ing 5:periods of time. this mix is noncorr & may be used w/all matls ing 6:which are formed w/air to be hydrated so that they increase in ing 7:formation). concs of so*2, cl*2, salt, etc. in the moisture other prec:title iii, section 313 not required. msds toxicity property">
oxygen; bp:-297.3f (-182.9c), vp:is above the critical temperature @ nitrogen; bp -320.5f (-195.8c), vp:above the critical temperature @ 70f sup dat:emer exists. do not allow temp where cyls are stored to exceed ing 4:be segregated. use a "first in-first out" inventory sys to pvnt ing 5:periods of time. this mix is noncorr & may be used w/all matls ing 6:which are formed w/air to be hydrated so that they increase in ing 7:formation). concs of so*2, cl*2, salt, etc. in the moisture other prec:title iii, section 313 not required. msds toxicity property">
MSDS
:
0.35% PENTANE AND 19% OXYGEN IN NITROGEN.
CAS
:
109-66-0 7782-44-7 7727-37-9
NAME
:
pentane; bp:97f (36c) vp:@ 100f(37.8c)=15 psia (103 kpa) mp:-201.5f oxygen; bp:-297.3f (-182.9c), vp:is above the critical temperature @ nitrogen; bp -320.5f (-195.8c), vp:above the critical temperature @ 70f sup dat:emer exists. do not allow temp where cyls are stored to exceed ing 4:be segregated. use a "first in-first out" inventory sys to pvnt ing 5:periods of time. this mix is noncorr & may be used w/all matls ing 6:which are formed w/air to be hydrated so that they increase in ing 7:formation). concs of so*2, cl*2, salt, etc. in the moisture other prec:title iii, section 313 not required.
LIQUID AIR CORP -- 0.35% PENTANE AND 19% OXYGEN IN NITROGEN.
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BWBDG
MSDS NAME: 0.35% PENTANE AND 19% OXYGEN IN NITROGEN.
Responsible Party
Name: LIQUID AIR CORP
Address: CA PLZ 2121 N CALIFORNIA BLVD
City: WALNUT CREEK CA 94596
Info Phone: 415-977-6500
Emergency Phone Number: 800-424-9300(CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LIQUID AIR CORP ONE CALIFORNIA PLAZA
Address: 2121 N. CALIFORNIA BLVD
City: WALNUT CREEK CA 94596
Phone: 415-977-6500
=======================================================
Ingredients
=======================================================
Cas: 109-66-0
RTECS #: RZ9450000
Name: PENTANE; BP:97F (36C) VP:@ 100F(37.8C)=15 PSIA (103 KPA) MP:-201.5F
(-129.7C)
% Wt: 0.35
OSHA PEL: 1000 PPM
ACGIH TLV: 600 PPM
------------------------------
Cas: 7782-44-7
RTECS #: RS2060000
Name: OXYGEN; BP:-297.3F (-182.9C), VP:IS ABOVE THE CRITICAL TEMPERATURE @
70F(21.1C), MP:-361.8F (-218.8C).
% Wt: 19
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 7727-37-9
RTECS #: QW9700000
Name: NITROGEN; BP -320.5F (-195.8C), VP:ABOVE THE CRITICAL TEMPERATURE @ 70F
(21.1C), MP: -345.9F (-209.9C).
OSHA PEL: N/K (FP N)
ACGIH TLV: ASPHYXIANT
------------------------------
Name: SUP DAT:EMER EXISTS. DO NOT ALLOW TEMP WHERE CYLS ARE STORED TO EXCEED
125F (52C). FULL & EMPTY CYLS SHOULD BE
-----------------------------
Name: ING 4:BE SEGREGATED. USE A "FIRST IN-FIRST OUT" INVENTORY SYS TO PVNT
FULL CYLS BEING STORED FOR EXCESSIVE
-----------------------------
Name: ING 5:PERIODS OF TIME. THIS MIX IS NONCORR & MAY BE USED W/ALL MATLS
OF CONSTRUCT. MOISTURE CAUSES METAL OXIDES
-----------------------------
Name: ING 6:WHICH ARE FORMED W/AIR TO BE HYDRATED SO THAT THEY INCREASE IN
VOLUME & LOSE THEIR PROT ROLE (RUST
-----------------------------
Name: ING 7:FORMATION). CONCS OF SO*2, CL*2, SALT, ETC. IN THE MOISTURE
ENHANCES THE RUSTING OF METALS IN AIR.
