===================== Product Identification =====================
MSDS NAME:4860-50 A/C WASH PRIMER DARKND, 4860-50
NIIN:00N066434
MSDS Number: CBDPP
=== Responsible Party ===
Company:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTRERO AVE
City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Info Phone Num:818-444-9274
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:RICHARD STEWART
CAGE:65860
=== Contractor Identification ===
Company:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTERO AVE
Box:City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Phone:818-444-9274 OR 213-283-9335
CAGE:65860
============= Composition/Information on Ingredients =============
Name:CHROMIC ACID, ZINC SALT; (ZINC 69.5%/CHROME:HEX118.5%)
(ALTERNATE CAS #1308-13-0)
CAS:13530-65-9
RTECS #:GB3290000
Fraction by Wt: 7.59%
OSHA PEL:NIL (MFR)
ACGIH TLV:.05 MG/M3 (MFR)
Name:ISOBUTYL ALCOHOL; (2-METHYL-1-PROPANOL). VP:8.9 @ 68F
CAS:78-83-1
RTECS #:NP9625000
Fraction by Wt: 20%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:50 PPM (MFR)
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:ISOPROPYL ALCOHOL; (ISOPROPANOL, 2-PROPANOL) (SARA 313).
VP:33 @ 68F
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: 50%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM/500 STEL
Name:COATING VOLATILE ORGANIC COMPOUND:5.83 LG/GL (700 G/L).
MATERIAL VOLATILE ORGANIC COMPOUND:5.68 LB/GL (682 G/L)
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Name:OTHER PREC:THE FOLLOWING EFTS IN HUMANS; CARDIAC ABNORM,
LIVER ABNORM, KIDNEY DMG, AND LUNG DMG.
RTECS #:9999999ZZ
Name:RESP PROT:ENGINEERING OR ADMIN CONTROLS SHOULD BE
IMPLEMENTED TO REDUCE EXPOSURE.
RTECS #:9999999ZZ
Name:EYE PROT:& FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:SEV EYE IRRIT, REDNESS, TEARING,
& BLURRED VISION. CAN CAUSE MOD SKIN IRRIT, DEFAT, DERM & TINGLING
SENSATION. SYMPS OF OVEREXP:INHAL:HDCH, FATG, WEARINESS, NAUS,
VOMIT, DIZZ, STUPER, DROW, DIST URBED VISION, COUGH, & UNCON.
SKIN:PRLNGD CONT CAN CAUSE MOD IRRIT, DEFAT & DERM. EYES:CAN CAUSE
SEV (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ:IRRIT, REDNESS, TEARING, & BLURRED
VISION. SKIN ABSORP:MOD IRRIT, DEFAT, DERM, DRY SKIN, RASH.
INGEST:BREATH SMELLS OF SOLV. IRRIT OF LIPS & MOUTH, GI IRRIT,
NAUS, DIARR, DROW, LOSS OF CONSCI OUSNESS. STATE OF SHOCK, WEAK &
RAPID PULSE, COLD-PALE COMPLEXION. CHRONIC:MAY PRDCE LIVER & KIDNEY
DMG, (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER AND KIDNEY
DISORDERS.
======================= First Aid Measures =======================
Eyes:FLUSH W/PLENTY OF WATER FOR @ LEAST 15 MINS. GET MED
ATTN. SKIN:WASH EXPOSED AREA W/MILD SOAP & WATER FOR 15 MINS.
REMOVE CONTAMD CLTHG. INHAL:REMOVE TO FRESH AIR. IF BRTHG IS DFCLT,
ADMIN OXYG. IF BRTHG HAS STOPPED, GIVE ARTF RESP. GET MED ATTN.
INGEST:DO NOT INDUCE VOMIT. KEEP VICTIM WARM & SEEK IMMED MED ATTN.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:53.0F,11.7C
Lower Limits:1.2%
Upper Limits:12.0%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA W/FULL FACEPIECE
OPERATED IN PRESSURE DEMAND OR OTHER POSITIVE PRESSURE MODES.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT, SPK, ELEC EQUIP & OPEN FLAME. CLSD CNTNRS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DURING EMER CNDTNS, (SUPDAT)
================== Accidental Release Measures ==================
Spill Release Procedures:FOLLOW INSTRUCTIONS IN FIRE & EXPLO HAZ DATA,
REACTIVITY DATA, HEALTH HAZARD DATA TO PVNT HEALTH HAZARDS.
ELIMINATE ALL SOURCES OF IGNITION, ABSORB LIQUIDS IN ABSORBENT
MATERIAL & PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:CNTNRS MAY BE HAZ WHEN EMPTIED, SINCE
EMPTIED CNTNRS MAY RETAIN PROD RESIDUALS (VAP, LIQ, &/OR SOLIDS)
ALL PREC GIVEN IN DATA SHEET MUST BE OBSERVED.
Other Precautions:STORE @ ROOM TEMP AWAY FROM HEAT SOURCES, & HAVE LIDS
TIGHTLY CLSD. OVEREXP HAS APPARENTLY BEEN FOUND TO CAUSE FOLLOWING
EFTS IN LAB ANIMALS:LIVER ABNORMAL, KIDNEY DMG, LUNG DMG. ALSO
OVEREXP TO MATL HAS BEEN SUGGESTED AS A CAUSE OF (ING 5)
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED
NIOSH/MSHA JOINTLY APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE
OF ENVIR CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD
RESPS UNDER SPECIFIED CNDTNS. (SEE YOUR SFTY EQUIP SUPPLIER) (ING
6)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL OR LOCAL EXHAUST)
VENT TO MAINTAIN EXPOSURE BELOW THE TLV'S.
Protective Gloves:POLYVINYL ALCOHOL COATED/POLYETHYLENE.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES (ING 7)
Other Protective Equipment:PROT HANDCREAM, IMPERVIOUS CLTHG & CHEM
RESIST BOOTS. ANSI APPRVD EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH HANDS BEFORE EATING/USING THE REST ROOM,
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLO HAZ:OVEREXP TO DECOMP PROD MAY CAUSE HLTH HAZ. SYMP MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. EFTS OF OVEREXP:PERSISTANT COUGH,
BRAIN DMG & MAY EVEN CAUSE DEATH. WARNING:DETECTABLE AMTS OF A C
HEM KNOWN TO ST OF CA TO CAUSE CANCER AND/OR BIRTH DEFECTS/OTHER
REPROD HARM MAY BE PRESENT IN THIS PRODUCT.
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.9 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NON SOLUBLE
Appearance and Odor:VARIOUS COLORS WITH SOLVENT ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION MAY PRODUCE
CARBON DIOXIDE AND/OR CARBON MONOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:RECYCLE LIQUIDS IF POSSIBLE, INCINERATE SOLIDS
IN ACCORDANCE WITH APPLICABLE REGULATIONS. AS A LAST RESORT
NEUTRALIZE AND LANDFILL I/A/W LOCAL, STATE AND FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|