Material Safety Data Sheet U.S. Department of Labor
May be used to comply with Occupational Safety and Health Administration
OSHA's Hazard Communication Standard, (Non-Mandatory-Form)
29 CFR 1910.1200. Standard must be Form Approved
consulted for specific requirements. OMB No. 1218-0072
Note: Blank spaces are not permitted. If any item is not applicable, or no
IDENTITY (As Used on Label and List)
information is available, the space must be marked to indicate that.
SUNSHINE RINSE ADDITIVE
NA = Not Applicable NIA = No Information Available
Section I
Manufacturer's Name Emergency Telephone Number
Sunburst Chemicals, Inc. 1-866-303-6943 (7 days/24 hours)
Telephone Number For Information
Address (Number, Street, City, State, and ZIP Code)
(952)884-3144
220 W. 86th St.
Date Prepared
01-15-03
Bloomington, MN 55420
Signature of Preparer (optional)
Section II - Hazardous Ingredients/Identity Information
Other Limits
Hazardous Components (Specific Chemical Identity; Common Name(s)) OSHA PEL ACGIH TLV Recommended %(optional)
Contains no hazardous ingredients
PA: Identification of specific ingredients is being withheld as a trade secret.
NJ 鈥? TRSN 6830-5054
Section III - Physical/Chemical Characteristics
Boiling Point Specific Gravity (H20=1)
Over 212掳F. 1.02
Vapor Pressure (mm Hg.) Melting Point
NA NIA
Vapor Density (AIR=1) Evaporation Rate
(Butyl Acetate = 1)
NA NA
Solubility In Water
Disperses.
Appearance and Odor
Blue liquid, alcohol odor.
Section IV - Fire and Explosion Hazard Data
Flash Point (Method Used) Flammable Limits LEL UEL
None. NA NA
Extinguishing Media
Water, CO2, Dry chemical.
Special Fire Fighting Procedures
None.
Unusual Fire and Explosion Hazards
None.
HMIS NFPA
1 HEALTH HEALTH HAZARD FIRE HAZARD Flash Points SPECIFIC HAZARD REACTIVITY
Oxidizer OX
0 FLAMMABILITY 4 Deadly 4 Below 73掳F (Boiling pt. Below 100掳F) 4 May detonate
Acid ACID
0 REACTIVITY 3 Extreme danger 3 Below 73掳F (Boiling pt. At/above 100掳F) 3 Shock and heat may detonate
and/or at/above 73掳F - not exceeding 100掳F Alkali ALK
A PERSONAL 2 Hazardous 2 Violent chemical change
X Corrosive COR
PROTECTION 1 Slightly hazardous 2 Above 100掳F, Not Exceeding 200掳F 1 Unstable if heated
Use NO WATER X
0 Normal material 1 Above 200掳F 0 Stable
X Radioactive
0 Will not burn
Fdrive/Pubs/MSDS_Sht/Glass-Dish/SunshineRinseAdditive.doc
Page 1
(CONTINUED) 鈥? SUNSHINE RINSE ADDITIVE
Section V - Reactivity Data
Stability Unstable Conditions to Avoid
X
Stable
Incompatibility (Materials to Avoid)
None.
Hazardous Decomposition or Byproducts
None.
Hazardous May Occur Conditions to Avoid
Polymerization
X
Will Not Occur
Section VI - Health Hazard Data
Routes(s) of Entry: Inhalation? Skin? Ingestion?
NO NO NO
Health Hazards (Acute and Chronic)
ACUTE - irritation, burning eyes, digestive tract disorder. CHRONIC 鈥? NIA.
Carcinogenicity: NTP? IARC Monographs? OSHA Regulated?
NIA NIA NIA
Signs and Symptoms of Exposure
SKIN & EYES 鈥? irritation, burning sensation. INTERNAL - nausea, foul taste.
Medical Conditions Generally Aggravated by Exposure
Open sores or wounds.
Emergency and First Aid Procedures
EXTERNAL 鈥? thoroughly rinse with water. INTERNAL 鈥? drink a large volume of milk, raw
eggs or water. Get immediate medical attention.
Section VII - Precautions for Safe Handling and Use
Steps to Be Taken in Case Material is Released or Spilled
Absorb spilled material with an absorbent material such as clay, sawdust, or sand.
Sweep up as much of this as possible and place in a sealed, labeled container or
in a proper landfill. Thoroughly rinse the affected area with water.
Waste Disposal Method
Spilled material should be collected as above for disposal in a landfill according to
Federal, State, and Local regulations. Any rinsing of the affected area should also be
in accordance with Federal, State and Local regulations.
Precautions to Be Taking in Handling and Storing
None.
Other Precautions
None.
Section VIII 鈥? Control Measures
Respiratory Protection (Specify Type)
Not required.
Ventilation Local Exhaust Special
NA NIA
Other
Mechanical (General)
NIA
NIA
Protective Gloves Eye Protection
Rubber or vinyl recommended. Safety glasses, goggles recommended.
Other Protective Clothing or Equipment
Not required.
Work/Hygienic Practices
Always wash hands after handling.
Fdrive/Pubs/MSDS_Sht/Glass-Dish/SunshineRinseAdditive.doc
Page 2
|