DATA SHEET
MATERIAIJ SAFETY
1
Page:
P
PRODUCTNAME: DESIGN MASTER TACK 1000 ADHESIVE HMISCODES:HFR
PRODUCT ODE: l-000
C
DTSTRTBUTORTDENTfI
NAME: DESIGN MASTER COLOR TOOL, INC.
DISTRIBUTOR'S
: P.O. BOX 601
ADDRESS
BOULDER, CO 80306 LabSafetySupptyInc. Reorder No. 17135
:
EMERGENCY PHONE 800-525-2644 INFORMATION PHONE : 3U 3-445-JZ 14
: L2/15/2006
DATE PREPARED NAME OF PREPARER : ESP
=========
HAZARDOUS INGREDIENTS/SARA INFORMATION
IfI
VAPOR PRESSURE WEIGHT
COMPONENTS CAS NUMBER nun Hq @ TEMP
REPORTABLE PERCENT
'78
* CYCLOHEXANE 20-30
L1_0-82-1 68
300 PPM, ACGIH TLV:300 PPM
OSHA PEL:
6 7- 6 4 - L 20-30
181 68
ACETONE
750 PPM, ACGIH T L V : 7 5 0 P P M
OSHA PEL:
L5-20
14-98-6 6350 68
PROPANE
1 0 0 0 P P M , A C G I H TLV: ASPHYXIANT
OSHA PEL:
1,06-978 - L5-20
1_640 68
BUTANE
OSHA PEL: 800 PPM, ACGIH TLV: 800 PPM
* Indicates subject to the requirements
toxic chemical(s) reporting of
secLion 313 of Title III and of 40 CFR 372.
_ ============
SECTION IIf PHYSICAL/CHEMICAL CHARACTERTSTICS
BOILING RANGE: -44 deg F to l-79 deg F SPECIFIC GRAVITY (H2O=1-): 0.12
VAPOR DENSTTY: HEAVTER THAN ATR EVAPORATION RATE: SLOWER THAN ETHER
IN WATER: NIII
SOI,UBILITY
APPEARANCE AND ODOR: AEROSOL PRODUCT
-
================= IV
SECTION FIRE AND EXPITOSION HAZARD DATA
FLASH POINT: -156 deg F METHOD USED: ESTIMATED
FLAMMABLE LIMITS IN AIR BY VOLUME- LOWER: 1-.3 UPPER: 13
EXTTNGUTSHTNG MEDrA: FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL, WATER
SPECIAL FIREFIGHTING PROCEDURES
WATER SPRAY MAY BE INEFFECTTVE. WATER MAY BE USED TO COOL CONTAINERS TO PREVENT
PRESSURE BUILD-UP AND EXPLOSTON WHEN EXPOSED TO EXTREME HEAT. IF WATER IS USED,
FOG NOZZLES PREFERRED. WEAR GOGGLES AND SELF-CONTATNED BREATHTNG APPARATUS.
UNUSUAL FIRE AND EXPLOSION HAZARDS
CLOSED CONTAINERS MAY EXPLODE FROM INTERNAL PRESSURE BUILD-UP WHEN EXPOSED TO
EXTREME HEAT AND DTSCHARGE CONTENTS. VAPOR ACCUMULATION CAN FLASH OR EXPLODE IF
IGNITED. OVEREXPOSURE TO DECOMPOSITION PRODUCTS MAY CAUSE A HEALTH HAZARD.
SYMPTOMS MAY NOT BE READILY APPARENT. OBTAIN MEDICAL ATTENTION.
- =======================
SECTION V REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID
APPLICATION TO HOT SURFACES. STORAGE ABOVE 120 DEG F. EXPOSURE TO OPEN FLAME.
(MATERIALS
INCOMPATIBILITY TO AVOID)
STRONG OXIDIZING AGENTS.
DATA SHEET
MATERIAL SAFETY
-
Dana )
HAZARDOUS DECOMPOSITION OR BYPRODUCTS
FUMES MAY CONTAIN CARBON
MAY PRODUCE FUMES WHEN HEATED TO DECOMPOSITION.
MONOXIDE AND OTHER TOXIC FUMES.
HAZARDOUS POLYMERIZATION: NOT OCCUR
WILL
_ ==================
H E A L T H H A Z A R DD A T A
SECTION Vf
AND SYMPTOMS OF EXPOSURE
HEALTH RISKS
INHALATION
DROWSINESS,
RESPIRATORY IRRfTATION, HEADACHE, NAUSEA, VOM]TING,
DIZZINESS,
EYE WATERTNG, UNCONSCIOUSNESS OR DEATH. MAY CAUSE HEART
IMPAIRED CO-ORDfNATION.
IRREGULARITES.
SKIN AND EYE CONTACT HEALTH RISKS AND SYMPTOMS OF EXPOSURE
DRY AND DEFAT THE SKIN.
PROLONGED OR REPEATED CONTACT MAY IRRITATE, EYES:
SKIN:
LIQUID OR VAPOR CAN IRRITATE.
SKfN ABSORPTTON HEALTH RISKS AND SYMPTOMS OF EXPOSURE
TO CRACK, LEADING
SOLVENT ACTION CAN DRY AND DEFAT THE SKIN CAUSING SKIN TO
DERMATITIS.
INGESTION HEALTH RISKS AND SYMPTOMS OF EXPOSURE
NOT A LIKELY ROUTE OF EXPOSURE. IF SWALLOWED,SEEK IMMEDIATE MEDICAL ADVICE
AND/OR ATTENTION.