-----------------------------
Name: OTHER PREC:TITLE III, SECTION 313 NOT REQUIRED.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: THIS MIXTURE SHOULD BE CONSIDERED SIMILAR TO AIR AND WOULD
THEREFORE CAUSE NO SYMPTOMS OF EXPOSURE.
Explanation Of Carcinogenicity: NOT RELEVANT
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INGEST:CALL MD IMMEDIATELY (FP N). INHAL:REMOVE TO FRESH AIR.
SUPPORT BREATHING (GIVE O*2/ARTF RESP) (FP N). EYES:IMMEDIATELY FLUSH
W/POTABLE WATER FOR A MINIMUM OF 15 MINUTES, SEEK ASSISTANCE FROM MD (FP N).
SKIN:FLUSH W/COPIOUS AMOUNTS OF WATER. CALL MD (FP N).
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: NONE SPECIFIED BY MANUFACTURER.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N).
Handling And Storage Precautions: USE A PRESS REDUCING REGULATOR WHEN
CONNECTING CYLINDER TO LOWER PRESS (<500 PSIG) PIPING/SYSTEMS. DO NOT HEAT
CYLINDER BY ANY MEANS TO (SUPP DATA)
Other Precautions: DOT 39 CYLS MAY NOT BE REUSED/REFILLED (49CFR). NEVER
TRANSPORT THESE CYLS IN TRUNKS OF VEHICLES, ENCLSD VANS, TRUCK CABS/IN
PASSENGER COMPARTMENTS. TRANSPORT THEM "CNTND" IN OPEN FLATBED/PICKUP TYPE
VEHICLES. RPTDG UNDER SARA,
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: NONFLAMMABLE GAS MIXTURE.
Fire Fighting Procedures: WEAR NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N). IF CYLINDERS ARE INVOLVED IN A FIRE, SAFELY RELOCATE OR
KEEP COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard: THIS MIXTURE AT HIGH PRESSURES WILL ACCELERATE
THE BURNING OF MATERIALS TO A GREATER RATE THAN THEY BURN AT ATMOSPHERIC
PRESSURE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH/MSHA APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN (FP N).
Ventilation: NONE
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS (FP N).
Other Protective Equipment: SAFETY SHOES.
Work Hygienic Practices: NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health: SPEC GRAV:(AIR=1 @ 70F (21.1C)=1.00. HNDLG/STOR
PREC:INCREASE DISCHARGE RATE OF PROD FROM CYL. USE A CHECK VALVE/TRAP IN
DISCHARGE LINE TO PVNT HAZ BACK FLOW INTO CYL. CLOSE VALVE AFTER EACH USE
& WHE N EMPTY. PROT CYLS FROM PHYSICAL DMG. STORE IN COOL, DRY, WELL VENT
AREA AWAY FROM HEAVILY TRAFFICKED AREAS &
=======================================================
Physical/Chemical Properties
=======================================================
HCC: G3
B.P. Text: SEE INGS
M.P/F.P Text: SEE INGS
Vapor Pres: SEE INGS
Spec Gravity: (SUPP DATA)
Solubility in Water: VERY SLIGHTLY
Appearance and Odor: COLORLESS GAS WITH VERY SLIGHT PARAFFINIC ODOR.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Materials To Avoid: NONE
Hazardous Decomposition Products: NONE
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: 0.35% PENTANE AND 19% OXYGEN IN NITROGEN.
Company: LIQUID AIR CORP ONE CALIFORNIA PLAZA
Street: 2121 N. CALIFORNIA BLVD
City: WALNUT CREEK CA
Zipcode: 94596
Health Emergency Phone: 800-424-9300(CHEMTREC)
Label Required IND: Y
Date Of Label Review: 11/18/1994
Status Code: C
Label Date: 11/18/1994
Origination Code: G
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: NONE
Respiratory Protection IND: YES
Health Hazard: None
Contact Hazard: None
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: THIS MIXTURE SHOULD BE CONSIDERED SIMILAR TO AIR AND
WOULD THEREFORE CAUSE NO SYMPTOMS OF EXPOSURE.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.