MATERIAL SAFETY DATA SHEET
1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PRODUCT CATEGORY: EL REY BASECOATS REVISION DATE: 10/11/05
PRODUCT NAME: FASTWALL
MANUFACTURER: PareXLahabra, Inc.
4125 E. LA PALMA AVE
SUITE 250 HMIS CODES:
ANAHEIM, CA 92807 HEALTH 1*
EMERGENCY PHONE NUMBER: CHEMTREC 800-424-930 FLAMMABILITY 0
INFORMATION PHONE NUMBER: 951-653-3549 REACTIVITY 0
NAME OF PREPARER: MICHELLE HEATON PROTECTION E
2 - COMPOSITION/INFORMATION ON INGREDIENTS
Components / Exposure Limits CASRN
---------------------------------------------------------------------------------------------------------------------
PORTLAND CEMENT 65997-15-1
OSHA PEL 5mg/m3 (RESPIRABLE DUST)
OSHA PEL 15mg/m3 (TOTAL)
ACGIH TLV 10 mg/m3
CRYSTALLINE SILICA 14808-60-7
OSHA TWA 10mg/m3
ACGIG TWA 0.05mg/m3
CALCIUM HYDROXIDE 1305-62-0
OSHA PEL 5 mg/m3
ACGIH TLV 5 mg/m3
FLY ASH 68131-74-8
OSHA PEL 5 mg/m3 (RESP)
OSHA PEL 15 mg/m3 (TOTAL)
3 - HAZARDS IDENTIFICATION - POTENTIAL HEALTH EFFECTS
EYES: WARNING - Exposure of the eyes to wet stucco mix can cause chemical burns and blindness. Exposure
to airborne dust can cause immediate or delayed irritation or inflammation. See Section 4 for first aid
instructions and Sections 11 and 15 for specific hazards. SKIN: WARNING - Exposure of the skin to wet
stucco mix can cause chemical burns. The symptoms of exposure may take several hours to manifest. See
Section 4 for first aid instructions and Sections 11 and 15 for specific hazards INGESTION: May be harmful
if ingested. INHALATION: Dust generated during handling this stucco concentrate can cause irritation to
the respiratory tract. CHRONIC (CANCER) INFORMATION: WARNING - See section 11, TOXICOLOGICAL INFORMATION
for details. Also see section 15. TERATOLOGY (BIRTH DEFECTS): Not known to cause birth defects.
REPRODUCTIVE INFORMATION: Not known to cause reproductive harm.
4 - FIRST AID MEASURES
EYES: Immediately flush eyes with plenty of water for at least 15 minutes. Get medical attention.
SKIN: Wash affected area thoroughly with soap and water. Remove contaminated cloths and launder before re-
MATERIAL SAFETY DATA SHEET
use. INGESTION: Do not induce vomiting. Get medical attention immediately. INHALATION: Remove to fresh
air. If not breathing, give artificial respiration. If having difficulty breathing, give oxygen. Get
immediate medical attention.
5 - FIRE FIGHTING MEASURES
This product does not support combustion and is non-flammable.
FLASH POINT:
Method: Not Applicable.
FLAMMABLE LIMITS:
Lower flammable limit: Not Applicable.
Uppoer flammable limit: Not Applicable.
AUTOIGNITION TEMPERATURE: Not Applicable.
HAZARDOUS COMBUSTION PRODUCTS:
EXTINGUISHING MEDIA: For the dried product, use carbon dioxide, dry chemical, or alcohol foam
extinguishing media.
FIREFIGHTING INSTRUCTIONS:
6 - ACCIDENTAL RELEASE MEASURES
For dry material, collect by sweeping and scooping. Transfer collected material to a container, being careful to
minimize creation of dust. For wet material, scoop material up and transfer to an open container. Allow material to
dry before disposal. Keep spilled products out of sewers, streams, and water systems. See section 13 and section 15
for specific regulatory information concerning this product.
7 - HANDLING AND STORAGE
HANDLING: STORAGE: Wear appropriate protective equipment when working with this product. Promptly remove dusty clothing, or
clothing wet with stucco mix, and launder before re-using. Wash thoroughly after exposure to stucco dust, or wet
stucco mixtures. Keep out of reach of children.
Keep stucco concentrate dry until use. Atmospheric temperatures and pressures do not affect the shelf life of this
product. However, moisture contamination will render the product useless.
8 - EXPOSURE CONTROLS/PERSONAL PROTECTION
VENTILATION: Use local exhaust. General exhaust acceptable if the exposure to materials in section 2 is
maintained below applicable exposure limits. Refer to OSHA Standards 1910.94, 1910.107, and 1910.108.
RESPIRATORY PROTECTION: If personal exposure cannot be controlled below applicable limits by ventilation,
wear a properly fitted organic vapor/particulate respirator approved by NIOSH for protection against
materials described in Section 2. SKIN PROTECTION: Prevent prolonged or repeated contact by using rubber
gloves and appropriate protective clothing. EYE PROTECTION: Wear safety glasses to reduce the potential
MATERIAL SAFETY DATA SHEET
for eye contact
9 - PHYSICAL AND CHEMICAL PROPERTIES
BOILING POINT: N/A FREEZING/MELTING POINT: N/A
EVAPORATION RATE: N/A VAPOR DENSITY: N/A
SOLUBILITY IN WATER: Dispersible. SPECIFIC GRAVITY: 1.73
DENSITY: 14.39 lb/gl pH: 12-13 in water.
ODOR: No distinct odor. APPEARANCE: Gray colored powder.
