Page 1 of 2
OFI TESTING EQUIPMENT, INC.
MATERIAL SAFETY DATA SHEET
SECTION I - PRODUCT AND COMPANY IDENTIFICATION
SILICONE
Chemical Name:
CALIBRATION FLUID, 20 cP, 50 cP, 100 cP, 200 cP, 500 cP
Trade Name:
132-80,132-81,132-82,132-83,132-84
OFI Part No.
Chemical Family:
OFI Testing Equipment, Inc.
Manufacturer: th
1006 West 34 Street
Houston, TX 77018 U.S.A.
(713) 880-9885
In Case of Emergency Spills,
In the USA, call INFOTRAC at 1-800-535-5053 day or night
Leaks, Fire, Exposure or
Outside the USA, call collect, (352) 323-3500
Accident:
SECTION II - HAZARD IDENTIFICATION
Non-hazardous.
Emergency Overview:
No Irritation to Nose or Throat Expected. No Injury is Likely from Relatively Short Exposure.
Inhalation:
Amounts Transferred to the Mouth by Fingers, etc., During Normal Operation Should Not Cause
Ingestion:
Injury.
Single, Prolonged Exposure Causes No Known Adverse Effect.
Skin:
May Cause Temporary Discomfort.
Eye Contact:
SECTION III - COMPOSITION / INFORMATION ON INGREDIENTS
CAS #: CHEMICAL NAME
SILICONE 90.0 to 100.0%
63148-62-9
SECTION IV - FIRST AID MEASURES
Inhalation: No Problem.
Ingestion: No Problem.
Skin: Wipe Off and Flush with Water.
Immediately Flush Eyes with Plenty of Water for at Least 15 Minutes, Lifting Upper and Lower
Eyes:
Eyelids Occasionally. Get Medical Attention Immediately.
SECTION V - FIRE FIGHTING MEASURES
Flash Point (Open Cup): 600 0F (315 0C), Auto Ignition Temperature: Not Determined.
Fire:
Flammability Limits in Air: Lower - N.D., Upper - N.D.
Explosion: Not Considered to be a Explosion Hazard.
Fire Extinguishing Media: Water Fog, CO2, Dry Chemical, Foam and Other Means Suitable to Control Fire.
Special Information: Evacuate Affected area, Avoid Smoke and Fumes. In the Event of Fire, Wear full Protective
Clothing and NIOSH-Approved Self-Contained Breathing Apparatus with Full Facepiece
Operated in the Pressure Demand or Other Positive Pressure Mode.
SECTION VI - ACCIDENTAL RELEASE MEASURES
Disposal of Collected Product, Residues, and Cleanup Materials may be Governmentally
Regulated. Observe all Applicable Local, State, and Federal Waste Management Regulations.
Mop Up, or Wipe Up, or Soak Up with Absorbent and Contain for Salvage or Disposal. Clean any
Remaining Slippery Surfaces by Appropriate Techniques, Such as: Several Moppings or
Swabbings with Appropriate Solvents; Washing with Mild Caustic Detergents or Solutions; or
High Pressure Steam for Large Areas.
SECTION VII - HANDLING AND STORAGE
Store in a Cool, Dry, Ventilated Storage Area. Protect from Physical Damage. Isolate from
Incompatible Substances. Containers of this Material may be Hazardous when Empty Since they
Retain Product Residues (dust, solids); Observe all Warnings and Precautions Listed for the
Product.
SECTION VIII - EXPOSURE CONTROL / PERSONAL PROTECTION
Ventilation System: A System of Local and/or General Exhaust is Recommended to Keep Employee Exposures
below the Airborne Exposure Limits. Local Exhaust Ventilation is Generally Preferred because it
can Control the Emissions of the Contaminant at its Source, Preventing Dispersion of it into
the General Work Area.
Airborne Exposure Limits: No Information Found.
Personal Respirators: No Respiratory Protection Required.
OFI Testing Equipment, Inc. Houston, TX, USA Phone (713) 880-9885 Fax (713) 880-9886 http://www.ofite.com
Version 2.1
Date 05-30-07
Page 2 of 2
(NIOSH APPROVED)
Skin Protection: Gloves and Lab Coat, Apron or Coveralls.
Eye Protection: Use Chemical Safety Goggles. Maintain Eye Wash Fountain and Quick-Drench Facilities in Work
Area.
SECTION IX - PHYSICAL AND CHEMICAL PROPERTIES
Liquid, No Color / Very Little Odor
Appearance / Odor:
< 0.1%
Solubility:
0.98 @ 77 0F (25 0C)
Specific Gravity:
Not Applicable
pH:
No Information Found
% Volatiles by Vol.:
Not Applicable
Melting Point:
> 300 0F (> 149 0C)
Boiling Point:
Not Applicable
Vapor Density (Air=1):
Vapor Pressure
< 5 @ 77 0F (25 0C)
(mmHg):
SECTION X - STABILITY AND REACTIVITY
General Reactivity: Stable under Ordinary Conditions of Use and Storage.
Hazardous Decomposition: Silicon Dioxide, Carbon Dioxide, and Traces of Incompletely Burned Carbon Products.
Incompatibilities: Oxidizing Material can Cause a Reaction. If this Product Becomes Contaminated with Strong
Acids, Bases, or Some Metallic Compounds and Oxidizing Agents, the Flash Point and Viscosity
may Change and Should be Redetermined.
Hazardous
Polymerization: Will Not Occur.
SECTION XI - TOXICOLOGICAL INFORMATION
Chronic Exposure: No Information Found.
Comment: No Known Adverse Chronic Health Effects, But Unnecessary Exposure to any Chemical Should
be Avoided. This Product, as with any Chemical, May Enhance Allergic Conditions on Certain
People. We Do Not Know of any Medical Conditions that Might be Aggravated by Exposure to
this Product.
Carcinogenic References:
NTP Carcinogen - Known: No, IARC Category- None
Aggravated by
No Information Found.
Exposure:
SECTION XII - ECOLOGICAL INFORMATION
Comment: This Product is an Oil in the Contest of the U.S. Clean Water Act. Spills to U.S. Surface Waters,
or to the Watercourses or Sewers Leading to U.S. Surface Waters that Cause a Visible Sheen
Must Be Reported to the NATIONAL RESPONSE CENTER.
Environmental Fate: No Information Found.
SECTION XIII - DISPOSAL CONSIDERATIONS
Dow Corning Suggests that all Local, State and Federal Regulations Concerning Health Pollution
be Reviewed to Determine Approved Disposal Procedures. Contact Dow Corning if
There are any Disposal Questions.
SECTION XIV - TRANSPORT INFORMATION
Shipping Name:
Hazard Class: Not Regulated
Identification No.: Not Regulated
SECTION XV - REGULATORY INFORMATION
TSCA Status: The ingredients of this product are listed on the TSCA Inventory.
SECTION XVI - OTHER INFORMATION
Comment: Traces of Formaldehyde and Other Thermal Decomposition Products May Form at
Temperatures above 302 0F (150 0C) in the Presence of Air.
NFPA Rating: HEALTH-1, FLAMMABILITY-1, REACTIVITY-0
OFI Testing Equipment, Inc. Houston, TX, USA Phone (713) 880-9885 Fax (713) 880-9886 http://www.ofite.com
Version 2.1
Date 05-30-07
|