| MSDS | : | CHEMGLAZE A352 COATINGS MOISTURE CURE, A3820R | | CAS | : | 100-41-4
1330-20-7
108-10-1
108-88-3
4098-71-9
1333-86-4
123-86-4
5124-30-1
64742-95-6
108-65-6
88917-22-0 | | NAME | : | benzene, ethyl-; (ethyl benzene) (sara iii). vp: 7.1 @ 20c.
xylene. vp: 6.6 @ 20c.
2-pentanone, 4-methyl-; (methyl isobutyl ketone) (sara iii). vp: 15 @
toluene. vp: 22 @ 20c.
isocyanic acid,methylene (3,5,5-trimethyl-3,1-cyclohexylene) ester;
carbon black
acetic acid, butyl ester; (n-butyl acetate) (sara iii). vp: 8 @ 20c.
isocyanic acid, methylenedi-4,1-cyclohexylene ester; methylenebis
solvent naphtha (petroleum), light aromatic; (naphtha light aromatic).
acetic acid, 2-methoxy-1-methylethyl ester; (propyleneglycol methylether
dipropylene glycol methyl ether acetate. vp: >0.1 @ 20c.
efts of overexp:affect gi sys. may affect blood & blood forming
ing 12: occup chem reprod hazs. seek consultation from approp hlth
ing 13: and safe handling and exposure information (fp n).
spill proc:flamm vaps. notify approp auth,if nec. contain & remove
other prec: allergic skin rxn. pvnt prlngd/rptd brthg of vap/spray mists.
ing 16: have been read & understood. never use press to empty. drum
ing 17: slide container. do not weld or flame-cut an empty drum.
vent:vaps are hvr/air & collect in lower levs of work area.suff
ing 19: to pvnt flamm vap/air mix from accumulating. all applic areas
other prot equip: applying matl, & expos to overspray may occur,
ing 21: faceshield, gloves and overshoes is recommended.
|
| |
|
|
LORD CHEMICAL PRODUCTS -- CHEMGLAZE A352 COATINGS MOISTURE CURE, A3820R
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BVZTK
MSDS NAME: CHEMGLAZE A352 COATINGS MOISTURE CURE, A3820R
Responsible Party
Name: LORD CHEMICAL PRODUCTS
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514
Info Phone: 814-868-3611
Emergency Phone Number: 814-763-2345
Preparer's Name: K.M.B.
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LORD CHEMICAL PRODUCT
Address: 2000 WEST GRANDVIEW BLVD
Box: 10038
City: ERIE PA 16514-0038
Phone: 814-763-2345"EMERG SAFETY ENGINEER"
Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514-0038
Phone: 814-868-3611
=======================================================
Ingredients
=======================================================
Cas: 100-41-4
RTECS #: DA0700000
Name: BENZENE, ETHYL-; (ETHYL BENZENE) (SARA III). VP: 7.1 @ 20C.
% Wt: <10
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM;125 PPM STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
Name: XYLENE. VP: 6.6 @ 20C.
% Wt: <20
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM;150 PPM STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 108-10-1
RTECS #: SA9275000
Name: 2-PENTANONE, 4-METHYL-; (METHYL ISOBUTYL KETONE) (SARA III). VP: 15 @
20C.
% Wt: <2.0
OSHA PEL: 100 PPM
ACGIH TLV: 50 PPM;75 PPM STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 108-88-3
RTECS #: XS5250000
Name: TOLUENE. VP: 22 @ 20C.
% Wt: <4.0
OSHA PEL: 200 PPM
ACGIH TLV: 50 PPM,S
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 4098-71-9
RTECS #: NQ9370000
Name: ISOCYANIC ACID,METHYLENE (3,5,5-TRIMETHYL-3,1-CYCLOHEXYLENE) ESTER;
(ISOPHORONE DIISOCYANATE)(SARA III).VP:0.0004 @ 20C.
% Wt: <1.0
OSHA PEL: N/K (FP N)
ACGIH TLV: 0.005 PPM
------------------------------
Cas: 1333-86-4
RTECS #: FF5800000
Name: CARBON BLACK
% Wt: <3.0
OSHA PEL: 3.5 MG/M3
ACGIH TLV: 3.5 MG/M3
------------------------------
Cas: 123-86-4
RTECS #: AF7350000
Name: ACETIC ACID, BUTYL ESTER; (N-BUTYL ACETATE) (SARA III). VP: 8 @ 20C.
