===================== Product Identification =====================
MSDS NAME:OXYGEN, COMPRESSED GAS (UN1072)
NIIN:00-169-0805
Status Code:A
MSDS Number: CLPRJ
=== Responsible Party ===
Company:SUNOX INC
Address:4236 STATESVILLE RD
Box:33871
City:CHARLOTTE
State:NC
ZIP:28233
Country:US
Info Phone Num:704-596-6262
Emergency Phone Num:800-868-7780
Chemtrec Ind/Phone:(800)424-9300
CAGE:6Z872
=== Contractor Identification ===
Company:SUNOX INC
Address:4236 STATESVILLE RD
Box:33871
City:CHARLOTTE
State:NC
ZIP:28233
Country:US
Phone:704-596-6262
CAGE:6Z872
============= Composition/Information on Ingredients =============
Name:OXYGEN
CAS:7782-44-7
RTECS #:RS2060000
= Wt:100.
OSHA PEL:NONE ESTABLISHED
ACGIH TLV:NONE ESTABLISHED
===================== Hazards Identification =====================
Health Hazards Acute and Chronic:PURE OXYGEN, ESPECIALLY IF NOT
PROPERLY HUMIDIFIED, MAY CAUSE MUCOUS MEMBRANE IRRITATION AND
PULMONARY EDEMA AFTER 24 HOURS. AIR NORMALLY CONTAINS 20-21%
OXYGEN. AS EXPOSURE TO HIGHER CONCENTRATIONS A ND/OR GREATER THAN
ATMOSPHERIC PRESSURE CONTINUES SYMPTOMS OF TOXICITY MAY DEVELOP AND
INCREASE IN SEVERITY. IT MAY EFFECT RESPIRATORY, NERVOUS & CARDIAC
SYSTEM. CHRONIC: DECREASE IN LUNG FUNCTION, RE TINAL ATROPHY.
Effects of Overexposure:MUCOUS MEMBRANE IRRITATION AND PULMONARY EDEMA
AFTER 24 HOURS. RESPIRATORY SYSTEM EFFECTS MAY INCLUDE A
PROGRESSIVE DECREASE IN VITAL CAPACITY, TIGHTNESS IN THE CHEST AND
DISCOMFORT, COUGHING, CONGEST ION, TRACHEOBRONCHITIS, PNEUMONIA,
EDEMA, ATELECTASIS AND INCREASED DEPTH OF RESPIRATION, RAPID
PANTING OR ASTHMA-LIKE ATTACKS, APNEA IN INSPIRATORY POSITION,
FIBROBLASTIC PROLIFERATION. CARDIOVASCULA R SYSTEM EFFECTS:
BRADYCARDIA, HYPERTHERMIA, PERIFERAL VASOCONSTRICTION. OTHERS:
NAUSEA, DIZZINESS, MALAISE, SIEZURES, IMPAIRED VISION. IN PREGNANT
WOMAN, 100% OXYGEN/20 MINUTES CAN CAUSE VARIABLE FET AL CARDIAC
RATE.
======================= First Aid Measures =======================
First Aid:INHALATION: REMOVE FROM EXPOSURE AREA TO FRESH AIR
IMMEDIATELY. IF BREATHING HAS STOPPED, PERFORM ARTIFICIAL
RESPIRATION. KEEP PERSON WARM & AT REST. TREAT SYMPTOMATICALLY &
SUPPORTIVELY. GET MEDICAL ATTENTION IMMEDIATELY. SKIN: IT IS
UNLIKELY THAT EMERGENCY TREATMENT WILL BE REQUIRED. IF ADVERSE
EFFECTS OCCUR, GET MEDICAL ATTENTION. IN CASE OF FROSTBITE, WARM
AFFECTED SKIN IN WARM WATER AT A TEMP ERATURE OF 107F. IF WARM
WATER IS NOT AVAILABLE OR IMPRACTICAL TO USE, GENTLY WRAP AFFECTED
PART IN BLANKETS, ENCOURAGE VICTIM TO EXERCISE AFFECTED PART WHILE
IT IS BEING WARMED. ALLOW CIRCULATION TO RETURN NATURALLY. GET
MEDICAL
===================== Fire Fighting Measures =====================
Extinguishing Media:DRY CHEMICAL, CARBON DIOXIDE OR HALON. FOR LARGER
FIRES, USE WATER SPRAY, FOG, OR STANDARD FOAM. (1990 EMERGENCY
RESPONSE GUIDEBOOK, DOT P 5800.4)
Fire Fighting Procedures:MOVE CONTAINER FROM FIRE AREA IF POSSIBLE.
STAY AWAY FROM STORAGE TANK ENDS. COOL FIRE-EXPOSED CONTANIERS WITH
WATER FROM SIDE UNTIL WELL AFTER FIRE IS OUT. FOR MASSIVE FIRE IN
STORAGE AREA, USE UNMAN NED HOSE HOLDER OR MONITOR NOZZLES, ELSE
WITHDRAW FROM AREA & LET FIRE BURN (1990 EMERGENCY RESPONSE
GUIDEBOOK
Unusual Fire/Explosion Hazard:NEGLIGIBLE FIRE HAZARD WHEN EXPOSED TO
HEAT OR FLAME. OXIDIZERS DECOMPOSE, ESPECIALLY WHEN HEATED TO YIELD
OXYGEN OR OTHER GASES WHICH WILL INCREASE THE BURNING RATE OF
COMBUSTIBLE MATTER. CONTACT WIT H EASILY OXIDIZABLE, ORGANIC, OR
OTHER COMBUSTIBLE MATERIALS MAY RESULT IN IGNITION, VIOLENT
COMBUSTION OR EXPLOSION.
