Permatex, Inc.
10 Columbus Blvd.
Hartford, CT 06106 USA
Telephone: 1-87-Permatex
(877) 376-2839
Emergency: 800-255-3924
Material Safety Data Sheet
1. PRODUCT IDENTIFICATION
Product Name: 133AR ANTI-SEIZE LUBRICANT 1OZ
Item No: 81343
Product Type: Lubricant
2. COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients Percent ACGIH 8 Hr. TWA: OSHA 8 Hr. TWA:
5 mg/m3 (oil mist) 5 mg/m3 (oil mist)
LITHIUM GREASE 30-40
Mixture
5 mg/m3 mist 5 mg/m3 mist
DISTILLATES (PETROLEUM), 20-30
HYDROTREATED HEAVY
NAPHTHENIC
64742-52-5
2 mg/m3 5 mg/m3
CALCIUM OXIDE 15-25
1305-78-8
2 mg/m3 respir.dust 5 mg/m3 TWA respir.; 15mg/m3
GRAPHITE 1-10
7782-42-5 total
5 mg/m3 TWA 10 mg/m3 TWA
MINERAL OIL 1-10
64741-44-2
metal dust, as Al: 10 mg/m3 TWA total dust, as Al: 15 mg/m3 TWA;
ALUMINIUM POWDER 5-15
respirable fraction, as Al: 5 mg/m3
(PYROPHORIC)
7429-90-5 TWA
0.1 mg/m3 TWA respirable 0.1 mg/m3 TWA respirable
SILICA, QUARTZ 0.1-1.0
14808-60-7
3. HAZARDS IDENTIFICATION
May cause eye and skin irritation. May cause nose, throat and respiratory irritation. May cause
Toxicity:
gastrointestinal irritation. May cause central nervous system (CNS) depression.
Eye and skin contact, ingestion, inhalation.
Primary Routes of Entry:
Signs and Symptoms of Exposure: Overexposure may cause eye and skin redness, difficulty breathing and vomiting. Excessive
accidental exposure may cause headache, dizziness, nausea and mild respiratory irritation. Inhalation
of dust at levels above recommended exposure limit may cause metallic or sweet taste, irritation of
pharynx and possible ulceration with performation of the nasal septum. Repeated skin contact may
cause allergic skin reactions.
Ingredients Percent NTP: ACGIH IARC:
Carcinogens
SILICA, QUARTZ 0.1-1.0 Known Carcinogen Not known Group 1; Vol. 68; 1997
14808-60-7
Medical Conditions Recognized as Persons with respiratory problems such as emphysema and asthma should avoid inhalation.
Being Aggravated by Exposure:
4. FIRST AID MEASURES
If swallowed, DO NOT induce vomiting. Keep individual calm. Obtain medical attention.
Ingestion:
If inhaled, remove to fresh air. If not breathing give artificial respiration, preferably mouth-to-mouth. If
Inhalation:
breathing is difficult give oxygen. Get medical attention.
Remove contaminated clothing. Wash area with soap and water. If irritation persists, seek medical
Skin Contact:
attention.
In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical
Eye Contact:
attention if irritation persists.
5. FIRE FIGHTING MEASURES
Greater than 200 degrees F. Method: Tag Closed Cup
Flash Point (掳F/C):
Carbon Dioxide, Dry Chemicals, Foam.
Recommended Extinguishing Media:
1 of 3
Product name: 133AR ANTI-SEIZE LUBRICANT 1OZ Item 81343
Firefighters should wear self-contained breathing apparatus. Water spray
Special Fire-Fighting Procedures:
may be ineffective on flames but should be used to keep fire-exposed
containers cool.
Metal oxide fumes, Oxides of carbon. Incomplete combustion may emit
Hazardous Products Formed by Fire or Thermal
component hydrocarbons.
Decomposition:
May ignite when sufficient heat is applied.
Unusual Fire/Explosion Hazards:
30% aluminum metal; 1% oil
Lower Explosive Limit:
7% oil
Upper Explosive Limit:
6. ACCIDENTAL RELEASE MEASURES
Eliminate all sources of ignition. Maintain good ventilation. Take up with an inert absorbent. Store in a
Spill Procedures:
closed waste container until disposal.
7. HANDLING AND STORAGE
Store away from heat, sparks or open flame. Do not store at temperatures above 120 degrees F.
Storage:
Avoid prolonged skin contact. Keep away from eyes. Do not inhale vapors. Do not use near heat,
Handling:
sparks or open flame. Wash hands and face after handling this compound.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Safety glasses or goggles.
Eyes:
Neoprene or nitrile gloves recommended.
Skin:
Provide adequate local ventilation to maintain vapor concentration below TLV if misting of oil occurs.
Ventilation:
Use an approved NIOSH organic vapor respirator below the TLV. If TLV is exceeded or overexposure
Respiratory Protection:
is likely, use positive pressure or self contained breathing apparatus.
9. PHYSICAL AND CHEMICAL PROPERTIES
Silver paste
Appearance:
PETROLEUM
Odor:
Not determined
Boiling Point (掳F):
Does not apply
pH:
Nil
Solubility in Water:
1.17
Specific Gravity:
Not determined
VOC Content(Wt.%):
Less than 5 mm Hg
Vapor Pressure:
Not Determined
Vapor Density (Air=1):
Not Determined
Evaporation Rate:
10. STABILITY AND REACTIVITY
Stable at normal conditions
Chemical Stability:
WILL NOT OCCUR
Hazardous Polymerization:
Strong oxidizers, alkalies, mineral acids, selected amines.
Incompatabilities:
Do not expose to heat or store at temperatures above 120 F.
Conditions to Avoid:
Metal oxide fumes, Oxides of carbon. Incomplete combustion may emit
Hazardous Products Formed by Fire or Thermal
component hydrocarbons.
Decomposition:
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal: Disposal should be made in accordance with federal, state and local regulations.
D001
US EPA Waste Number:
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
Domestic Ground Transport
Unrestricted
DOT Shipping Name:
NONE
Hazard Class:
2 of 3
Product name: 133AR ANTI-SEIZE LUBRICANT 1OZ Item 81343
None
UN/ID Number:
None
Marine Pollutant:
IATA
Unrestricted
Proper Shipping Name:
None
Class or Division:
None
UN/NA Number:
IMDG
Unrestricted
Proper Shipping:
None
Hazard Class:
None
UN Number:
15. REGULATORY INFORMATION
SARA 313 Chemicals: The following component(s) is listed as a SARA Section 313 Toxic Chemical.
SARA 313 Information
NONE
CALIFORNIA PROP 65:
No California Prop 65 chemicals are known to be present.
TSCA Inventory Status:
Listed on Inventory: YES All components of this product are listed (or exempt) on the EPA TSCA inventory.
16. OTHER INFORMATION
HEALTH 1, FLAMMABILITY 1 , REACTIVITY 1
Estimated NFPA Rating:
HEALTH 1, FLAMMABILITY 1, PHYSICAL HAZARD 0
Estimated HMIS Classification:
NFPA is a registered trademark of the National Fire Protection Assn.
HMIS is a registered trademark of the National Paint and Coatings Assn.
Denise Boyd, Health and Safety Manager
Prepared By: Revision Date: 09/16/2003
Permatex. Inc. 10 Columbus Blvd. Hartford, CT USA 2
Company: Revision
06106 Number:
Telephone Number: 1-87-Permatex (877) 376-2839
3 of 3
|