% Wt: <10
OSHA PEL: 150 PPM
ACGIH TLV: 150 PPM;200 PPM STEL
EPA Rpt Qty: 5000 LBS
DOT Rpt Qty: 5000 LBS
------------------------------
Cas: 5124-30-1
RTECS #: NQ9250000
Name: ISOCYANIC ACID, METHYLENEDI-4,1-CYCLOHEXYLENE ESTER; METHYLENEBIS
4-CYCLOHEXYLISOCYANATE). VP: 0.001 @ 20C.
% Wt: <4.0
OSHA PEL: 0.01 PPM, C
ACGIH TLV: 0.005 PPM
------------------------------
Cas: 64742-95-6
RTECS #: WF3400000
Name: SOLVENT NAPHTHA (PETROLEUM), LIGHT AROMATIC; (NAPHTHA LIGHT AROMATIC).
VP: 3.0 @ 20C.
% Wt: <10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 108-65-6
RTECS #: AI8295000
Name: ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (PROPYLENEGLYCOL METHYLETHER
ACETATE). VP: 3.7 @ 20C.
% Wt: <10
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 88917-22-0
Name: DIPROPYLENE GLYCOL METHYL ETHER ACETATE. VP: >0.1 @ 20C.
% Wt: <2.0
OSHA PEL: 100 PPM, S
ACGIH TLV: 100 PPM, S
------------------------------
Name: EFTS OF OVEREXP:AFFECT GI SYS. MAY AFFECT BLOOD & BLOOD FORMING
ORGANS. NOTE: TOLUENE APPEARS ON NAVY LISTING OF
-----------------------------
Name: ING 12: OCCUP CHEM REPROD HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSIONALS CONCERNING LATEST HAZ LIST INFO
-----------------------------
Name: ING 13: AND SAFE HANDLING AND EXPOSURE INFORMATION (FP N).
-----------------------------
Name: SPILL PROC:FLAMM VAPS. NOTIFY APPROP AUTH,IF NEC. CONTAIN & REMOVE
W/INERT ABSORB MATL & NON-SPARKING TOOLS. AVOID CONT.
-----------------------------
Name: OTHER PREC: ALLERGIC SKIN RXN. PVNT PRLNGD/RPTD BRTHG OF VAP/SPRAY MISTS.
DO NOT HNDL UNTIL MFR'S SAFETY PRECS
-----------------------------
Name: ING 16: HAVE BEEN READ & UNDERSTOOD. NEVER USE PRESS TO EMPTY. DRUM
IS NOT PRESS VESSEL. DO NOT PUNCTURE,DRAG OR
-----------------------------
Name: ING 17: SLIDE CONTAINER. DO NOT WELD OR FLAME-CUT AN EMPTY DRUM.
-----------------------------
Name: VENT:VAPS ARE HVR/AIR & COLLECT IN LOWER LEVS OF WORK AREA.SUFF
VENT(USING EXPLO PROOF EQUIP) SHOULD BE PROVIDED
-----------------------------
Name: ING 19: TO PVNT FLAMM VAP/AIR MIX FROM ACCUMULATING. ALL APPLIC AREAS
SHOULD BE VENT I/A/W OSHA REG 29 CFR PART 1910.94.
-----------------------------
Name: OTHER PROT EQUIP: APPLYING MATL, & EXPOS TO OVERSPRAY MAY OCCUR,
IMPERVIOUS PROT CLTHG INCL HEAD COVERING &
-----------------------------
Name: ING 21: FACESHIELD, GLOVES AND OVERSHOES IS RECOMMENDED.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE: POSS IRRIT OF RESP SYS CAN OCCUR CAUSING VARIETY OF
SYMPS SUCH AS DRYNESS OF THROAT, TIGHTNESS OF CHEST, & SHORT OF BRTH.