PHYSICAL STATE: Powdered Solid. VOC: 0.0 lb/gl(0 g/l)
10 - STABILITY AND REACTIVITY
CONDITIONS TO AVOID: None known.
CHEMICAL STABILITY: Stable.
HAZARDOUS DECOMPOSITION PRODUCTS:
Will not spontaneously occur. Addition of water will produce caustic calcium hydroxide, which can cause chemical burns.
HAZARDOUS POLYMERIZATION: Will not occur.
INCOMPATIBILITY: None known.
11 - TOXICOLOGICAL INFORMATION - CHRONIC AND ACUTE HEALTH HAZARDS
CRYSTALLINE SILICA - (Quartz, Christobalite) is considered a known human carcinogen by Federal (OSHA) and
advising health agencies (IARC, NIOSH, and NTP). Additionally, crystalline silica can cause a lung
condition known as silicosis after long term exposure to dusts containing crystalline silica. Exposure of
workers to crystalline silica containing dusts is specifically regulated by OSHA. The use of a correctly
fitted, NIOSH approved respirator suitable for use against crystalline silica inhalation is essential for
minimizing exposure to this danger. MINERAL DUSTS - Some items mentioned in section 2 of this MSDS are
considered mineral dusts by OSHA and a correctly fitted, NIOSH approved respirator is required when working
with this product. PORTLAND CEMENT AND CALCIUM HYDROXIDE - A single, short term exposure to the dry form of
these two items, which are present in this stucco concentrate mix, are not likely to cause serious harm.
However, exposure of sufficient duration to wet stucco can cause serious, potentially irreversible tissue
destruction of the skin or eye from caustic chemical burns, including third degree burns. The same type of
tissue destruction can occur if wet or moist areas of the body are exposed for sufficient duration to dry
stucco concentrate. Wet stucco is caustic and personal protective equipment, and proper work hygiene, must
be employed for protection against personal injury.
12 - ECOLOGICAL INFORMATION
There is no data available about this topic.
13 - DISPOSAL CONSIDERATIONS
This product must be disposed of in accordance with applicable local, state and federal regulations.
Where possible, it is best to use up any excess material.
MATERIAL SAFETY DATA SHEET
14 - TRANSPORT INFORMATION
US DOT PROPER SHIPPING DESCRIPTION: Not applicable.
15 - REGULATORY INFORMATION
U.S. FEDERAL REGULATIONS:
CERCLA - SECTION 103 (40CRF302.4)
This product contains the following toxic chemicals that require notification of the National Response
Center of releases of quantities of hazardous substances equal to or greater than the Reportable Quantities
(RQ).
*** No reportable quantities are present. ***
CLEAN AIR ACT - SECTION 112:
This product contains the following components present at or above the minimum level and listed as
Hazardous Air Pollutants:
*** No reportable quantities are present. ***
This product contains the following components present at or above the minimum level and listed as
Extremely Hazardous Air Pollutants:
*** No reportable quantities are present. ***
EPA VOC REGULATIONS:
THEORETICAL VOC FOR THIS PRODUCT =0.0 lb/gl(0 g/l)
OSHA:
This Material Safety Data Sheet is prepared to comply with the United States Occupational Safety and
Health Administration (OSHA) Hazard Communication Standard (29 CFR 1910.1200). Unlisted ingredients are not
'hazardous' per OSHA standard.
In addition to items listed in Section 11, This product contains the following items that are
specifically regulated by OSHA. Exposure limits may be found in Section 2 of this MSDS.
PORTLAND CEMENT65997-15-1
FLY ASH68131-74-8
SARA SECTION 302 (40CFR355.30), AND SECTION 304 (40CFR355.40):
This product contains the following chemicals that require emergency planning based on Threshold Planning
Quantities (TPQ) or release reporting based on Reportable Quantities (RQ):
*** No reportable quantities are present. ***
MATERIAL SAFETY DATA SHEET
SARA SECTION 311/312 (40CFR370.21) HAZARD CLASSIFICATION FOR THIS PRODUCT:
FIRE: NO PRESSURE GENERATING: NO REACTIVITY: NO
ACUTE HEALTH: YES CHRONIC HEALTH: YES
SARA SECTION 313 (40CFR372.65):
This product contains the following substances subject to the reporting requirements of Section 313 of
Title III of the Superfund Amendment and Reauthorization Act of 1986:
*** No reportable quantities are present. ***
TSCA:
All components of this product are listed, or are exempt from listing on the TSCA inventory.
STATE REGULATIONS:
CALIFORNIA
WARNING: The following chemicals are present in this coating product in small amounts. These chemicals
are listed by the California EPA as materials known to the State of California to cause cancer, (and/or)
birth defects, (and/or) other reproductive harm.
Chemical Name CAS Number
------------- ----------
PORTLAND CEMENT 65997-15-1
CRYSTALLINE SILICA 14808-60-7
CALCIUM HYDROXIDE 1305-62-0
FLY ASH 68131-74-8
16 - OTHER INFORMATION
The information and recommendation set forth herein are believed to be accurate. Because some of the
information used to prepare this document is derived from information provided to PareXLahabra, Inc. from
its suppliers, and because PareXLahabra, Inc. has no control over the conditions of handling and use, the
PareXLahabra, Inc. makes no warranty, expressed or implied, regarding the accuracy of the data or the
results to be obtained from the use thereof. The information and consideration, and PareXLahabra, Inc.
assumes no responsibility from use or reliance thereon. It is the responsibility of the user of
PareXLahabra, Inc. products to comply with all applicable federal, state, and local laws and regulations.
|