LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CHRONIC HEALTH EFFECTS ARE POSSIBLE
FROM LONG TERM EXPOSURE TO MATERIAL, INCLUDING DRYING, CRACKING AND
IRRITATION OF SKIN. REACTS WITH SKIN PROTEIN AND MOISTURE AND CAN
CAUSE RASH, SCALING OR BLISTER ING. HIGH CONCENTRATIONS MAY CAUSE
HEADACHES AND DIZZINESS, ARE ANESTHETIC, AND MAY HAVE OTHER CENTRAL
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HEALTH HAZARDS: NERVOUS SYSTEM EFFECTS,
INCLUDING DEATH. TOLUENE APPEARS ON NAVY LISTING OF OCCUPATIONAL
CHEMICAL REPRODUCTIVE HAZARDS. SEEK CONSULTATION FROM APPROPRIATE
HEALTH PROFESSIONALS CONCERNI NG LATEST HAZARD LIST INFORMATION AND
SAFE HANDLING AND EXPOSURE INFORMATION .
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE HEIGHTENED REACTION TO EXPOSURE TO THIS PRODUCT.
CONTACT LENS WEARERS SHOULD CONSULT PROVIDER BEFORE
HANDLING-CONSULT PHYS IMMED IF THERE IS EYE CONTACT.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE TO FRESH AIR, RESTORE BREATHING, CONSULT
PHYSICIAN. SKIN: FLUSH WITH WATER. EYE: FLUSH IMMEDIATELY WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CONSULT PHYSICIAN.
INGESTION: DO NOT INDUCE VOMITING. KEEP PERSON WARM, QUIET AND GET
MEDICAL ATTENTION. SMALL AMOUNTS OF LIQUID ASPIRATED INTO
RESPIRATORY SYSTEM DURING INGEST, OR FROM VOMIT, MAY CAUSE CHEM
PNEUM OR PULM EDEMA.
===================== Fire Fighting Measures =====================
Flash Point Method:SCC
Flash Point:31F,-0.6C
Lower Limits:0.3%
Upper Limits:11.4%
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT . WATER STREAM WILL SPREAD FIRE. DO NOT USE
WATER HOSE STREAM.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPARKS,& OPEN FLAME. CLSD CNTNRS MAY EXPLO WHEN EXPOS TO
EXTREME HEAT.WATER MAY BE USED TO COOL CLSD CNTNRS (ING 8)
Spill Release Procedures:AVOID BRTHG SOLV VAP.ENSURE ADEQ VENT. AVOID
SPARKS, FLAMES, & ANYTHING WHICH COULD CAUSE FIRE. ELIM SOURCE OF
SPILL IF YOU CAN DO SO W/OUT RISK BY CLOSING VALVE, PLUGGING HOLE,
ETC. APPLY ABSORB INER T MATL (SAND, DUST, VERMICULITE) TO
SPILL.(SUPDAT)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED WHEN BEING
EMPTIED.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURNING.
Respiratory Protection:NIOSH/MSHA APPRVD RESP TYPES SUITABLE FOR MATLS
IN ING SEC RECOM. NIOSH/MSHA APPRVD CHEM/MECH FILTERS RECOM WHEN
VENT IS RESTRICTED.PRECS MUST BE TAKEN SO THAT PERSONS DO NOT BRTH
VAPS/HAVE CONT W/EYE S/SKIN. PROT AGAINST EXPOS TO (SUPDAT)
Ventilation:SUFF VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO KEEP AIR
CONTAM BELOW CURRENT APPLIC OSHA PEL OR ACGIH'S TLV (SUPDAT)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKER GOGGLES .
Other Protective Equipment:USE PROTECTIVE CREAMS WHERE SKIN CONTACT IS
LIKELY. REMOVE AND WASH CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:USE NORMAL HYGIENE PRACTICES DURING AND AFTER
HANDLING THIS MATERIAL.
Supplemental Safety and Health
PART #/TRADE NAME: MIL-L-81352 LACQUER.SPILL PROC:CLEAN SPILL W/BRISTLE
BROOMS, NON-SPARKING TOOLS,CLEAN DRY RAGS.PROT CLTHG SHOULD BE
WORN.WASTE DISP METH:WASTE CODE F003 HAZ WASTE CHARACT IGNITABILI
TY. RESP PROT:BOTH VAP & SPRAY MIST. VENT:LIMIT. SOLV VAPS SHOULD
BE REMOVED FROM LOWER LEVS OF WORK AREA & IGNIT(ING 7)
Waste Disposal Methods:SOAK LIQS W/SAWDUST OR RAGS & REMOVE. FLUSH
W/WATER IF POSS. AVOID SKIN CONT. DISP SHOULD BE I/A/W LOC, ST, &
FED REGS. DO NOT INCIN, CUT/WELD EMPTY CNTNRS. WHEN DISCARDED MATL
IS HAZ WASTE. TRANSFER LIQ TO CNTNRS FOR RECOVERY/DISP. EPA HAZ
(SUPDAT)
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.