M.P/F.P Text: NOT PROVIDED
Decomp Text: NOT PROVIDED
Vapor Pres: LOW
Vapor Density: N/D
Spec Gravity: 1.03
PH: NOT PROVIDED
Viscosity: NOT PROVIDED
Evaporation Rate & Reference: NOT PROVIDED
Solubility in Water: INFINITE
Appearance and Odor: LIGHT YELLOW LIQUID. MILD ODOR
Percent Volatiles by Volume: NOT PROVIDED
Corrosion Rate: NOT PROVIDED
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: ACTIVE INGREDIENT DECOMPOSES AT ELEVATED
TEMPERATURES. PRODUCT CAN DECOMPOSE AT ELEVATED TEMPERATURES.
Materials To Avoid: AVOID CONTACT WITH OXIDIZING MATERIALS.
Hazardous Decomposition Products: SMOKE, UNIDENTIFIED TOXIC AND/ OR IRRITATING
COMPOUNDS. HAZARDOUS COMBUSTION PRODUCTS MAY INCLUDE AND ARE NOT LIMITED TO:
CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: YES
Conditions To Avoid Polymerization: NONE
=======================================================
Toxicological Information
=======================================================
Toxicological Information: SKIN: THE DERMAL LD50 HAS NOT BEEN DETERMINED.
INGESTION: THE ORAL LD50 FOR RATS IS EXPECTED TO BE >2000 MG/ KG.
MUTAGENICITY: IN VITRO MUTAGENICITY STUDIES WERE NEGATIVE FOR COMPONENT( S)
TESTED. MUTAGENICITY STUDIES IN ANIMALS WERE NEGATIVE FOR COMPONENT( S)
TESTED.
=======================================================
Ecological Information
=======================================================
Ecological: BIOCONCENTRATION POTENTIAL IS LOW (BCF LESS THAN 100 OR LOG POW
LESS THAN 3). POTENTIAL FOR MOBILITY IN SOIL IS VERY HIGH (KOC BETWEEN 0 AND
50). DEGRADATION & PERSISTENCE: BASED ON INFORMATION FOR TR IETHYLENE
GLYCOL, AND DOWANOL DPM, TMH AND TBH. BIODEGRADATION UNDER AEROBIC STATIC
LABORATORY CONDITIONS IS MODERATE (BOD20 OR BOD28/ THOD BETWEEN 10 AND 40%).
BASED ON INFORMATION FOR REMAINING CO MPONENTS. BIODEGRADATION UNDER AEROBIC
STATIC LABORATORY CONDITIONS IS HIGH (BOD20 OR BOD28/ THOD GREATER THAN
40%). ECOTOXICITY:MATERIAL IS PRACTICALLY NON- TOXIC TO AQUATIC ORGANISMS.
=======================================================
MSDS Transport Information
=======================================================
Transport Information: DEPARTMENT OF TRANSPORTATION (D. O. T.): FOR DOT
REGULATORY INFORMATION, IF REQUIRED, CONSULT TRANSPORTATION REGULATIONS,
PRODUCT SHIPPING OR CONTACT YOUR DOW REPRESENTATIVE.
=======================================================
Regulatory Information
=======================================================
Sara Title III Information: SARA 313 INFORMATION: THIS PRODUCT CONTAINS THE
FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF
TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 AND
40 CFR PART 372: CHEMICAL NAME CAS NUMBER CONCENTRATION-------- GLYCOL
ETHERS PROPRIETARY <100 % --- SARA HAZARD CATEGORY: THIS PRODUCT HAS BEEN
REVIEWED ACCORDING TO THE EPA "HAZARD CATEGORIES" PRO MULGATED UNDER SECTIONS
311 AND 312IS CONSIDERED, UNDER APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING
CATEGORIES: AN IMMEDIATE HEALTH HAZARD A DELAYED HEALTH HAZARD.