HEALTH HAZARDS (ACUTE AND CHRONIC)
CAUSES IRRfTATION TO SKIN, EYES AND RESPIRATORY TRACT. OVEREXPOSURE CAUSES
NAUSEA, HEADACHE AND VOMITING. UNCONSCIOUSNESS OR DEATH MAY OCCUR IF TOO MUCH IS
BREATHED. MAY CAUSE HEART IRREGULARITES. PROLONGED CONTACT MAY DRY AND DEFAT THE
SKTN. REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL EXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE.
CARC]NOGENICITY: NTP CARCINOGEN: No IARC MONOGRAPHS: NO OSHA REGULATED: NO
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE
LIVER AND KIDNEY DISEASE, ANEMIA, CORONARY DISEASE. PREGNANT WOMEN SHOULD AVOID
EXPOSURE TO SOLVENTS.
EMERGENCY AND FIRST AID PROCEDURES
REMOVE TO FRESH AIR.
INHAI,ATION: ADMINISTER OXYGEN IF NEEDED. APPLY ARTTFICIAL
RESPfRATTON rF BREATHTNG HAS STOPPED. GET MEDICAL ATTENTION. SKIN: REMOVE
CONTAMINATED CLOTHING AND WASH IT BEFORE REUSE. WTPE OFF WTTH TOWEL. WASH WITH
SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION PERSISTS. EYES: WASH
IMMEDIATELY WITH LARGE VOLUMES OF FRESH WATER FOR AT LEAST 15 MINUTES. GET
MEDICAL ATTENTION.
DPE'r-ATTTTN\Tq E'r)P CAE'E' I-IAITNT.TNTT: A\TN TTqT'
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED
AVOID BREATHING VAPORS. VENTILATE AREA. REMOVE ALL SOURCES OF IGNITION. CLEAN UP
AREA WITH ABSORBENT MATERIAL AND PLACE IN CLOSED CONTATNERS FOR DISPOSAL.
WASTE DISPOSAL METHOD
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULAT]ONS. BEFORE
ATTEMPTING CLEAN UP, REFER TO OTHER SECTIONS OF THTS MSDS FOR HAZARD CAUTION
TNFORMATION.
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING
STORE AND USE IN COOL, DRY, WELL-VENTILATED AREAS. VAPORS MAY CAUSE FLASH FIRE
MATERIAL SAFETY DATA SHEET
Page: 3
KEEP AWAY FROM HEAT, SPARKS AND FLAME. DO NOT STORE ABOVE 120 DEG F. DO NOT
(BURN) CANS. DO NOT STICK PIN, NAIL OR ANY OTHER SHARP
PUNCTURE OR INCINERATE
OB.JECT INTO OPEN,ING ON TOP OF CAN. DO NOT SPRAY IN EYES . SEE PRODUCT LABEL FOR
ADDITIONAL INFORMATfON.
OTHER PRECAUTIONS
USE WTTH ADEQUATE VENT]LATTON. TO PREVENT VAPOR BUILD_UP, OPEN DOORS AND WINDOWS
OR USE AN EXPLOSION-PROOF EXHAUST FAN TO ENSURE FRESH AIR EXCHANGE DURING AND
AFTER USE. DO NOT BREATHE VAPOR, GAS OR SPRAY MIST. WHEN USING, DO NOT EAT,
DRINK OR SMOKE. AVOID CONTACT WITH EYES, SKTN AND CLOTHING. WEAR PROTECTIVE
EQUTPMENT. WASH THOROUGHLY AFTER HANDLING. REMOVE CONTAMINATED CLOTHTNG AND WASH
BEFORE REUSE. EMPTY CONTAINERS RETAIN PRODUCT RESIDUES; FOLLOW LABEL WARNINGS
EVEN AFTER CAN IS EMPTIED. DO NOT STORE IN BASEMENTS.
RESPIRATORY PROTECTTON
AVOID BREATHING VAPORS. USE WITH ADEQUATE VENTILATION EQUAL TO OUT OF DOORS. IN
RESTRTCTED AREAS, USE APPROVED CHEMICAL/ MECHANICAL FILTERS DESIGNED TO REMOVE A
COMBINATTON OF PARTICLES AND VAPOR. IN CONFINED AREAS, USE APPROVED ATR LTNE
TYPE RESPIRATOR OR HOOD. SELF-CONTAINED BREATHING APPARATUS IS REQUIRED FOR
VAPOR CONCENTRATIONS ABOVE PEL/TLV LIMITS.
VENTILATION
SUFFICIENT TO PREVENT INHALATTON OF SOLVENT VAPORS. GENERAL DILUTION AND/OR
LOCAL EXHAUST VENTfLATION IN VOLUME OR PATTERN TO KEEP PEL/TLV OF MOST HAZARDOUS
INGREDIENT BELOW ACCEPTABLE LTMIT AND LEL BELOW STATED LIMIT.
PROTECTIVE GLOVES
SOLVENT RES]STANT GLOVES REQUIRED FOR PROLONGED OR REPEATED CONTACT.
EYE PROTECTION
USE OF SAFETY GLASSES WITH SPLASH GUARDSOR FULL FACE SHIELD IS RECOMMENDED.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT
USE OF SOLVENT RESISTANT APRONS OR OTHER CLOTHING IS RECOMMENDED.
WORK/HYGIENTC PRACTTCES
EYE WASHES AND SAFETY SHOWERS IN THE WORKPLACE ARE RECOMMENDED.
==========================
DISCLAIMER
JELIfVT\ AA
THE INFORMATTON CONTAINED HEREIN TS BASED ON DATA CONSTDERED ACCURATE. HOWEVER,
NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THE DATA OR THE
RESULTS TO BE OBTAINED FROM THE USE THEREOF. BECAUSE THE INFORMATION CONTATNED
HEREIN MAY BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL, WE ASSUME NO
RESPONSIBILITY FOR ITS USE.
|