MATERIAL SAFETY DATA SHEET
FIRE-TROL HOLDINGS, L.L.C.
FIRE-TROL庐 FIREFOAM庐 103 & 103B
Fire-Trol Holdings, L.L.C.
2620 N. 37th Dr.
Phoenix, AZ 85009
(602) 262-5401
(530) 865-4932 (24 hr. number)
CAUTION
Avoid eye contact; may be irritating. Avoid unprotected exposure of the skin. Work in a well-ventilated
area to avoid possible irritation of respiratory tract.
CLASSIFICATION: NON-HAZARDOUS
A. MATERIAL IDENTIFICATION AND INFORMATION
GENERAL INFORMATION
FIRE-TROL庐 FIREFOAM庐 103 &103B are mixtures of foaming and wetting agents in a
non-flammable solvent. The active ingredients are commonly used in hair shampoo and
dish washing liquid formulas.
DOT Proper Shipping Name: This product is not classified as a hazardous
material by the U.S. Department of Transportation.
DOT Hazard Classification/I.D.: Not applicable.
Label(s): Product Label.
U.S. Surface Freight
Classification: Cleaning compound.
SARA Hazard Notification:
Hazardous Categories Under
Criteria of SARA Title III
Rules (40 CFR Part 370) None
SECTION 313 TOXIC CHEMICAL(S) None
HAZARDOUS CHEMICAL(S) UNDER OSHA HAZARD COMMUNICATION STANDARD
Permissible Concentrations (air) :
Hexylene Glycol (CAS 107-41-5): 25 ppm, 125 mg/m3, ceiling (OSHA).
HEALTH HAZARD CLASSIFICATION: An immediate health hazard.
WARNING STATEMENTS:
WARNING! May cause respiratory tract irritation. May cause eye and skin irritation.
PRECAUTIONARY MEASURES:
Avoid breathing fumes.
Use with adequate ventilation.
Avoid unnecessary contact with eyes and skin.
CALIFORNIA PROPOSITION 65 None
FIRE-TROL庐 FIREFOAM餂? 103 & 103B
January 4, 2000
Page 2 of 4
B. OCCUPATIONAL CONTROL PROCEDURES
For handling concentrates
Avoid eye contact with concentrates. Wear goggles when handling concentrates.
Avoid skin contact with concentrates. Use rubber or plastic solvent resistant gloves to avoid
prolonged skin contact with concentrates.
Avoid excessive inhalation of concentrates' vapors.
Ventilation. Handle concentrates in a well-ventilated area. Permissible concentration in air
of:
hexylene glycol solvent (CAS 107-41-5) is 25 ppm, 125 mg/m3, ceiling (OSHA) .
Avoid ingestion of concentrates.
For handling diluted product
Avoid unnecessary eye and skin contact.
Minimal effects expected from contact if it occurs.
C. FIRE PROTECTION INFORMATION FOR CONCENTRATES
Flash Point
Flash point greater than 200oF by Pensky Martens Closed Cup Test.
Extinguishing Media for Concentrates
Carbon dioxide, dry chemical, foam, or water spray. Class A, BC, or ABC fire extinguishers,
sand/earth.
Special Fire Fighting Procedures in Enclosed Areas
There are no special hazards associated with diluted product as used for fire fighting. In case
of an accident or fire involving either concentrate, fire fighters must be equipped to prevent
breathing of vapors or products of combustion. Wear an approved self-contained breathing
apparatus and protective clothing.
Unusual Fire or Explosion Hazards
None
D. PHYSIOLOGICAL EFFECTS AND HEALTH INFORMATION (Toxicological Data)
Note: All animal tests reported in this section for both the concentrate and diluted mixtures were done
in accordance with "USDA Interim Requirements and Manufacturer Submission Procedures for Wild
Land Fire Foam, 5100-Fire, August, 1986", through the U.S. Forest Service, by an independent
laboratory. The results which follow are all acceptable under those requirements.
For concentrate before diluting with water
Eye Irritation: Moderately irritating
Skin Irritation: Slight irritant
Acute Oral Toxicity: LD50>5050 mg/kg (Practically Non-Toxic)
Acute Dermal Toxicity: LD50>2010 mg/kg (No more than Slightly Toxic)
For diluted product (1.0% by volume)
Eye Irritation: Minimally irritating
Skin Irritation: Slight irritant
Acute Oral Toxicity: LD50>5050 mg/kg (Practically Non-Toxic)
Acute Dermal Toxicity: LD50>2010 mg/kg (No more than Slightly Toxic.)
