MATERIAL SAFETY DATA SHEET
SPEEDTRACK Clean & Burnish Date Prepared: 06/07/2000
Date Revised: 06/07/2000
1. PRODUCT AND COMPANY IDENTIFICATION
Product Name/Use: SPEEDTRACK Clean & Burnish
MANUFACTURER
Butcher Telephone Number: 800-225-9475
The Butcher Company
Emergency T elephone (24 hours): 800-228-5635
67 Forest Street
CHEMTREC (U.S./Can.): 800-424-9300
Marlborough, MA 01752-3012
CHEMTREC (Int鈥檒): +1 703-527-3887
2. COMPOSITION / INFORMATION ON INGREDIENTS
INGREDIENT(S) CAS NO. % BY WEIGHT
Pine oil 8002-09-3 3鈥?5
Isopropylamine dodecylbenzenesulfonate 26264-05-1 1鈥?3
Nonyl phenol ethoxylate 9016-45-9 1鈥?3
See Section 8 for Exposure Limits NA - Not Applicable
OSHA REGULATORY STATUS: This product is classified as hazardous under OSHA regulations.
WHMIS CLASS: Class D- Division 2B
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
Opaque, White Liquid. Pine Odor. May Cause Eye Irritation. May Cause Allergic Skin Reaction.
POTENTIAL HEALTH EFFECTS (See Section 11 for Toxicological Information)
PRIMARY ROUTE(s) OF EXPOSURE: X Eye X Skin Contact Skin Absorption
X Inhalation X Ingestion
EFFECTS OF ACUTE EXPOSURE
EYES:
May cause eye irritation. Symptoms may include redness and pain.
SKIN:
May cause slight skin irritation. Symptoms may include temporary redness.
INHALATION:
High concentrations of vapor or mist may cause nose, throat and respiratory tract irritation. Symptoms may
include coughing.
MSDS No: 4032 Page: 1 of 7
SPEEDTRACK Clean & Burnish Date Prepared: 06/07/2000
Date Revised: 06/07/2000
INGESTION:
May cause mouth, throat and stomach irritation. Symptoms may include nausea, vomiting and diarrhea.
EFFECTS OF CHRONIC EXPOSURE:
Prolonged or repeated exposure to an ingredient in this product may cause allergic skin reaction.
MEDICAL CONDITIONS AGGRAVATED:
May aggravate pre-existing eye, skin and respiratory conditions.
4. FIRST AID MEASURES
EYES:
Flush eyes with plenty of water while holding eyelids apart. After initial flushing, remove any contact lenses and
continue flushing for at least 15 minutes. Do not put any medication in the victim鈥檚 eyes unless instructed by a
physician. Get medical attention.
SKIN:
Flush with water, then wash with soap and water. Remove saturated clothing. Get medical attention if irritation
develops.
INHALATION:
Remove to fresh air. If not breathing, give respiration; if breathing is difficult, give oxygen (by trained personnel
only). Get medical attention if symptoms persist.
INGESTION:
Do not induce vomiting. Drink large quantities of water. Get immediate medical attention. Never give anything
by mouth to an unconscious person.
5. FIRE FIGHTING MEASURES
FLASH POINT AND METHOD: >200掳F 93掳C TCC
FLAMMABLE LIMITS:
Not applicable.
AUTOIGNITION TEMPERATURE: Not applicable.
EXTINGUISHING MEDIA:
Use extinguishing media appropriate for surrounding fire.
HAZARDOUS COMBUSTION PRODUCTS:
Normal products of combustion (carbon monoxide and carbon dioxide).
FIRE AND EXPLOSION HAZARDS:
None known.
MSDS No: 4032 Page: 2 of 7
SPEEDTRACK Clean & Burnish Date Prepared: 06/07/2000
Date Revised: 06/07/2000
FIRE FIGHTING INSTRUCTIONS:
This product is not flammable. As in any fire, MSHA/NIOSH approved self-contained breathing apparatus
(SCBA) and full protective gear should be worn.
6. ACCIDENTAL RELEASE MEASURES
See Section 8, Exposure Controls/Personal Protection and Section 3, Hazard Identification. Floors may be
slippery. Use care to avoid falling. Contain and isolate spill. Keep non-essential personnel from entering spill
area. Use mop, absorbent, or wet vacuum to collect material for proper disposal. Rinse area with water.
7. HANDLING AND STORAGE
HANDLING:
Follow label use directions. Do not mix with other chemicals unless instructed by label directions. Avoid contact
with eyes and skin. Wash thoroughly after handling. Remove saturated clothing. Wash clothing and equipment
before reuse.
STORAGE:
Keep container closed when not in use. Store away from incompatible materials. (See Section 10, Stability and
Reactivity).
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
PERSONAL PROTECTIVE EQUIPMENT (PPE)
EYE:
Where eye contact is possible, wear safety glasses with side shields or chemical splash goggles (ANSI Z87.1
approved).
SKIN:
Where prolonged or repeated contact is possible, chemical-resistant clothing (e.g., gloves) is recommended.
RESPIRATORY:
No respiratory protection is required if ventilation is adequate.
ENGINEERING CONTROLS:
Good general room ventilation is expected to be adequate.
