Material Data Safety Sheet 鈭? Product #30009014
939150 MATERIAL SAFETY DATA SHEET
MEDICAL EMERGENCIES ONLY (24 Hour Service): 1鈭?800鈭?328鈭?0026
Medical Calls from Outside of the USA: 1鈭?651鈭?222鈭?5352
Ecolab Vehicle Care Division
Ecolab Center St. Paul MN 55102
Product Information: 1鈭?877鈭扙COWASH Issue Date: February 21, 2001
==========================================================================
1.0 IDENTIFICATION /
1.1 Product Name: TAR ADHESIVE REMOVER
1.2 Product Type: Liquid High Solvent Tar and Adhesive Remover
1.3 Hazard Rating: Health: 2 Fire: 3 Reactivity: 0
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
Substances Subject to SARA 313 Reporting Are Indicated by "#"
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
2.0 HAZARDOUS COMPONENTS / (in mg/m3)
CAS No. % PEL TWA
2.1 # Xylene (mixed isomers) 1330鈭?20鈭?7 70 100 100*
*ACGIH STEL = 150 ppm
2.2 # sec鈭払utyl alcohol 78鈭?92鈭?2 10 450 300
2.3 Aliphatic petroleum distillates 64742鈭?47鈭?8 20鈭?50 5 5
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
STEL = ACGIH short term exp. limit (15 min) PEL = OSHA 8 hr ave in air
TWA = ACGIH 8 hr average C = ceiling limit in air, do not exceed
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
3.0 PHYSICAL DATA /
3.1 Appearance: Clear colorless liquid; sweet aromatic odor
3.2 Solubility in Water: Negligible
3.3 pH: Not applicable
3.4 Initial Boiling Point: 210 deg F / 98 deg C
3.5 Specific Gravity: 0.850 @ 68 deg F / 20 deg C
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
4.0 FIRE AND EXPLOSION DATA /
4.1 Special Fire Hazards: Flammable liquid. Vapors released at room
temperature may travel along floor to ignition source and flash back.
4.2 Fire Fighting Methods: Use dry chemical, foam, water fog, fine water
spray, or CO2.
4.3 Flash Point: 74 deg F / 23 deg C (TCC)
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
5.0 REACTIVITY DATA /
5.1 Stability: Stable under normal conditions of use and handling.
5.2 Conditions to Avoid: High heat, ignition sources. Also avoid strong
acids and oxidizers.
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
6.0 SPILL OR LEAK PROCEDURES / WEAR PROPER PROTECTIVE EQUIPMENT
6.1 Cleanup: Remove ignition sources. Recover free liquid and add
inert absorbent to spill area. Use non鈭抯parking tools.
6.2 Waste Disposal: Consult state/local authority for limits on chemical
waste disposal. Unused product is RCRA ignitable (D001).
==========================================================================
7.0 HEALTH HAZARD DATA / WARNING
7.1 Effects of Overexposure to Concentrate:
Eyes: Causes minor to moderate irritation.
Skin: Causes defatting of skin, dryness, and irritation.
If Swallowed: Harmful or fatal if swallowed. Pulmonary aspiration
hazard if swallowed and vomiting occurs. May cause liver damage.
If Inhaled: Concentrated vapors may cause respiratory tract
irritation, nausea, dizziness, loss of coordination, headaches,
respiratory arrest, unconsciousness or death.
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭?
8.0 FIRST AID /
8.1 Eyes: Flush with cool running water. Remove contact lenses and
continue flushing for 15 minutes.
8.2 Skin: Flush skin with water; wash with soap and water. Remove
and wash contaminated clothing before reuse.
8.3 If Swallowed: Rinse mouth; then drink 1 or 2 large glasses of
water. DO NOT induce vomiting. In case of nausea or spontaneous
vomiting, keep head below hips. NEVER give anything by mouth to
an unconscious person.
8.4 If Inhaled: Immediately move to fresh air. If breathing is difficult
administer oxygen, if breathing stopped give artificial respiration.
IF SWALLOWED, CALL THE MEDICAL EMERGENCY NUMBER IMMEDIATELY
(1鈭?800鈭?328鈭?0026); IN CASE OF PERSISTENT EYE OR SKIN IRRITATION,
CALL A POISON CONTROL CENTER OR PHYSICIAN
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
9.0 PROTECTIVE MEASURES /
9.1 FOR CONCENTRATE:
Eyes: Wear chemical splash goggles.
Skin: Wear any impervious glove.
Respiratory: Avoid breathing mists or vapors of this product.
Ventilate to maintain air levels below exposure limits.
鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝鈭掆垝
10.0 ADDITIONAL INFORMATION /
10.1 DOT: FLAMMABLE LIQUID,N.O.S.,(CONTAINS XYLENE AND SECONDARY
BUTANOL),3,UN1993,III
1
Material Data Safety Sheet 鈭? Product #30009014
10.2 Purpose of 2/21/2001 issue: Add flash point data. Replaces
August 24, 2000 issue.
KEEP OUT OF REACH OF CHILDREN
The above information is believed to be correct with respect to the
formula used to manufacture the product. As data, standards, and
regulations change, and conditions of use and handling are beyond our
control, NO WARRANTY, EXPRESS OR IMPLIED, IS MADE AS TO THE COMPLETENESS
OR CONTINUING ACCURACY OF THIS INFORMATION.
2
|