Federal Regulatory Information: TOXIC SUBSTANCES CONTROL ACT (TSCA): ALL
INGREDIENTS ARE ON THE TSCA INVENTORY OR ARE NOT REQUIRED TO BE LISTED ON THE
TSCA INVENTORY. OSHA HAZARD COMMUNICATION STANDARD: THIS PRODUCT IS A
"HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD COMMUNICATION STANDARD,
29 CFR 1910.1200.
State Regulatory Information: STATE RIGHT- TO- KNOW: THE FOLLOWING PRODUCT
COMPONENTS ARE CITED ON CERTAIN STATE LISTS AS MENTIONED. NON- LISTED
COMPONENTS MAY BE SHOWN IN THE COMPOSITION SECTION OF THE MSDS. CHEMICAL
NAME CAS N UMBER LIST --------------------------------------------
----------- ----------- PROPRIETARY INGREDIENT PROPRIETARY X X =THIS PRODUCT
CONTAINS PROPRIETARY INGREDIENT( S) LISTED BY ONE OR MORE STATES.
=======================================================
Other Information
=======================================================
Other Information: NOTE TO PHYSICIAN: NO SPECIFIC ANTIDOTE. 4- METHYL PYRAZOLE
IS AN EFFECTIVE BLOCKER OF ALCOHOL DEHYDROGENASE AND IS AVAILABLE NOW AS
FOMEPIZOLE (ANTIZOL) (R) AND SHOULD BE USED IN THE TREATMENT OF E THYLENE
GLYCOL, DIETHYLENE GLYCOL AND METHANOL INTOXICATION IF AVAILABLE. SUPPORTIVE
CARE. TREATMENT BASED ON JUDGMENT OF THE PHYSICIAN IN RESPONSE TO REACTIONS
OF THE PATIENT.
=======================================================
Transportation Information
=======================================================
Trans ID NO: 157979
MSDS NAME: 03386, BRAKE FLUID 1000
MSDS Prepared Date: 04/28/2000
Review Date: 07/24/2001
Net Unit Weight: 2.1 LBS
Multiple KIT Number: 0
Unit Of Issue: QT
Container QTY: 0
Type Of Container: PPP-C-96
=======================================================
Detail DOT Information
=======================================================
DOT PSN Code: ZZZ
DOT Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail IMO Information
=======================================================
IMO PSN Code: ZZZ
IMO Proper Shipping Name: NOT REGULATED FOR THIS MODE OF TRANSPORTATION
=======================================================
Detail IATA Information
=======================================================
IATA PSN Code: ZZZ
IATA Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
Detail AFI Information
=======================================================
AFI PSN Code: ZZZ
AFI Proper Shipping Name: NOT REGULATED BY THIS MODE OF TRANSPORTATION
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 03386, BRAKE FLUID 1000
Company: DOW CHEMICAL U.S.A.
City: MIDLAND MI
Zipcode: 48674
Health Emergency Phone: 517-636-4400
Label Required IND: Y
Date Of Label Review: 07/24/2001
Status Code: A
MFG Label NO: NOT PROVIDED
Year Procured: 2001
Origination Code: F
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: NO
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: TARGET ORGANS: N/P. CAUTION! MAY CAUSE EYE AND SKIN
IRRITATION. IF IN EYES, FLUSH WITH WATER. IF ON SKIN, WASH WITH SOAP AND
WATER. IF SWALLOWED, DO NOT INDUCE VOMITING. CALL PHYSICIAN. IF INHALED, R
