===================== Product Identification =====================
MSDS NAME:SEARCH SPRAY CLEAN, S0239CT
NIIN:00N092534
Status Code:A
MSDS Number: CJSXP
=== Responsible Party ===
Company:CHEM-PAK INC
Box:1685
City:WINCHESTER
State:VA
ZIP:22604-8185
Country:US
Info Phone Num:800-336-9828
Emergency Phone Num:800-255-3924
Resp. Party Other MSDS Num.:SUPPLIER PART # 233T
CAGE:4M364
=== Contractor Identification ===
Company:CHEM-PAK INC
Box:1685
City:WINCHESTER
State:VA
ZIP:22604-8185
Country:US
Phone:800-336-9828
CAGE:4M364
Company:SIRCHIE FINGER PRINT LABORATORIES INC
Address:100 HUNTER PLACE
Box:City:YOUNGSVILLE
State:NC
ZIP:27596
Country:US
Phone:919-554-2244
CAGE:94514
============= Composition/Information on Ingredients =============
Name:HYDROTREATED HEAVY NAPHTHA (PETROLEUM); (HYDROTREATED HEAVY
PETROLEUM NAPHTHA)
CAS:64742-48-9
Minumum % Wt:40.
Maxumum % Wt:45.
Other REC Limits:N/K
OSHA PEL:5 MG/M3
OSHA STEL:N/K
ACGIH TLV:5 MG/M3
ACGIH STEL:N/K
Name:LIQUEFIED PETROLEUM GAS
CAS:68476-85-7
RTECS #:SE7545000
Minumum % Wt:30.
Maxumum % Wt:35.
Other REC Limits:N/K
OSHA PEL:1800 MG/M3;1000 PPM
OSHA STEL:N/K
ACGIH TLV:1800 MG/M3;1000 PPM
ACGIH STEL:N/K
Name:LIGHT ALIPHATIC SOLVENT NAPHTHA (PETROLEUM); (MINERAL
SPIRITS)
CAS:64742-89-8
Minumum % Wt:25.
Maxumum % Wt:30.
Other REC Limits:N/K
OSHA PEL:300 PPM
OSHA STEL:N/K
ACGIH TLV:300 PPM
ACGIH STEL:N/K
===================== Hazards Identification =====================
LD50 LC50 Mixture:SEE TOXICOLOGICAL INFORMATION.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: FREQUENT/PROLONGED CONTACT CAN
RESULT IN DEFATTING & DRYING OF SKIN WHICH MAY RESULT IN SKIN
IRRITATION & DERMATITIS (RASH). EYES: LIQUID/VAPORS MAY CAUSE
REDNESS, BURNING, TEARING, SWELLING &/O R PAIN. INGEST: DUE TO
BEING AN AEROSOL, PRODUCT DOES NOT LEND ITSELF TO INGEST. SHOULD
INGEST OCCUR, IT MAY CAUSE IRRITATION TO MENBRANES OF MOUTH, THROAT
& GASTROINTESTINAL TRACT, RESULTING IN VOMIT ING &/OR CRAMPS.
INHAL: PROLONGED/REPEATED OVEREXPOSURE IS ANESTHETIC. MAY CAUSE
IRRITATION OF RESPIRATORY TRACT/ACUTE NERVOUS SYSTEM DEPRESSION
CHARACTERIZED BY HEADACHE, DIZZINESS, STAGGERING GAIT/C ONFUSION.
Explanation of Carcinogenicity:NONE OF THE INGREDIENTS IN THIS PRODUCT
ARE LISTED WITH OSHA, IARC OR NTP AS BEING CARCINOGENIC.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN CONTACT MAY AGGRAVATE AN
EXISTING DERMATITIS. OTHER CONDITIONS UNKNOWN.
======================= First Aid Measures =======================
First Aid:INGEST: UNLIKELY DUE TO BEING IN AEROSOL FORM. SHOULD INGEST
OCCUR, DO NOT INDUCE VOMIT! DRINK A GLASS OF WATER/MILK TO DILUTE.
