Material Safety Data Sheet U.S. Department of Labor
May be used to comply with Occupational Safety and Health Administration
OSHA's Hazard Communication Standard, (Non-Mandatory-Form)
29 CFR 1910.1200. Standard must be Form Approved
consulted for specific requirements. OMB No. 1218-0072
Note: Blank spaces are not permitted. If any item is not applicable, or no
IDENTITY (As Used on Label and List)
information is available, the space must be marked to indicate that.
QUICKWAY OVEN AND HOOD CLEANER
NA = Not Applicable NIA = No Information Available
Section I
Manufacturer's Name Emergency Telephone Number
Sunburst Chemicals, Inc. 1-866-303-6943 (7 days/24 hours)
Telephone Number For Information
Address (Number, Street, City, State, and ZIP Code)
(952)884-3144
220 W. 86th Street
Date Prepared
01-30-03
Bloomington, MN 55420
Signature of Preparer (optional)
Section II - Hazardous Ingredients/Identity Information
Other Limits
Hazardous Components (Specific Chemical Identity; Common Name(s)) OSHA PEL ACGIH TLV Recommended %(optional)
2 mg/m3 2 mg/m3
Potassium Hydroxide CAS# 1310-58-3
2-2-Butoxyethanol CAS# 112-34-5 NIA NIA
Isobutane CAS# 75-28-5 800 ppm 800 ppm
Propane CAS# 74-98-6 1000 ppm Asphyxiant
2-Methyl 鈥?2, 4 Pentanediol CAS# 107-41-5 25 ppm 25 ppm
Ceiling Ceiling
Section III - Physical/Chemical Characteristics
Boiling Point Specific Gravity (H20=1)
1,022
212掳F.
Vapor Pressure (mm Hg.) Melting Point
NA NA
Vapor Density (AIR=1) Evaporation Rate
(Butyl Acetate = 1)
>1 NA
Solubility In Water PH
Complete. 13.0
Appearance and Odor
Opaque tan liquid, lemon scent.
Section IV - Fire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limits LEL UEL
NIA. NIA NIA NIA
Extinguishing Media
Water, CO2, Dry chemical.
Special Fire Fighting Procedures
Spray with water to keep cans cool.
Unusual Fire and Explosion Hazards
Aerosol containers may burst if heated above 120掳F.
HMIS NFPA
2 HEALTH HEALTH HAZARD FIRE HAZARD Flash Points SPECIFIC HAZARD REACTIVITY
Oxidizer OX
2 FLAMMABILITY 4 Deadly 4 Below 73掳F (Boiling pt. below 100掳F) 4 May detonate
Acid ACID
0 REACTIVITY 3 Extreme danger 3 Below 73掳F (Boiling pt. at/above 100掳F) 3 Shock and heat may detonate
X and/or at/above 73掳F 鈥? not exceeding 100掳F X Alkali ALK
B PERSONAL 2 Hazardous 2 Violent chemical change
X Corrosive COR
PROTECTION 1 Slightly hazardous 2 Above 100掳F, Not Exceeding 200掳F 1 Unstable if heated
Use NO WATER X
0 Normal material 1 Above 200掳F 0 Stable
Radioactive
0 Will not burn
Fdrive/Pubs/MSDS_Sht/Cleaners/QuickwayOvenAndHoodCleaner.doc
Page 1
(CONTINUED) 鈥? QUICKWAY OVEN AND HOOD CLEANER
Section V 鈥? Reactivity Data
Stability Unstable Conditions to Avoid
X
Stable
Incompatibility (Materials to Avoid)
Aluminum, strong acids, strong oxidizers, copper, wool.
Hazardous Decomposition or Byproducts
Oxides of carbon, potassium oxides.
Hazardous May Occur Conditions to Avoid
Polymerization
X
Will Not Occur
Section VI - Health Hazard Data
Routes(s) of Entry: Inhalation? Skin? Ingestion?
Yes Yes Yes
Health Hazards (Acute and Chronic)
ACUTE 鈥? corrosive to eyes and skin, chemical burns, distress to digestive tract.
CHRONIC 鈥? NIA.
Carcinogenicity: NTP? IARC Monographs? OSHA Regulated?
NO NO NO
Signs and Symptoms of Exposure
EXTERNAL - redness of skin or eyes, burning sensation. INTERNAL 鈥? foul taste, burning
sensation in mouth and throat.
Medical Conditions Generally Aggravated by Exposure
Open sores or wounds.
Emergency and First Aid Procedures
EXTERNAL 鈥? thoroughly rinse with water for at least 15 minutes. Get medical
attention if irritation persists. INTERNAL 鈥? drink a large quantity of milk, raw eggs
or water. Get immediate medical attention.
Section VII 鈥? Precautions for Safe Handling and Use
Steps to Be Taken in Case Material is Released or Spilled
Absorb spilled material with an absorbent material such as clay, sawdust, or sand.
Sweep up as much of this as possible and place in a sealed, labeled container or
in a proper landfill. Thoroughly rinse the affected area with water.
Waste Disposal Method
Spilled material should be collected as above for disposal in a landfill according to
Federal, State, and Local regulations. Any rinsing of the affected area should also be
in accordance with Federal, State and Local regulations.
Precautions to Be Taking in Handling and Storing
Keep tightly closed when not in use.
Other Precautions
Avoid contact of product (or its use solutions) with skin, eyes or clothing. Keep out
of reach of children.
Section VIII 鈥? Control Measures
Respiratory Protection (Specify Type)
5 micron particle mask recommended if used in enclosed area.
Ventilation Local Exhaust Special
NA NIA
Other
Mechanical (General)
Use in well ventilated areas.
NIA
Protective Gloves Eye Protection
Rubber or vinyl. Safety glasses, goggles recommended.
Other Protective Clothing or Equipment
As needed to prevent skin contact.
Work/Hygienic Practices
Always wash hands after handling.
Fdrive/Pubs/MSDS_Sht/Cleaners/QuickwayOvenAndHoodCleaner.doc
Page 2
|