=====================  Product Identification  =====================

MSDS NAME:COOLANOL 45R;DIELECTRIC HEAT TRANSFER FLUID
NIIN:00-257-1298
MSDS Number: BDPHK
=== Responsible Party ===
Company:MONSANTO CO
Address:800 N LINDBERGH BLVD
City:ST LOUIS
State:MO
ZIP:63141
Country:US
Info Phone Num:314-694-1000
Emergency Phone Num:314-694-1000 (COLLECT)
CAGE:76541
=== Contractor Identification ===
Company:MONSANTO COMPANY
Address:800 N LINDBERGH BLVD
Box:City:SAINT LOUIS
State:MO
ZIP:63167
Country:US
Phone:314-694-6661 OR 800-332-3111
CAGE:76541

=============  Composition/Information on Ingredients  =============

Name:ORGANOSILICATE ESTER (PRODUCT OF REACTING SILICON TETRA
    CHLORIDE WITH ANHYDROUS ALCOHOL)

Name:2,6-DI-TERT-BUTYL-P-CRESOL
CAS:128-37-0
RTECS #:GO7875000
Fraction by Wt: 0.5%
OSHA PEL:10 MG/M3
ACGIH TLV:10 MG/M3; 9192

Name:MINERAL OIL (EXPOSURE REGULATED AS 'OIL MIST')
CAS:8012-95-1
RTECS #:PY8030000
Fraction by Wt: 2%
OSHA PEL:5 MG/M3
ACGIH TLV:5 MG/M3/10 STEL;9192

Name:2-ETHYL-1-BUTANOL (PRESENT AS A PRODUCT OF HYDROLYSIS. SEE
    CASE HISTORY 85098H)
CAS:97-95-0
RTECS #:EL3850000

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:ORAL RAT LD50=>10,000 MG/KG
Routes of Entry: Inhalation:NO	Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:PRODUCT IS PRACTICALLY NON-TOXIC.
    DERMAL CONTACT IS SLIGHTLY IRRITATING. 6 HR INHALATION STUDIES HAVE
    SHOWN NO EFFECTS DUE TO THE LOW VOLITILITY OF THE PRODUCT AND THUS
    LOW EXPOSURE LEVELS. SEE SUPP D ATA.
Effects of Overexposure:OTHER THAN SLIGHT IRRITATION, NONE WERE
    REPORTED.
Medical Cond Aggravated by Exposure:NONE REPORTED.

=======================  First Aid Measures  =======================

First Aid:MFR MADE NO COMMENT ON FIRST AID PROCEDURES. FOLLOWING FROM
    HMIS: EYES:FLUSH WITH WATER 15 MIN. SKIN:REMOVE CONTAMINATED
    CLOTHING. LAUNDER BEFORE RE-USE. WASH PRODUCT FROM SKIN WITH SOAP
    AND WATER FLU SH. INHALED:REMOVE TO FRESH AIR. INGESTED:GET
    IMMEDIATE MEDICAL ATTENTION. IF IRRITATION FROM ANY CONTACT IS
    SEVERE OR PERSISTS,GET MEDICAL ATTENTION.

=====================  Fire Fighting Measures  =====================

Flash Point Method:COC
Flash Point:370F/188C
Autoignition Temp:Autoignition Temp Text:505F
Extinguishing Media:WATER SPRAY,FOAM,DRY CHEMICAL,CARBON DIOXIDE,OR
    OTHER MEDIA FOR CLASS B FIRES.
Fire Fighting Procedures:WEAR FULL PROTECTIVE CLOTHING AND SELF-
    CONTAINED BREATHING APPARATUS. DECONTAMINATE EQUIPMENT AFTER USE.
Unusual Fire/Explosion Hazard:MAY EMIT HAZARDOUS FUMES IN FIRE
    CONDITIONS.

==================  Accidental Release Measures  ==================

Spill Release Procedures:CONTAIN AND RECOVER LIQUID IF POSSIBLE. ABSORB
    ON CLAY,SAWDUST,ETC. IF NOT.
Neutralizing Agent:NONE

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE TIGHTLY CLOSED IN AN AREA FREE
    FROM IGNITION SOURCES. PROTECT FROM MOISTURE. PRODUCT WILL
    HYDROLYZE. SEE SUPP DATA.
Other Precautions:DO NOT EXPOSE TO MOISTURE AND HIGH TEMP ENVIRONMENTS
    WHICH MAY DETERIORATE PROD.; WATER AT HIGH TEMP CAUSES HYDROLYSIS;
    AVOID BREATHG VAP; WASH THOROUGHLY AFTER HANDLING. AVOID FIRE/IGN
    CONDITION

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NOT NORMALLY NEEDED. USE NIOSH RESPIRATOR OR
    SUPPLIED AIR RESPIRATOR IF EXPOSED OVER TLV.
Ventilation:NORMAL ROOM VENTILATION IS USUALLY SUFFICIENT. USE
    ADDITIONAL LOCAL EXHAUST AS NEEDED TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves:RUBBER,PLASTIC.
Eye Protection:SAFETY GLASSES OR SPLASH GOGGLES.
Other Protective Equipment:IF USE INVOLVS SPLASHING,ETC. USE APRONS,
    BOOTS,ETC. TO PREVENT PROLONGED OR REPEATED CONTACT.
Work Hygienic Practices:USE GOOD CHEMICAL HYGIENE PRACTICE. AVOID ANY
    UNNECESSARY EXPOSURE.
Supplemental Safety and Health
SEE DGSC-SLM CASE HISTORY 85098H. DESCRIBES EXPOSURE CASE HISTORY
    WITHIN DOD. THIS EXPOSURE HISTORY DISCUSS THE IRRITATING EYES,
    BURNING THROAT, NAUSEA, HEADACHES, LIGHT HEADEDNESSSKIN IRRITATION
    EXPE RIENCED BY PERSONNEL ATTEMPTING TO CLEAN UP A LEAKING
    CONTAINER IN AN AIRCRAFT. USE CAUTION OF EXPOSURE OF FREE LIQUID.

==================  Physical/Chemical Properties  ==================

HCC:N1
Boiling Pt:B.P. Text:644F,340C
Vapor Pres:<1 MM
Vapor Density:19
Viscosity:17 CS
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR OILEY LIQUID, MILD,SWEET ODOR

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS,WATER.
Stability Condition to Avoid:MOISTURE,HIGH TEMPERATURES. SEE SUPP DATA.
Hazardous Decomposition Products:NORMAL PRODUCTS OF HYDROCARBON
    COMBUSTION PLUS SILICON DIOXIDE AND PARTIAL SILICATE ESTERS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE I/A/W FEDERAL,STATE,LOCAL REGULATIONS.
    MFR SUGGESTS INCINERATION. DO NOT FLUSH TO SEWER OR PUBLIC WATER
    WAY.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***