MSDS   | : | CARRIAGE CONTROL TAPE ADHESIVE, 419012 | CAS   | : | 71-55-6 1314-13-2 1309-48-4 | NAME   | : | methyl chloroform (1,1,1-trichloroehane) (sara iii) zinc oxide magnesium oxide rubber, synthetic, compounded resin, synthetic
|
| |
|
|
===================== Product Identification =====================
MSDS NAME:CARRIAGE CONTROL TAPE ADHESIVE, 419012
NIIN:00N003983
MSDS Number: BCLHX
=== Responsible Party ===
Company:IBM CORPORATION, INFORMATION RECORDS DIVISION
Emergency Phone Num:201-329-7131
CAGE:30338
=== Contractor Identification ===
Company:IBM CORPORATION, INFORMATION RECORDS DIVISION
CAGE:30338
============= Composition/Information on Ingredients =============
Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE) (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 85%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
Name:ZINC OXIDE
CAS:1314-13-2
RTECS #:ZH4810000
OSHA PEL:15MG/M3 TDUST/5 FUME
ACGIH TLV:10MG/M3 TDUST; 9293
Name:MAGNESIUM OXIDE
CAS:1309-48-4
RTECS #:OM3850000
OSHA PEL:15 MG/M3 PARTICULATE
ACGIH TLV:10 MG/M3;TDUST; 9293
Name:RUBBER, SYNTHETIC, COMPOUNDED
Name:RESIN, SYNTHETIC
===================== Hazards Identification =====================
Effects of
Overexposure:HDCH,VERTIGO,INCOORDINATION,NAUS,COMA,APNEA.EYES:MILD
CONJUNCTIVAL IRRIT.SKIN:DEFATTING DERMATITIS.
======================= First Aid Measures =======================
First Aid:REMOVE FROM EXPOSURE,GIVE CARDIOPULMONARY SUPPORT & OXYGEN AS
NEEDED.SKIN/EYES:FLUSH COPIOUSLY W/WATER AT LEAST 15
MINS.ING:INDUCE EMESIS ONLY IF PATIENT IS CONSCIOUS.AVOID DRENERGIC
PRESSORS IN TREAT ING SHOCK FROM MASSIVE OVER-EXPOSURE.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Lower Limits:7.0
Upper Limits:16.0
Extinguishing Media:CO*2
Fire Fighting Procedures:SCBA SHOULD BE WORN FIGHTING FIRES W/THIS
CHEMICAL.
Unusual Fire/Explosion Hazard:FIRES MAY CAUSE PRESSURE BUILD-UP IN
CANS.
================== Accidental Release Measures ==================
Spill Release Procedures:EXTINGUISH ALL FLAMES.SCRAPE UP EXCESS
W/NON-SPARKING TOOLS.CLEAN UP SPILL SITE W/NON-FLAMMABLE SOLVENT,
SUCH AS 1,1,1-TRICHLOROETHANE.AVOID VAPOR BUILD-UP.AVOID PROLONGED
SKIN CONTACT.
====================== Handling and Storage ======================
Handling and Storage Precautions:USE W/ADEQUATE VENT.AVOID BREATHING
VAPOR & CONTACT W/SKIN OR EYES.HARMFUL OR FATAL IF SWALLOWED.STORE
INSIDE WHERE POSSIBLE OR OUT OF DIRECT SUNLIGHT
Other Precautions:STORAGE AREAS SHOULD BE WELL VENTILATED & KEPT AS
CLOSE TO 70F,21C AS POSSIBLE.INCOMPATABILITY:SUCH AS ALUMINUM &
MAGNESIUM POWDERS,SODIUM,POTASSIUM.WELDING ARCS,STRONG UV
LIGHT.H*2O(SUPP DATA
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPRVD ORGANIC VAPOR MASK.
Ventilation:LOCAL EXHAUST TO MAINTAIN LEVELS BELOW TLV.
Protective Gloves:SOLVENT RESIST
Eye Protection:SFTY GLAS W/SIDE SHIELDS.
Supplemental Safety and Health
AUTOIGNITION TEMP:932F,500C.HEALTH HAZARD DATA REFERS TO
1,1,1-TRICHLOROETHANE.MFR STATES IS A CNS DEPRESSANT.SLOWLY
ABSORBED ACROSS INTACT SKIN.H*2O:SLOW HYDROLYSIS PROD CORROSIVE
ACID.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:165F,74C
Vapor Pres:100
Vapor Density:4.6
Spec Gravity:1.31
Evaporation Rate & Reference:7.5, BUAC
Solubility in Water:NEGLIGIBLE
Appearance and Odor:TAN MOBILE LIQUID,PUNGENT CHLOROFORM-LIKE ODOR.
Percent Volatiles by Volume:85.0
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG CAUSTICS & OXIDIZERS,CHEM ACTIVE METALS(SEE OTH PREC)
Stability Condition to Avoid:DIRECT EXPOSURE TO FLAMES, EXCESSIVE HEAT.
Hazardous Decomposition Products:DENSE ACRID
SMOKE,CO,CO*2,HCL,CL*2,POSS TRACES OF PHOSGENE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE IN LANDFILL IN ACCORDANCE W/LOCAL, STATE
& FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|