HARCROS CHEMICALS INC -- T DET N 307, 15546
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BWLWY
MSDS NAME: T DET N 307, 15546
Responsible Party
Name: HARCROS CHEMICALS INC
Address: 5200 SPEAKER RD
City: KANSAS CITY KS 66106-1095
Info Phone: 913-321-3131
Emergency Phone Number: 800-424-9300 (CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: HARCROS CHEMICALS INC.
Address: 5200-SPEAKER ROAD
Box: 2383
City: KANSAS CITY KS 66106-1095
Phone: 913-321-3131
=======================================================
Ingredients
=======================================================
Cas: 9016-45-9
RTECS #: MD0900000
Name: GLYCOLS, POLYETHYLENE, MONO(NONYLPHENYL) ETHER; (NONYLPHENOL ETHOXYLATE)
% Wt: 71
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Name: SUPDAT:BY MOUTH TO UNCON PERSON. CALL PHYS.
-----------------------------
Name: SPILL RELEASE:WATERS, & SEWERS. IT MAY BE NEC TO REMOVE CONTAMD SOIL.
IF PROD IS FLAM/COMBUST, USE NON SPARKING
-----------------------------
Name: ING 3:TOOLS. IF ACIDITY (LOW PH) IS PROBLEM, NEUT W/DILUTE ACETIC
ACID/DILUTE HYDROCHLORIC (MURIATIC) ACID. IF
-----------------------------
Name: ING 4:REQD, NOTIFY STATE AND LOCAL AUTHORITIES. PROD MAY BE TOXIC TO FISH
OR AQUATIC LIFE.
-----------------------------
Name: WASTE DISP:MAY BE MORE STRINGENT THAN FEDERAL/STATE. PROD MAY CAUSE
FOAMING PROBLEMS.
-----------------------------
Name: RESP PROT:USED. IF PROD IS HNDLD ACCORDING TO RECOMMENDATIONS SET FORTH
IN THIS MATERIAL SAFETY DATA SHEET,
-----------------------------
Name: ING 7:PRESENCE OF TRACE AMTS IS NOT EXPECTED TO RSLT IN ANY SHORT/LONG
TERM HAZ. ETHYLENE OXIDE & PROPYLENE
-----------------------------
Name: ING 8:OXIDE ARE CONSIDERED BY OSHA AS POTNTL CARCIN & REPROD HAZ FOR
HUMANS. HARCROS URGES THAT USERS OF PROD
-----------------------------
Name: ING 9:CONFIRM THAT THEIR OPERATING, STOR & DISTRIBUTION FACILITIES
COMPLY W/OSHA STD (29 CFR 1910.1047), AND
-----------------------------
Name: ING 10:THAT PERS BE MONITORED TO DETERMINE LEVELS OF EXPOSURE.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: NO
Skin: YES
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYES:MAY CAUSE IRRITATION BURNS. SKIN:MAY CAUSE
IRRITATION. INHALATION:MAY CAUSE IRRITATION, COUGHING, HEADACHE, NAUSEA,
DROWSINESS. INGESTION:MAY CAUSE NAUSEA, VOMITING, DIARRHEA. CHRONIC:PROLO
NGED OR REPEATED SKIN CONTACT MAY CAUSEIRRITATION, DERMATITIS. MAY BE
ABSORBED IN HARMFUL AMOUNTS.
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
Medical Cond Aggravated By Exposure: DISORDERS OF SKIN.
First Aid: EYES:IMMED FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MINS, WHILE
HOLDING APART TO ENSURE FLUSHING OF ENTIRE SURF. CALL PHYS. SKIN:IMMED FLUSH
W/PLENTY OF WATER FOR @ LEAST 15 MINS, WHILE REMOVING CONTAMD CLTHG &
SHOES. THORO CLEAN CLTHG & SHOES BEFORE REUSE. CALL PHYS. INHAL:REMOVE TO
FRESH AIR. IF NOT BRTHG GIVE ARTF RESP, PREF MOUTH TO MOUTH. INGEST:INDUCE
VOMIT IMMED BY GIVING 2 GLASSES (SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: EVACUATE NON ESSENTIAL PERS, ELIM IGNIT SOURCES,
& WEAR PROT EQUIP. SHUT OFF SOURCE OF LEAK ONLY IF SAFE TO DO SO. CONTAIN
SPILL. RECOVER FREE PROD. TO CLEAN UP RESIDUE, FLUSH SPARINGLY W/WATER/USE AB
SORB. AVOID RUNOFF TO GROUND WATER, SURF
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: SOLIDS MUST BE DISPOS OF IN PERMITTED HAZ WASTE
MANAGEMENT FACILITY. RECOVERED LIQ MAY BE REPROCESSED/INCINERATED. INCIN MUST
BE HNDLD IN PERMITTED HAZ WASTE MANAGEMENT FACILITY. DISPOSE OF MATL I/A/W
ALL FED, ST & LOCAL REGS. LOCAL REGS
Handling And Storage Precautions: WEAR PROT EQUIP WHEN HNDLG. USE ONLY W/ADEQ
VENT. DO NOT BREATHE VAP/MIST. DO NOT GET IN EYES. AVOID PRLNGD/RPTD CONT
WITH SKIN. FOR INDUST USE ONLY.