CALL MD/POIS CTL CTR IMMED. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCON PER SON. EYES: IMMED FLUSH W/PLENTY OF CLEAR WATER FOR AT
LEAST 15 MINS. MAKE SURE TO FLUSH UNDER EYELIDS. CONSULT MD FOR
DEFINITIVE TREATMENT. SKIN: REMOVE W/SOAP & WATER. CONTINUE
FLUSHING W/WATER FOR S EVERAL MINS. USE SKIN CREAM TO COUNTER
RESULTING DRYNESS. CONSULT MD IF IRRIT/IF LGE SKIN AREA IS
AFFECTED. INHAL: REMOVE TO FRESH AIR. IF NOT BRTHG, GIVE ARTF RESP.
IF BRTHG IS DFCLT, GIVE OXYGEN. SE EK MED ATTN IF SYMPS PERSIST/IF
UNCON.
===================== Fire Fighting Measures =====================
Flash Point:<-17.8C, 0.F
PROPELLANT
Extinguishing Media:FOR WAREHOUSE AND STORAGE CONDITIONS, USE NFPA
CLASS B EXTINGUISHERS (CARBON DIOXIDE, DRY CHEMICAL OR UNIVERSAL
AQUEOUS FILM-FORMING FOAM).
Fire Fighting Procedures:WEAR NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT . USE WATER SPRAY TO COOL FIRE-EXPOSED CONTAINERS FOR
CONTAINERS CAN RUPTURE VIOLENTLY FROM HEAT-DEVELOPED PRESSURE.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. IN ADDITION,
WHEN LIQUID OR VAPOR COMES INTO CONTACT WITH FLAMES OR RED HOT
METAL, PRODUCTS OF COMBUSTION WILL BE CREATED.
================== Accidental Release Measures ==================
Spill Release Procedures:PROD IS AN AEROSOL, THEREFORE SPILLS & LEAKS
ARE UNLIKELY. IN CASE OF RUPTURE, RELEASED CONTENT SHOULD BE
CONTAINED AS ANY OTHER SOLV SPILL. SPILLS FROM AEROSOL CANS ARE
UNLIKELY & ARE GENERALLY OF SM L VOL. LGE SPILLS ARE THEREFORE NOT
NORMALLY CONSIDERED A PROBLEM. IN CASE OF ACTUAL RUPTURE, AVOID
BRTHG VAPS & VENT AREA WELL. REMOVE ALL SOURCES OF IGNIT & USE
NON-SPKG EQUIP. (SUP DAT)
====================== Handling and Storage ======================
Handling and Storage Precautions:AVOID PROLONGED OR REPEATED SKIN
CONTACT. AVOID BREATHING VAPORS. STORE IN AREA BELOW 120F. DO NOT
INCINERATE (BURN) CONTAINERS. ASSURE CAN IS IN A SECURE PLACE TO
PREVENT KNOCKING OVER AND ACCIDENTAL RUPTURE. ALWAYS REPLACE
OVERCAP WHEN NOT IN USE.
Other Precautions:FOR STORAGE OF PALLET QUANTITIES, COMPLIANCE WITH
ANSI/NFPA 30C IS RECOMMENDED.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ATMOSPHERIC LEVELS SHOULD BE MAINTAINED BELOW
THE EXPOSURE GUIDELINE. WHEN RESPIRATORY PROTECTION IS REQUIRED, AN
APPROPRIATE NIOSH APPROVED RESPIRATOR FOR ORGANIC VAPOR SHOULD BE
WORN. IF RESPIRATORS ARE NEEDED, ASSURE COMPLIANCE WITH OSHA
STANDARD 29 CFR 1910.134.
Ventilation:GEN VENT (TYPICALLY 10 AIR CHANGES PER HR) SHOULD BE USED.
VENT RATES SHOULD BE MATCHED TO CNDTNS. LOC EXHST VENT/ENCLSD HNDLG
SYS MAY BE NEEDED (OTHER INFO)
Protective Gloves:SOL-VEX GLOVES FOR PROLONGED OR REPEATED CONTACT.
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER .
FOR BRIEF CONT, NO PREC OTHER THAN CLEAN BODY-COVERING CLTHG SHOULD
BE NEEDED. WHEN PRLNG/RPTD CONT COULD OCCUR, USE PROT IMPERVIOUS
CLTHG.