================== Accidental Release Measures ==================
Spill Release Procedures:KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.)
AWAY FROM HAZARD AREA. STOP LEAK IF YOU CAN DO IT WITHOUT RISK.
KEEP UNNECESSARY PEOPLE AWAY; ISOLATE AREA AND DENY ENTRY.
VENTILATE CLOSED SPACES BEFORE ENT ERING.
====================== Handling and Storage ======================
Handling and Storage Precautions:OBSERVE ALL FEDERAL, STATE AND LOCAL
REGULATIONS WHEN STORING OR DISPOSING OF THIS SUBSTANCE. FOR
ASSISTANCE, CONTACT THE DISTRICT DIRECTOR OF THE ENVIRONMENTAL
PROTECTION AGENCY. STORE IN ACCORDANCE WITH 29 CFR 1910.104.
Other Precautions:AVOID CONTACT WITH COMBUSTIBLE MATERIALS (WOOD,
PAPER, FUEL, OILS, ETC.); CONTACT MAY RESULT IN IGNITION OR
EXPLOSION. DO NOT PERMIT PHYSICAL DAMAGE OR OVERHEATING OF
CONTAINERS. CONTENTS UNDER PRESSU RE; CONTAINER MAY VIOLENTLY
RUPTURE AND TRAVEL A CONSIDERABLE DISTANCE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:ANY SUPPLIED-AIR RESPIRATOR OPERATED IN
PRESSURE-DEMAND OR OTHER POSITIVE PRESSURE MODE. ANY SCBA. FOR
FIREFIGHTING & OTHER IMMEDIATELY DANGEROUS TO LIFE OR HEALTH
CONDITIONS: SCBA W/ FULL FACEPIECE O PERATED IN PRESSURE-DEMAND OR
OTHER POSITIVE PRESSURE MODE. SUPPLIED-AIR RESPIRATOR WITH FULL
FACEPIECE & OPERATED IN PRESSURE-DEMAND OR OTHER POSITIVE
Ventilation:PROVIDE GENERAL DILUTION VENTILATION.
Protective Gloves:WEAR FULL PROTECTIVE, COLD INSULATING GLOVES.
Eye Protection:FOR THE GAS FORM EYE PROTECTION IS NOT REQUIRED BUT
RECOMMENDED.
Other Protective Equipment:WHERE THERE IS ANY POSSIBILITY OF CONTACT
WITH THE LIQUID FORM, EMPLOYEE MUST WEAR SPLASH-PROOF SAFETY
GOGGLES AND A FACESHIELD TO PREVENT CONTACT WITH THIS SUBSTANCE.
CONTACT LENSES SHOULD NOT BE WORN.
Supplemental Safety and Health
WHERE THERE IS ANY POSSIBILITY THAT AN EMPLOYEE'S EYES AND/OR SKIN MAY
BE EXPOSED TO THE LIQUID FORM OF THIS SUBSTANCE, THE EMPLOYER
SHOULD PROVIDE AN EYE WASH FOUNTAIN AND QUICK DRENCH SHOWER WITHIN
THE IMMEDIATE WORK AREA FOR EMERGENCY USE.
================== Physical/Chemical Properties ==================
HCC:G4
Boiling Pt:=-182.6C, -297.F
Melt/Freeze Pt:=-218.3C, -361.F
Vapor Pres:760 MMHG @ -183C
Vapor Density:1.1
Spec Gravity:1.309 G/L @25C
Viscosity:0.02075 CPS @25C
Solubility in Water:3.2% @25C
Appearance and Odor:COLORLESS, TASTELESS, GAS; ODORLESS
Percent Volatiles by Volume:GAS
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
ACETALDEHYD, ACETYLENE, ETHERS, POLY(ACRYLONITRILE-BUTADIENE),ALKALI &
ALKALINE EARTH METALS, AMMONIA, COMBUSTIBLES, ORGANICS,
HYRDROCARBONS, OILS, GASOLINE, METAL HYDRIDES, SILANES, CARBON,
HYDROGEN SULFIDE, POTASSIUM PERO
Hazardous Decomposition Products:NONE HAZARDOUS.
Conditions to Avoid Polymerization:HAS NOT BEEN REPORTED TO OCCUR UNDER
NORMAL TEMPERATURE AND PRESSURES.
=================== Toxicological Information ===================
Toxicological Information:TOXICITY DATA:100 PPH/14 HOURS INHALATION-
HUMAN TCL0; REPRODUCTION EFFECTS DATA (RTECS), MUTAGENIC DATA
(RTECS) CARCINOGENIC STATUS: NONE. TARGET EFFECTS: POISONING MAY
EFFECT THE PULMONAY, CARDIOVAS CULAR, NERVOUS SYSTEM AND THE EYE.
ADDITIONAL DATA: TOXIC ACTION IS GREATLY ENHANCED BY EXERCISE OR BY
PRESENCE OF MODERATE AMOUNTS OF CARBON DIOXIDE.
==================== Disposal Considerations ====================
Waste Disposal Methods:DO NOT ATTEMPT TO DISPOSE OF RESIDUAL OR UNUSED
QUANTITIES. RETURN IN THE SHIPPING CONTAINER TAGGED TO INDICATE A
DEFECT AND PROPERLY LABELED, WITH ANY VALVE OUTLET PLUGS OR CAPS
SECURED AND VALVE PRO TECTION CAP IN PLACE TO SUNOX, INC. FOR
PROPER DISPOSAL. FOR EMERGENCY DISPOSAL CONTACT SUNOX, INC.
=================== MSDS Transport Information ===================
Transport Information:PSN: OXYGEN, COMPRESSED, UN1072. LABEL:
NON-FLAMMABLE GAS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|