MATERIAL SAFETY DATA SHEET
(Essentially Similar to Form OSHA-174)
While the information and recommendations set forth herein are believed to be accurate as of
the date hereof, DEB SBS Inc. makes no warranty with respect thereto and disclaims all liability
from reliance thereon.
SECTION I
PRODUCT NAME EPI SAN鈩? INSTANT HAND SANITIZING GEL
MANUFACTURED DEB SBS INC. FORMULA 01034
FOR 1100 HIGHWAY 27 SOUTH COMPLETED BY DEB SBS, INC.
STANLEY, NC 28164 TITLE CHEMIST
PHONE NUMBER (704) 263-4240 DATE August 3, 2006
SECTION II - INGREDIENTS
THIS PRODUCT IS MANUFACTURED AND LABELED IN COMPLIANCE WITH THE FEDERAL FOOD, DRUG, AND COSMETIC ACT,
AND IS EXEMPT FROM THE LABELING REQUIREMENTS OF THE OSHA HAZARD COMMUNICATION STANDARD.
ALL PRODUCT INGREDIENTS ARE LISTED BELOW.
ACTIVE INGREDIENT CAS NUMBER WEIGHT, %
Ethyl Alcohol 64-17-5 62 minimum
INACTIVE INGREDIENTS
Water 7732-18-5
Isopropyl Alcohol 67-63-0
Acrylates/C10-30 Alkyl Acrylate
Copolymer
Propylene Glycol 57-55-6
Isopropyl Myristate 110-27-6
Aloe Vera Gel 8001-97-6
Amino Methyl Propanol 124-68-5
Tocopheryl Acetate 7695-91-2
Glycerin 56-81-5
Fragrance
FD&C Yellow No. 5 1934-21-0
FD&C Blue No. 1 3844-45-9
Data marked with * in sections III below refer to the properties of the Ethyl Alcohol
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING POINT SPECIFIC GRAVITY (H 20 = 1)
173掳* 0.9
VAPOR PRESSURE (mmHg) MELTING POINT NA
40掳*, 19掳C
VAPOR DENSITY (Air = 1) EVAPORATION RATE (Butyl Acetate = 1)2.8*
1.59*
SOLUBILITY IN WATER pH 7.5
Complete
APPEARANCE & ODOR Clear green viscous gel with alcohol odor
SECTION IV - FIRE AND EXPLOSION DATA
74掳F (ASTM D-1310 open cup)
FLASH POINT (Method Used)
LEL 3.3% UEL 19%
FLAMMABLE LIMITS
Water, alcohol foam, carbon dioxide or dry chemicals
EXTINGUISHING MEDIA
SPECIAL FIRE
NIOSH approved eye and full protection
FIGHTING PROCEDURES
UNUSUAL FIRE AND
NA
EXPLOSION HAZARDS
MATERIAL SAFETY DATA SHEET - EPI SAN鈩? , side 2
SECTION V - REACTIVITY DATA
Keep away from heat or
UNSTABLE CONDITIONS
ignition source
STABILITY STABLE X TO AVOID
INCOMPATIBILITY
(Materials to Avoid) Oxidizing materials
HAZARDOUS
DECOMPOSITION OR CO2
BY-PRODUCTS
HAZARDOUS MAY OCCUR CONDITIONS
None known
POLYMERIZATION WILL NOT OCCUR X TO AVOID
SECTION VI - HEALTH HAZARD DATA
Routes of Entry for Gel: Inhalation; Ingestion only by accidental or intentional misuse.
Health Hazards: Eye irritation, drowsiness.
Primary skin irritation index of 0.00 classifies the product as no irritation and not a primary
irritant to the skin since the empirical score was less than 5.00.
Carcinogenicity: NA
Signs and systems of exposure: Eye irritation, possible drowsiness.
Medical conditions generally aggravated by exposure: Persons with preexisting skin
disorders may be more susceptible to the effects of exposure.
Emergency and First Aid Procedures: Flush eyes with water, remove from exposure.
If swallowed, give a tablespoon of salt in a glass of warm water
and repeat until vomit fluid is clear. Get medical attention.
SECTION VII - PRECAUTIONS FOR SAFE HANDLING AND USE
STEPS TO BE TAKEN IN CASE Small Spill: Absorb on paper, vermiculite, floor absorbent or other absorbent material.
Large Spill: Eliminate all ignition sources. Liquid may be taken up on sand, clay, earth,
MATERIAL IS RELEASED OR floor absorbent or other absorbent material and shoveled into containers.
SPILLED
WASTE DISPOSAL Small Spill: Dispose of in accordance with local, state and federal regulations.
Large Spill: Deposit contaminated absorbent in a land fill.
METHOD
SPECIAL PRECAUTIONS FOR Keep out of the reach of children and other persons who may misuse the product.
HANDLING AND STORAGE
SECTION VIII - CONTROL MEASURES
SPECIAL RESPIRATORY None applicable.
PROTECTION
SPECIAL SKIN Alcohol gel is marketed as a hand antiseptic for use by healthcare personnel.
PROTECTION
SPECIAL EYE Avoid eye contact while hands are wet with the product.
PROTECTION
|