ALLERGIC CNDTNS CAN OCCUR IN CERTAIN INDIVS W/HIGH SENSITIVITY TO ISOCY
ANATES. THIS MAY RSLT IN ASTHMA-LIKE SYMPS. ANESTHETIC. RESP IRRIT. SKIN
IRRIT. EYE IRRIT. MAY CAUSE (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: CNS DEPRESS CHARACT BY FOLLOWING
PROGRESSIVE STEPS: HDCH, DIZZ, STAG GAIT, CONFUSN, UNCON/COMA. MAY CAUSE HDCH
& NAUS. CHRONIC: MAY CAUSE SKIN SENSIT. MAY CAUSE DERM. MAY CAUSE RESP
SENSIT. MAY CAUSE LIVER/KIDNEY DMG. RPTD/PRLNGDSOLV OVEREXP MAY RSLT IN PERM
CNS DMG. MAY CAUSE LONG-TERM LUNG DMG. MAY
Medical Cond Aggravated By Exposure: RESP ALLERGIES. CHRONIC DISEASES OF SKIN.
CHRONIC DISEASES OF NOSE, THROAT & RESP TRACT. CHRONIC DISEASES OF CNS.
CHRONIC DISEASES OF EYES. CHRONIC DISEASES OF GASTROINTESTINAL TRACT.
First Aid: INHAL: MOVE PERSON TO FRESH AIR. RESTORE BRTHG BY ARTF RESP, IF NEC.
TREAT SYMP. CONSULT PHYS. EYES: FLUSH IMMED W/LRG AMOUNTS OF WATER FOR AT LST
15 MINS, HOLDING EYELIDS OPEN WHILE FLUSHING. GET PRO MPT MED ATTN. SKIN:
FLUSH CONTAMD SKIN & CLTHG W/LRG AMTS OF WATER. REMOVE CONTAMD CLTHG.
WASH AFFECTED SKIN AREAS W/SOAP & WATER. CONSULT PHYS IF IRRIT PERSISTS.
INGEST: DRINK 1-2 GLASSES OF (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVAC NON-ESSENT PERS. REMOVE ALL SOURCES OF IGNIT
(FLAME, HOT SURFS,& ELEC, STATIC OR FRICTIONAL SPARKS). AVOID BRTHG VAPS.
USE NIOSH/MSHA APPRVD SELF-CONTAINED BRTHG EQUIP. VENT AREA W/EXPLO-PROOF DR
IVEN EQUIP, BECAUSE OF POSS PRESENCE OF
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP SHOULD BE DONE I/A/W FED (40CFR PART 261), STATE
& LOC ENVIRON CNTRL REGS. BEFORE ATTEMPTING CLEAN-UP, REFER TO HAZARD
CAUTION INFO IN OTHER SECTIONS OF MSDS. IF WASTE IS DETERMD TO BE HAZ, USE L
ICENSED HAZ WASTE TRANSPORTER & DISP FACILITY.
Handling And Storage Precautions: DO NOT STORE OR USE NEAR HEAT OR OPEN FLAME.
REFER TO OSHA 29CFR PART 1910.106 "FLAMMABLE AND COMBUSTIBLE LIQUIDS" FOR
SPECIFIC STORAGE REQUIREMENTS.
Other Precautions: KEEP CLOSURE TIGHT & CNTNR UPRIGHT TO PVNT LEAKAGE.
STORE DRUM OUT OF SUN & AWAY FROM HEAT.STORE ONLY IN WELL-VENT AREAS.
METAL CNTNRS OF MATL SHOULD BE GROUNDED & BONDED WHEN POURING. DO NOT GET
IN E YES. AVOID SKIN CONT.CAN CAUSE
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 81F,27.2C
Lower Limits: 1%
Upper Limits: 13.1%
Extinguishing Media: DRY CHEMICAL, CARBON DIOXIDE, WATER FOG, FOAM.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP(FP
N).IF WATER IS USED,FOG NOZZ ARE PREF.DURING FIRE,IRRIT &/OR TOX GASES
& PARTICULATE FROM DECOMP MAY BE(SUPDAT)
Unusual Fire/Explosion Hazard: KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM HEAT,
ELEC EQUIP, SPARKS, OPEN FLAME & OTHER SOURCES OF IGNIT.CLSD CNTNRS MAY
RUPTURE WHEN EXPOS TO EXTREME HEAT.(SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED AIRLINE TYPE RESPIRATORS OR
HOODS IN CONFINED AREAS. PRODUCT CONTAINS ISOCYANATES WHICH HAVE POOR ODOR
WARNING PROPERTIES. IF OCCUPATIONAL EXPOSURE LIMITS ARE EXCEEDED, NIOSH/M SHA
APPRVD SUPP AIR RESP SHOULD BE USED.
