===================== Product Identification =====================
MSDS NAME:747 MASTIC REMOVER
NIIN:00F030278
MSDS Number: BRXYG
=== Responsible Party ===
Company:SENTINEL CHEMICAL CO INC
Address:7714 BEECH ST NE
City:MINNEAPOLIS
State:MN
ZIP:55432
Country:US
Info Phone Num:612-571-0630
Emergency Phone Num:612-571-0630
CAGE:SENTI
=== Contractor Identification ===
Company:SENTINEL CHEMICAL CO INC
Box:UNKNOW
CAGE:6R235
Company:SENTINEL CHEMICAL CO INC
Address:7714 BEECH ST NE
City:MINNEAPOLIS
State:MN
ZIP:55432
Country:US
Phone:612-571-0630
CAGE:SENTI
============= Composition/Information on Ingredients =============
Name:WEIGHT PER GALLON IN POUNDS: 6.71
RTECS #:9999999WG
Name:KEROSENE (PETROLEUM), HYDROTREATED; PETROLEUM DISTILLATE,
HYDROTREATED ,(MINERAL SPIRITS)
CAS:64742-47-8
RTECS #:OA5504000
ACGIH TLV:100 PPM
Name:2-BUTOXYETHANOL (ETHYLENEGLYCOL MONOBUTYL ETHER), BUTYL
CELLOSOLVE, BUTYL GLYCOL, GLYCOL ETHER EB
CAS:111-76-2
RTECS #:KJ8575000
Fraction by Wt: 2-6%
Other REC Limits:25 PPM (SKIN)
OSHA PEL:S, 50 PPM
ACGIH TLV:S, 25 PPM; 9293
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE: IRRITATION. SKIN:
IRRITATION/DERMATITIS. INHALATION: IRRITATION OF
NOSE/THROAT/NERVOUS SYSTEM DEPRESSION. INGESTION: IRRITATION OF
DIGESTIVE TRACT/NERVOUS SYSTEM DEPRESSION. NARCOSIS/PULMONARY ED
EMA/SEVERE KIDNEY & LIVER DAMAGE. ASPIRATION INTO LUNGS MAY CAUSE
LUNG INFLAMMATION & DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION/BURNS/TEARS/REDNESS. SKIN:
REDNESS/BURNS/DRYING/CRACKING/IRRITATION. INHALATION:
DROWSINESS/DIZZINESS/LOSS OF COORDINATION/FATIGUE. INGESTION:
DROWSINESS/DIZZINESS/LOSS OF COORDINATIO N/FATIGUE.
Medical Cond Aggravated by Exposure:SKIN DISORDERS, IMPAIRED LUNG
FUNCTION OR ASTHMA-LIKE CONDITIONS
======================= First Aid Measures =======================
Eyes: FLUSH W/PLENTY OF WATER FOR AT LEAST 15 MINS. SKIN:
REMOVE CONTAMINATED CLOTHING. WASH W/SOAP & WATER. INHALATION:
REMOVE TO FRESH AIR. IF NECESSARY, GIVE OXYGEN/CPR. INGESTION:
DON'T INDUCE VOM ITING. ASPIRATION HAZARD. OBTAIN MEDICAL ATTENTION
IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:141F
Lower Limits:1.2%
Upper Limits:6%
Extinguishing Media:SMALL FIRES: DRY CHEMICAL, CO2, OR FOAM. LARGE
FIRES: DRY CHEMICAL OR FOAM
Fire Fighting Procedures:USE SCBA. WATER SPRAY MAY BE USEFUL IN
MINIMIZING VAPORS/COOLING CONTAINERS EXPOSED TO HEAT/FLAME. AVOID
SPREADING BURNING LIQUID W/WATER USED FOR COOLING.
Unusual Fire/Explosion Hazard:THIS MATERIAL IS COMBUSTIBLE & MAY BE
IGNITED BY HEAT OR FLAME. THIS MATERIAL WILL BURN, BUT WILL NOT
IGNITE READILY.
================== Accidental Release Measures ==================
Spill Release Procedures:STAY UPWIND/AWAY FROM SPILL. KEEP FROM
IGNITION SOURCES. IF SPILLS IS INDOORS, VENTILATE AREA OF SPILL.
FOAM, ESPECIALLY HIGH EXPANSION FOAM, MAY BE USED TO SUPPRESS
VAPORS. KEEP CONTAINED/DISPOSE ACC ORDINGLY.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINERS TIGHTLY
CLOSED/COOL/DRY/AWAY FROM IGNITION SOURCES. USE & STORE W/ADEQUATE
VENTILATION. AVOID INHALATION OF VAPORS.
Other Precautions:DON'T PRESSURIZE/CUT/WELD/BRAZE/SOLDER/DRILL/GRIND.
EMPTY DRUMS SHOULD BE COMPLETELY DRAINED, PROPERLY BUNGED &
PROMPTLY SHIPPED TO A QUALIFIED DRUM RECONDITIONER.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NECESSARY TO MINIMIZE EXPOSURE TO ORGANIC VAPOR
OR GASES. DEPENDING ON NATURE & CONCENTRATION OF AIRBORNE MATERIAL,
USE RESPIRATOR/GAS MASK W/APPROPRIATE CARTRIDGES/CANISTERS (NIOSH
APPROVED) OR SUPPL IED AIR EQUIPMENT.
Ventilation:WHERE EXPLOSIVE MIXTURES MAY BE PRESENT, SYSTEMS SAFE FOR
SUCH LOCATIONS SHOULD BE USED. ADDITIONAL MAY BE NECESSARY.
Protective Gloves:IMPERMEABLE
Eye Protection:REQUIRED
Other Protective Equipment:SOURCE OF CLEAN WATER, IMPERVIOUS CLOTHING
Supplemental Safety and Health
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:370-518F
Vapor Pres:NEGLIGIBLE
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:LIGHT BLUE, MILD/CHARACTERISTIC ODOR.
Percent Volatiles by Volume:100
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HEAT, OPEN FLAME, HOT METAL SURFACES,
SPARKS, & OTHER SOURCES OF IGNITION
Hazardous Decomposition Products:CO, CO2
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, COUNTY,
FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|