FIRE-TROL庐 FIREFOAM餂? 103 & 103B
January 4, 2000
Page 3 of 4
E. PHYSICAL & CHEMICAL PROPERTIES
Color: Light amber, low viscosity liquid
Odor: Bland
pH in 10% aqueous solution: 9.0-9.5
Specific Gravity: 1.025 or 8.5 lb./gal. (Typical, not a specification.)
Vapor Pressure (mm Hg) at 20oC: <1
F. REACTIVITY DATA
Stability
Concentrates have excellent long-term stability for an indefinite period. Can be used at
temperatures down to the freezing point of water. Do not store above 150oF.
Corrosion Performance
Products have been tested by the USDA Forest Service according to 90 day weight loss
corrosion requirements for Fire Chemicals Specification 5100-304a. There is minimal
corrosion on 2024 T3 aluminum and naval brass and moderate corrosion on mild steel for both
the concentrate and the diluted product (1.0% by volume). FIRE-TROL庐 FIREFOAM庐 103B
is approved for use in fixed-tank helicopters and all concentrates are approved for use in
helicopters with buckets and ground tanks (fire engines as part of the field evaluation
program).
Storage
Recommend storing concentrates in polyethylene or polyethylene-lined containers ONLY.
DO NOT store concentrates in metal tanks. The concentrates are not corrosive and meet
USDA Forest Service requirements for corrosion. However, metal contamination of the
concentrates will degrade the foams' performance. This is typical of foaming agents, which
are therefore routinely supplied in polyethylene containers.
Hazardous Decomposition of Products
There are no significant hazardous decomposition products from a fire's action on the diluted
product as used in fire fighting. When a fire occurs adjacent to stored concentrates, such as
in a highway accident, the concentrates will break down to give off carbon monoxide and
oxides of sulfur. These gases can be harmful in enclosed areas so fire fighters must then wear
an approved self-contained breathing apparatus and protective clothing.
Hazardous polymerization will not occur.
Incompatibility (Keep Away From)
Strong oxidizers such as hydrogen peroxide, bromine, and chromic acid.
G. SPILL, LEAK AND DISPOSAL INFORMATION
Spills of FIRE-TROL庐 FIREFOAM庐 103 & 103B concentrates should be physically removed with a
shovel. Sand or other absorbent material can be used to facilitate removal. Direct application of water
to FIREFOAM 103 & 103B concentrates may result in excessive foaming. Water can be used for final
clean-up after concentrate is removed.
FIRE-TROL庐 FIREFOAM餂? 103 & 103B
January 4, 2000
Page 4 of 4
H. ENVIRONMENTAL PROTECTION
FIRE-TROL FIREFOAM 103 & 103B are biodegradable and have minimal environmental impact.
Due to the sensitivity of aquatic life to chemicals, we do not recommend the application of FIRE-
TROL FIREFOAM 103 & 103B directly into streams or other bodies of water. The 96-h LC50 on
juvenile rainbow trout are 30 mg/l and 41.1 mg/l for FIRE-TROL FIREFOAM 103 & 103B,
respectively.
I. EMERGENCY & FIRST AID PROCEDURES (For Concentrates)
Eye Contact
Flush eyes immediately with plenty of water for at least fifteen minutes.
Skin Contact
Wash off with water. Remove contaminated clothing.
Inhalation
Remove person to fresh air and provide oxygen if breathing is difficult. Get medical attention.
NOTICE OF WARRANTY: Fire-Trol Holdings, L.L.C. warrants that FIRE-TROL products are
reasonably fit for the purposes they were intended only when used in accordance with recommended use
practices under normal conditions. In no case shall Fire-Trol Holdings, L.L.C. be liable for
consequential, special, or indirect damages resulting from the use or handling of these products. ALL
such risks shall be assumed by the buyer. FIRE-TROL HOLDINGS, L.L.C. MAKES NO
WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE NOR
ANY OTHER EXPRESSED OR IMPLIED WARRANTY, EXCEPT AS STATED ABOVE.
January 4, 2000 Supersedes all previous dates for FIRE-TROL铮? FIREFOAM铮? 103 & 103B
|