Other Precautions: KEEP CONTAINER CLOSED WHEN NOT IN USE. DO NOT STORE ABOVE
12F. KEEP OUT OF REACH OF CHILDREN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: PMCC
Flash Point Text: 212F,100C
Extinguishing Media: WATER SPRAY, DRY CHEMICAL, FOAM, CARBON DIOXIDE.
Fire Fighting Procedures: PVNT HUMAN EXPOS TO FIRE, FUMES, SMOKE, & PROD OF
COMBUST. EVACUATE NON-ESSENTIAL PERSN. NIOSH/MSHA APPRVD FULL FACE SCBA &
IMPERVIOUS PROT CLTHG. (SUPDAT)
Unusual Fire/Explosion Hazard: HOT ORG CHEM VAPS MAY SPONT IGNITE/EXPLODE WHEN
MIXED W/AIR, EVEN @ TEMPS BELOW THEIR PUBLISHED AUTOIGNITION TEMPERATURE.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE NORMALLY REQD. NIOSH/MSHA APPRVD RESP APPROP FOR
EXPOS OF CONCERN (FP N). TRACES OF ETHYLENE OXIDE AND/OR PROPLENE OXIDE COULD
ACCUM IN HEADSPACE OF DRUMS, STOR/TRANSPORT VESSELS/IN ENCLOSED AREA S WHERE
PROD IS BEING HNDLD OR
Ventilation: MECHANICAL GEN VENT IS USUALLY ADEQ. LOCAL MECH VENT MAY BE
REQUIRED.
Protective Gloves: IMPERVIOUS GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGG (FP N)
Other Protective Equipment: SAFETY SHOWER, EYE WASH FOUNTAIN, & WASHING
FACILITIES SHOULD BE READILY AVAILABLE.
Work Hygienic Practices: WASH THORO AFTER HANDLING. ALWAYS WEAR EYE PROT WHEN
WORKING W/CHEM. DO NOT WEAR CONT LENSES WHEN WORKING W/CHEMICALS.
Supplemental Safety and Health: PH:AQUEOUS APPROX. 5.0-7.0. FIRE FIGHT
PROC:DIRECT STREAM OF WATER MAY CAUSE FOAMING. USE WATER TO COOL CNTNRS EXPOS
TO FIRE. MATLS TO AVOID:PERCHLORATES, PERCARBONATES, PEROXIDES, CHROMATES,
HYPOCHLO RITES, NITRIC ACID, & SULFURIC ACID. FIRST AID PROC:OF WATER
& STICKING FINGER DOWN THROAT. NEVER GIVE ANYTHING
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >212F,>100C
M.P/F.P Text: 30.0F,-1.1C
Vapor Pres: <1.000@68F
Vapor Density: >1.00000
Spec Gravity: >1.0910 @ 68F
PH: SUPDAT
Solubility in Water: COMPLETE
Appearance and Odor: COLORLESS TO LIGHTLY COLORED LIQUID, MILD AROMATIC ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: INORG ACIDS, INORG BASES. AVOID CONT W/BLEACHING AGENTS &
OXIDIZERS WHICH INCL CHLORINE, OXYG, PERMANGANATES, (SUPDAT)
Hazardous Decomposition Products: CARBON MONOXIDE. MISCELLANEOUS ORGANIC
COMPOUNDS, SOME POSSIBLY TOXIC.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: T DET N 307, 15546
Company: HARCROS CHEMICALS INC.
Street: 5200-SPEAKER ROAD
PO Box: 2383
City: KANSAS CITY KS
Zipcode: 66106-1095
Health Emergency Phone: 800-424-9300 (CHEMTREC)
Label Required IND: Y
Date Of Label Review: 01/09/1995
Status Code: C
Label Date: 01/09/1995
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: Slight
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:EYES:IRRITATION BURNS.
INHAL:IRRITATION, COUGHING, HEADACHE, NAUSEA, DROWSINESS. INGEST:NAUSEA,
VOMITING, DIARRHEA. SKIN:IRRITATION. CHRONIC:SKIN:IRRITATION, DERMATITIS.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|