=====================  Product Identification  =====================

MSDS NAME:POLYESTER POWDER COATING, TGIC SERIES
NIIN:00N077982
MSDS Number: CDZSG
=== Responsible Party ===
Company:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTRERO AVE
City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Info Phone Num:818-444-9274
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:RICHARD A STEWART
CAGE:65860
=== Contractor Identification ===
Company:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTERO AVE
Box:City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Phone:818-444-9274 OR 213-283-9335
CAGE:65860

=============  Composition/Information on Ingredients  =============

Name:CARBON BLACK VP: 0.0 @ 20C
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: 0-5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3

Name:1,3,5-TRIGLYCIDYL ISOCYANURATE VP: 0.0 @ 20C (MFR INVALID
    CAS # 2451-62-2)
CAS:2451-62-9
RTECS #:XZ1994900
Fraction by Wt: 0-10%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Name:2H-AZEPIN-2-ONE, HEXAHYDRO-; (E-CAPROLACTAN) VP: 0.0 @ 20C
    (MFR INVALID CAS #14505-60-2)
CAS:105-60-2
RTECS #:CM3675000
Fraction by Wt: 0-5%
OSHA PEL:N/K 
ACGIH TLV:N/K 
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

Name:BARIUM SULFATE VP: 0.0 @ 20C
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 0-25%
OSHA PEL:15 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST

Name:RESP PROT: CONTROLS SHOULD BE IMPLEMENTED TO REDUCE
    EXPOSURE.
RTECS #:9999999ZZ

Name:OTHER PROT EQUIP: PREVENT REPEATED/PROLONGED SKIN CONT W/GB
    PROT HAND CREAM. WEAR IMPERVIOUS CLTHG & CHEM RESIST BOOTS.
RTECS #:9999999ZZ

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:YES	 OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAN CAUSE IRRITATION AND
    REDNESS, TEARING OR BLURRED VISION. SKIN: IRRITATION, RASH AND
    DERMATITIS POSSIBLE FROM PROLONGED EXPOSURE. INHALATION: COUGHING,
    SNEEZING, NASAL IRRITATION, HEAD ACHE, DIZZINESS, NAUSEA, WEAKNESS.
Explanation of Carcinogenicity:CARBON BLACK: IARC MONO ON EVAL OF
    CARCIN RISK OF CHEMICALS TO MAN, VOL 65, PG 24-27, 1995: GROUP 2B.
    ANIMAL: LUNG.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY CONDITIONS,
    PREEXISTING SKIN DISORDERS.

=======================  First Aid Measures  =======================

Eyes: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
    ATTENTION IMMEDIATELY SKIN: WASH EXPOSED AREA WITH SOAP AND WATER.
    REMOVE CONTAMINATED CLOTHING. INHALATION: REMOVE TO FRESH AIR. IF
    BREATHI NG IS DIFFICULT, ADMINISTER OXYGEN. IF BREATHING HAS
    STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
    INGESTION: INDUCE VOMITING. KEEP PERSON WARM AND QUIET. GET MEDICAL
    ATTENTION.

=====================  Fire Fighting Measures  =====================

Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA & FULL PROTECTIVE
    EQUIPMENT .
Unusual Fire/Explosion Hazard:WHEN EXPOSED TO EXTREME HEAT, DECOMP
    PRODS MAY YIELD OXIDES OF CARBON & NITROGEN/TOX FUMES. NOTE: THIS
    PROD IS A DRY POWDER & UNDER NORM OPERATING (SUP DAT)

==================  Accidental Release Measures  ==================

Spill Release Procedures:REFER TO OTHER SECTIONS OF THIS MSDS.
    ELIMINATE ALL IGNITION SOURCES. SWEEP UP SPILLS AND PLACE IN DRUM
    OR OTHER SEALABLE CONTAINER. AVOID GENERATING DUST FROM CLEAN UP
    MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN COOL, DRY PLACE & PROTECT
    FROM BREAKAGE. AVOID STORING AT TEMPS > 80F. AVOID EXCESS
    MOISTURE/EXTREME HEAT.
Other Precautions:DO NOT ALLOW POWDER DUST TO ACCUM NEAR
    MACHINERY/SOURCES OF IGNIT. POWDER COATINGS SHOULD BE APPLIED ONLY
    W/PROPER APPLICATION EQUIP W/IN PROPERLY VENTD CTL ENCLOSURE.
    POWDER COATING EQUIP SHOULD BE G ROUNDED AT ALL TIMES TO PVNT (SUP
    DAT)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, NIOSH
    APPRVD AIR SUPP RESP IS ADVISED IN ABSENCE OF ENVIRON CTL. OSHA
    REGS ALSO PERMIT OTHER NIOSH RESP UNDER SPECIFIED CNDTNS (SEE YOUR
    SFTY EQUIP SUPPLIER).  ENGINEERING/ADMINISTRATIVE (ING 5)
Ventilation:PROVIDE SUFFICIENT MECH (GENERAL AND/OR LOCAL EXHAUST) VENT
    TO CONTROL DUST ACCUMULATION & MAINTAIN EXPOS BELOW TLV.
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EMERGENCY EYEWASH & DELUGE
    SHOWER . HAND CREAM SUGGESTED FOR MANUAL SPRAY EQUIP. (ING 6)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOM.
    SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLO HAZ: CNDTNS PRESENTS MIN RISK OF FIRE/EXPLO. HOWEVER, PROPER STOR
    & CAUTION IN HNDLG & USE PRACTICES SHOULD BE USED AT ALL TIMES.
    OTHER PREC: STATIC ELEC BUILD-UP (OSHA 29 CFR 1910.107). NO OPEN 
    FLAMES/SOURCES OF IGNIT/SPK PRODUCING EQUIP SHALL BE LOCATED W/IN
    20 FEET OR POWDER USE, UNLESS SEPARATED BY PARTITION.

==================  Physical/Chemical Properties  ==================

Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.2-1.8
Appearance and Odor:POWDER OF VARIOUS COLORS
Percent Volatiles by Volume:<2

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

====================  Disposal Considerations  ====================

Waste Disposal Methods:REUSE OR RECYCLE WHENEVER POSSIBLE. DESTROY
    WASTE SOLIDS BY INCINERATION, OR DISPOSE OF IN AN APPROVED LANDFILL
    IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***