EMOVE TO FRESH AIR. IF SPILLED, REMOVE TO CONTAINER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
631-914, ELECTRONIC SOLV (BULK FORMULATED)
| |
|
SCATTER GRANULAR ODOR COUNTERACTANT
| |
|
3053-53, ANALYSIS: REAGENT PILLOWS FOR BROMINE/CHLORINE
| |
|
SIERRA ANTIFREEZE-COOLANT
| |
|
71-110 METALSIDE PASTEL BASE
| 107-21-1
1314-13-2
13463-67-7
14808-60-7
29911-28-2 |
|
RENE' N-4
| 7440-02-0
7440-47-3
7440-48-4
7429-90-5
7440-32-6
7440-33-7
7440-25-7 |
|
RENE' N-4+
| 7440-02-0
7440-47-3
7440-48-4
7429-90-5
7440-32-6
7440-33-7
7440-25-7 |
|
RENE' N-5
| 7440-02-0
7440-47-3
7440-48-4
7429-90-5
7440-33-7
7440-25-7
7439-98-7 |
|
RENE' N-6
| 7440-02-0
7440-47-3
7440-48-4
7429-90-5
7440-33-7
7440-25-7 |
|
RENE' 142
| 7440-02-0
7440-47-3
7440-48-4
7429-90-5
7440-33-7
7440-25-7
7439-98-7
7440-58-6 |
|
97-725 THINNER
| 100-41-4
108-88-3
1330-20-7
2807-30-9
67-63-0 |
|
97-726 HIGH FLASH NAPTHA
| 25551-13-7
64742-48-9
64742-95-6
95-63-6 |
|
PENAIR M-5704A
| |
|
THIOKOL MC-236 CLASS B BASE
| |
|
WB EPOXY 850 PART A, P25V00100
| |
|
22538, AMINO ACID F REAGENT (SEE SUPPL)
| |
|
UNIVER 3 HARDNESS REAGENT, #962
| 497-19-8
7757-83-7
12125-02-9
14402-88-1 |
|
862, THERMOCOUPLE ALLOYS (3% TUNGSTEN)
| 7440-33-7 |
|
LTSA-35A (QPL BLEND)
| |
|
PRELUBE 6
| |
|
BORA-CARE
| |
|
IMPERIAL 2135TH, (SEE SUPPL)
| |
|
NP-6000/7000/8000 SERIES TONER BLACK(SEE SUPPL)
| |
|
"VERTREL" MCA PLUS; KCD-9546
| 138495-42-8
156-60-5
287-92-3
75-83-2 |
|
DOW CORNING 732 MULTI PURPOSE SEALANT, CLEAR
| 4253-34-3
17689-77-9
7631-86-9 |
|
602722-00, MOBIL DTE 15M
| |
|
MG0554PL, MG055422, MAG I ALL FLEET SAE 15W40 (SEE SUPPL)
| |
|
CHROMIUM ALLOYED STEEL CASTINGS
| 7440-44-0
7440-47-3
1309-37-1
7439-96-5
7439-98-7
7440-02-0
7440-21-3
7704-34-9
7440-33-7
7440-62-2 |
|
ENERGIZER, ENERGIZER E2, INDUSTRIAL ZMA; HERCULES
| 7782-42-5
1313-13-9
1310-58-3
7440-66-6 |
|
CHEM-LOC 101, DUST CONTROL AGENT
| |
|
0315-1, ULTRA PREP ULTRA-LOW RESIDUE HANDWIPE AGENT
| |
|
DOW CORNING 795 SILICONE BUILDING SEALANT, GRAY
| 112945-52-5
1185-55-3 |
|
HP 4500 PHOTOPRECISE TONER - YELLOW (SEE SUPPL)
| |
|
SEALED LEAD ACID BATTERY
| 7664-93-9
9003-07-0
65997-17-3
7439-92-1 |
|
03386, BRAKE FLUID 1000
| |
|
CLEAN AND SHEEN
| 74-98-6
106-97-8 |
|
VV-L-800C LUBRICATING OIL,GENERAL PURPOSE PRESERVATIVE
| 61790-48-5
64741-88-4
64742-53-6
68608-26-4 |
|
HEMATOXYLIN SOLUTION GILL NO 3, GHS-3, COMPONENT OF 91-6
| |
|
SEALED LEAD ACID BATTERY
| 7664-93-9
9003-07-0
65997-17-3
7439-92-1 |
|
HYDRAULIC FLUID, PETROLEUM BASE ISO 32
| |
|
QUICK START STARTING FLUID CYLINDER (SEE SUPPL)
| |
|
NEW II (MIL-PRF-680, TYPE II) ENVIRONMENTALLY PREFERRED PART
| |
|
34/78-1050, ENGINE STARTING BATTERIES (GROUP 34)
| 7664-93-9
9003-07-0
65997-17-3
7439-92-1 |
|
MIL-P-46002B GRADE 1
| |
|
0296-01, ELECTRON
| |
|
GLASS & WINDOW CLEANER
| 74-98-6
106-97-8
111-76-2
7664-41-7
7732-18-5 |
|
CHEMICAL #1
| |
|
CHEMICAL #2
| |
|
CHEMICAL #3
| |
|
AAF44-12,32 AUTOPRIDE DOT 3 STANDARD HEAVY DUTY BRAKE FLUID
| |
|
|