Ventilation: SUFF VENT, IN PATTERN & VOL, SHOULD BE PROVIDED TO KEEP AIR
CONTAM CONC BELOW APPLIC EXPOS LIMITS. CAUTION:SOLV
Protective Gloves: NEOPRENE, NITRILE OR RUBBER GLOVES.
Eye Protection: ANSI APPROVED CHEM WORKERS GOGG (FP N).
Other Protective Equipment: USE DISP/IMPERVIOUS CLTHG IF WORK CLTHG CONTAM IS
LIKELY. REMOVE & WASH CONTAMD CLTHG BEFORE REUSE. WHEN SPRAY
Work Hygienic Practices: WASH HANDS BEFORE EATING, DRINKING/USING WASH ROOM. DO
NOT SMOKE IN ANY CHEM HNDLG/STORAGE AREA. FOOD/BEVERAGES (SUPDAT)
Supplemental Safety and Health: FIRE FIGHT PROC: PRESENT.EXPLO HAZ:WATER MAY BE
USED TO COOL CLSD CNTNRS TO PVNT PRESS BUILDUP & POSS AUTOIGNIT/EXPLO.
FIRST AID PROC: WATER/MILK TO DILUTE.DO NOT INDUCE VOMIT. CONSULT PHYS/POIS
CNTRL CNTR IMMED.TREAT SYMP.HYGIENE PRACT: SHOULD NOT BE CONSUMED ANYWHERE
THIS PROD IS HNDLD/STORED. WASH THORO AFTER HNDLG.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: F4
B.P. Text: >232F,>111C
Vapor Pres: SEE INGS
Vapor Density: HVR/AIR
Spec Gravity: 0.984 (FP N)
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: BLACK LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume: 61.1
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES. SOURCES OF IGNITION.
Materials To Avoid: AMINES, ACIDS, WATER, HYDROXYL OR ACTIVE HYDROGEN
COMPOUNDS. STRONG ACIDS, BASES AND STRONG OXIDIZERS.
Hazardous Decomposition Products: MONOMERIC ISOCYANATE, TRACES OF HYDROGEN
CYANIDE, NITROGEN DIOXIDE. CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: CHEMGLAZE A352 COATINGS MOISTURE CURE, A3820R
Assigned IND: Y
Company: LORD CHEMICAL PRODUCT
Street: 2000 WEST GRANDVIEW BLVD
PO Box: 10038
City: ERIE PA
Zipcode: 16514-0038
Health Emergency Phone: 814-763-2345
Label Required IND: Y
Date Of Label Review: 11/11/1994
Status Code: C
Label Date: 11/11/1994
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAMMABLE LIQUID CLASS IC. ACUTE: POSS IRRIT OF RESP
SYS CAN OCCUR CAUSING VARIETY OF SYMPS SUCH AS DRYNESS OF THROAT, TIGHTNESS
OF CHEST, AND SHORTNESS OF BREATH. ALLERGIC CNDTNS CAN OCCUR IN CERTAIN
INDIVS WITH HIGH SENSITIVITY TO ISOCYANATES. THIS MAY RESULT IN ASTHMA-LIKE
SYMPTOMS. ANESTHETIC. RESPIRATORY IRRITATION. SKIN IRRIT. EYE IRRIT. MAY
CAUSE CNS DEPRESS W/HEADACHE, DIZZINESS, CONFUSION , UNCON/COMA. CHRONIC: MAY
CAUSE SKIN/RESP SENSIT. MAY CAUSE DERM. MAY CAUSE LIVER/KIDNEY DMG. MAY CAUSE
LONG TERM LUNG DMG. MAY AFFECT GI SYS, BLOOD & BLOOD FORMING ORGANS.
CONTAINS TOLUENE WHICH APP EARS ON NAVY OCCUP CHEM REPRO HAZ LIST (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|