===================== Product Identification =====================
MSDS NAME:GUN SCRUBBER
NIIN:00F035156
MSDS Number: BTKLH
=== Responsible Party ===
Company:BIRCHWOOD LABORATORIES INC.
Address:7900 FULLER ROAD
City:EDEN PRAIRIE
State:MN
ZIP:55344
Country:US
Info Phone Num:612-937-7933
Emergency Phone Num:612-937-7933
Preparer's Name:DEREK J BEMIS
CAGE:51243
=== Contractor Identification ===
Company:BIRCHWOOD LABORATORIES INC.
Address:7900 FULLER ROAD
Box:City:EDEN PRAIRIE
State:MN
ZIP:55344
Country:US
Phone:612-937-7900
CAGE:51243
============= Composition/Information on Ingredients =============
Name:CARBON DIOXIDE
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 2-20%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM 9394
Name:1,1,1-TRICHLOROETHANE (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 80-98%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM/450STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1
===================== Hazards Identification =====================
LD50 LC50 Mixture:ORAL LD50 (RAT) IS UNKNOWN.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: IRRITATION. SKIN:
IRRITATION. INHALATION: CNS DEPRESSION, HEADACHES, NAUSEA,
DIZZINESS, LOSS OF CONSCIOUSNESS. INGESTION: NOT LIKELY SOURCE OF
EXPOSURE. CHRONIC: PROLONGED CONTACT COULD R ESULT IN PERMANENT EYE
DAMAGE AND DEFATTING OF SKIN.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:EYES: IRRITATION, EYE DAMAGE. SKIN: IRRITATION,
DEFATTING. INHALATION: CNS DEPRESSION, HEADACHE, NAUSEA, DIZZINESS,
LOSS OF CONSCIOUSNESS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
Eyes: FLUSH WITH LARGE AMOUNTS OF WATER. IF IRRITATION
PERSISTS, GET MEDICAL ATTENTION. SKIN: REMOVE CONTAMINATED
CLOTHING. WASH SKIN AREA WITH SOAP AND WATER. IF IRRITATION
DEVELOPS, GET MEDICAL ATTE NTION. INHALATION: MOVE TO FRESH AIR.
ADMINISTER OXYGEN OR CPR IF NEEDED AND GET MEDICAL ATTENTION.
INGESTION: GET MEDICAL ATTENTION. TREATMENT IS DEPENDENT ON
CONDITION OF VICTIM.
===================== Fire Fighting Measures =====================
Flash Point:NOT FLAMMABLE
Lower Limits:7
Upper Limits:15
Extinguishing Media:USE MEDIA SUITABLE FOR SURROUNDING FIRE.
Fire Fighting Procedures:SCBA AND PROTECTIVE CLOTHING SHOULD BE WORN IN
FIGHTING FIRES INVOLVING CHEMICALS. AVOID ACCUMULTIONS OF VAPORS AT
FLOOR LEVEL, AS VAPOR IS HEAVIER THAN AIR.
Unusual Fire/Explosion Hazard:AVOID POSSIBLE BURSTING OF AEROSOL CAN.
DO NOT STORE WHERE TEMPERATURE MAY EXCEED 120F. DO NOT PUNCTURE OR
INCINERATE.
================== Accidental Release Measures ==================
Spill Release Procedures:VENTILATE AREA WELL. SOAK UP ON SUITABLE
ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
FIRE, SPARKS, OR FLAME. DO NOT STORE WHERE TEMPERATURES MAY EXCEED
120F.
Other Precautions:DO NOT USE NEAR HEAT, FIRE, FLAME, OR SPARKS. AVOID
EXCESSIVE BREATHING OF VAPOR. DO NOT SPRAY IN DIRECTION OF BODY.
USE ONLY IN ACCORDANCE WITH DIRECTIONS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NOT NECESSARY UNDER NORMAL USE. IF TLV EXCEEDED
OR IN CONFINED AREAS USE NIOSH/MSHA APPROVED SELF-CONTAINED
BREATHING DEVICE OR RESPIRATOR.
Ventilation:MUST BE ADEQUATE TO MAINTAIN VAPORS AT LESS THAN 350 PPM,
PARTICULARLY AT FLOOR LEVEL AS VAPORS ARE HEAVIER THAN AIR.
Protective Gloves:SOLVENT RESISTANT IF EXPOSURE EXPECTED.
Eye Protection:SAFETY GLASSES OR GOGGLES RECOMMENDED.
Other Protective Equipment:NORMALLY NOT NECESSARY.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NONE.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:AEROSOL
Vapor Pres:90 PSIG
Vapor Density:4.3
Spec Gravity:1.30
Evaporation Rate & Reference:<1 (ETHER = 1)
Solubility in Water:SLIGHT
Appearance and Odor:CLEAR LIQUID. CHLORINATED ODOR.
Percent Volatiles by Volume:97
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, ALKALIES, ALUMINUM.
Stability Condition to Avoid:HEAT, SPARKS, FLAMES. DO NOT STORE AT
TEMPERATURES ABOVE 120F.
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
HYDROGEN CHLORIDE VAPORS, TRACES OF PHOSGENE, AND UNIDENTIFIED
ORGANIC MATERIALS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WASTE IN ACCORDANCE WITH LOCAL, STATE
AND FEDERAL REGULATIONS. DO NOT PUNCTURE OR INCINERATE.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|