Supplemental Safety and Health
SPILL PROC: SOAK UP MATL W/INERT ABSORB & PLACE IN SFTY CONTRS FOR
PROPER DISP. AEROSOL PRODS REPRESENT LIMITED HAZ & WILL NOT
SPILL/LEAK UNLESS RUPTURED. IN CASE OF RUPTURE CONTENTS ARE GEN
EVACUATED FROM CAN RAPIDLY. AREA SHOULD BE VENTILATED IMMED &
CONTINUOUS VENT PROVIDED UNTIL ALL FUMES & VAPS HAVE (OTHER INFO)
================== Physical/Chemical Properties ==================
Boiling Pt:<-17.8C, 0.F
B.P. Text:PROPELLANT
Vapor Density:>1 (AIR=1)
Spec Gravity:<1 (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR COLORLESS LIQUID, WITH A SWEET PETROLEUM
ODOR.
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING MATERIALS.
Stability Condition to Avoid:HEAT, SPARKS, FLAME, RED HOT METAL.
Hazardous Decomposition Products:OXIDES OF CARBON.
=================== Toxicological Information ===================
Toxicological Information:ACUTE ORAL LD50: MINERAL SPIRITS >25 ML/KG
(RAT); PETROLEM NAPHTHA >5 G/KG (RAT). ACUTE DERMAL LD50: MINERAL
SPIRITS >4 ML/KG (RABBIT); PETROLEUM NAPHTHA >3 G/KG (RABBIT).
ACUTE INHALATION LC50: LIQUE FIED PETROLEUM GAS 57.42% V/V (MICE);
MINERAL SPIRITS >700 PPM/4H (RAT).
===================== Ecological Information =====================
Ecological:THIS PRODUCT HAS NOT BEEN TESTED FOR ENVIRONMENTAL EFFECTS.
==================== Disposal Considerations ====================
Waste Disposal Methods:AN AEROSOL CONTR THAT DOES NOT CONTAIN
SIGNIFICANT AMOUNT OF LIQUID WOULD MEET DEFINITION OF SCRAP METAL
(40 CFR 261.1(C)(6)), & WOULD BE EXEMPT FROM RCRA REG UNDER 40 CFR
261.6(A)(3)(IV) IF IT IS TO BE RECYCLED. IF CONTRS ARE NOT
RECYCLED THEY MUST BE MANAGED UNDER ALL APPLIC RCRA & STATE REGS.
DIS POSE OF I/A/W LOC, STATE, & FEDERAL REGS .
=================== MSDS Transport Information ===================
Transport Information:DOT HM-181 INFORMATION: PROPER SHIPPING NAME:
CONSUMER COMMODITY; HAZARD CLASS OR DIVISION: ORM-D; IDENTIFICATION
NUMBER: NONE; LABEL(S) REQUIRED: NONE. INTERNATIONAL TRANSPORTATION
REGULATIONS: PROPE R SHIPPING NAME: CONSUMER COMMODITY; CLASS OR
DIVISION: 9; HAZARD LABEL(S): MISCELLANEOUS; UN OR ID NUMBER:
ID8000. NATIONAL MOTOR FREIGHT CLASSIFICATION: ITEM: 48580 SUB 2;
ARTICLE: COMPOUNDS CLEANIN G; CLASS: 55.
===================== Regulatory Information =====================
SARA Title III Information:SARA TITLE III, SECTION 313: NONE OF THE
INGREDIENTS IN THIS PRODUCT ARE SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT OF 1986 A ND 40 CFR PART 372.
Federal Regulatory Information:TOXIS SUBSTANCES CONTROL ACT: ALL OF THE
INGREDIENTS IN THIS PRODUCT ARE ON THE TSCA INVENTORY. CLEAN AIR
ACT (CAA): NONE OF THE INGREDIENTS IN THIS PRODUCT APPEAR ON THE
LIST OF HAZARDOUS AIR POLLUTA NTS (HAP-42 USC 7412, TITLE 1, PART
A, P112). CLEAN WATER ACT (CWA): NONE OF THE INGREDIENTS IN THIS
PRODUCT APPEAR ON THE CWA LIST OF HAZARDOUS SUBSTANCES (40 CFR
116.4). CANADIAN WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM
(WHMIS): THE FOLLOWING INGREDIENTS ARE LISTED: LPG, MINERAL
SPIRITS.
State Regulatory Information:CALIFORNIA PROPOSITION 65: NONE OF THE
INGREDIENTS IN THIS PRODUCT APPEAR ON THE PROPOSITION 65 LIST(S).
======================= Other Information =======================
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|