MSDS No: 4032 Page: 3 of 7
SPEEDTRACK Clean & Burnish Date Prepared: 06/07/2000
Date Revised: 06/07/2000
EXPOSURE LIMITS:
INGREDIENT(S) OSHA PEL/STEL ACGIH TLV/STEL
Pine oil NA NA
Isopropylamine dodecylbenzenesulfonate NA NA
Nonyl phenol ethoxylate NA NA
NA - Not Available
9. PHYSICAL AND CHEMICAL PROPERTIES
PHYSICAL STATE: Liquid
ODOR: Pine
APPEARANCE: Opaque, White
pH: 5.0
PERCENT VOLATILE BY WEIGHT 93 :
VAPOR PRESSURE: Not Available
VAPOR DENSITY: Not Available
BOILING POINT Not Available
:
FREEZING/MELTING POINT Not Available
:
SOLUBILITY IN WATER: Dispersible
EVAPORATION RATE: Not Available
SPECIFIC GRAVITY: 0.99
VISCOSITY: Slightly Viscous
OCTANOL/WATER PARTITION COEFFICIENT Not Available
:
ODOR THRESHOLD: Not Available
10. STABILITY AND REACTIVITY
STABILITY (CONDITIONS TO AVOID):
Stable.
POLYMERIZATION:
Will not occur.
HAZARDOUS DECOMPOSITION:
None known.
INCOMPATIBLE MATERIALS:
Oxidizers (e.g., bleach) and strong bases (e.g., sodium hydroxide).
11. TOXICOLOGICAL INFORMATION
ACUTE DATA:
This product causes minimal skin irritation. Based on testing of a similar product, it may cause mild to moderate
eye irritation. The following data are available for product ingredients:
MSDS No: 4032 Page: 4 of 7
SPEEDTRACK Clean & Burnish Date Prepared: 06/07/2000
Date Revised: 06/07/2000
PRODUCT/INGREDIENT ORAL LD50 (rat) DERMAL LD50 (rabbit) INHALATION LC50 (rat)
Pine oil 3200 mg/kg 3000 mg/kg Not Available
Isopropylamine dodecylbenzenesulfonate 760 mg/kg Not Available Not Available
Nonyl phenol ethoxylate 2000鈥?5000 mg/kg 1000鈥?3000 mg/kg Not Available
SENSITIZATION DATA:
Pine oil has been found to cause weak skin sensitization in laboratory animals.
CHRONIC DATA:
No data available.
REPRODUCTIVE/TERATOGENIC DATA:
No data available.
CARCINOGENIC/MUTAGENIC DATA:
Not listed as carcinogenic by NTP IARC, or ACGIH or regulated as a carcinogen by OSHA.
,
SYNERGISTIC MATERIALS:
No data available.
12. ECOLOGICAL INFORMATION
No data available.
13. DISPOSAL CONSIDERATIONS
Disposal of this material should be in accordance with local, state or provincial and federal regulations. The
unused product, as manufactured, is a RCRA non-hazardous waste in accordance with 40 CFR 261. The
product has not been evaluated by the T oxicity Characteristic Leachate Procedure (TCLP). According to RCRA,
it is the responsibility of the waste generator to ensure proper disposal.
14. TRANSPORT INFORMATION
DOT/TDG HAZARDOUS MATERIAL DESCRIPTION: Not regulated
15. REGULATORY INFORMATION
Not meant to be all-inclusive鈥攕elected regulations represented.
UNITED STATES
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT)
311/312 HAZARD CATEGORIES: Under 40 CFR 370.2, this product meets the following hazard category: Im-
mediate.
313 REPORTABLE INGREDIENTS: Ingredients in this product are not currently subject to notification.
MSDS No: 4032 Page: 5 of 7
SPEEDTRACK Clean & Burnish Date Prepared: 06/07/2000
Date Revised: 06/07/2000
CERCLA (COMPREHENSIVE RESPONSE, COMPENSATION, AND LIABILITY ACT)
CERCLA REGULATORY: None of the ingredients in this product are reportable under CERCLA.
TSCA (TOXIC SUBSTANCE CONTROL ACT)
TSCA STATUS: This product complies with all TSCA inventory requirements.
MASSACHUSETTS, NEW JERSEY PENNSYLVANIA RIGHT-TO-KNOW:
,
INGREDIENT(S) CAS NO. STATE LISTING
Water 7732-18-5 Not Listed
Pine oil 8002-09-3 NJ
Hydrocarbon polymer, polymerized alpha alkenes 68527-08-2 Not Listed
Isopropylamine dodecylbenzenesulfonate 26264-05-1 Not Listed
Nonyl phenol ethoxylate 9016-45-9 Not Listed
NA - Not Applicable
CANADA
WHMIS (WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM):
Class D- Division 2B, eye irritant; potential skin sensitizer. This product has been classified in accordance
with the hazard criteria of the Canadian Controlled Products Regulations (CPR) and the MSDS contains all the
information required by the CPR.
16. OTHER INFORMATION
HMIS RATING NFPA RATING
FIRE
HEALTH - 2
FLAMMABILITY 0
0
REACTIVITY 0
HEALTH 1 0 REACTIVITY
PERSONAL PROTECTION -
鈥?
SPECIAL
MSDS STATUS
Revision #: 1
This MSDS replaces the June 29, 1997 MSDS. Any changes in information are as follows:
In Section 1
Prepared By Date Prepared [ ] Print CHEMTREC Phone Number
In Section 3
Signs & Symptoms - Skin (text)
MSDS No: 4032 Page: 6 of 7
SPEEDTRACK Clean & Burnish Date Prepared: 06/07/2000
Date Revised: 06/07/2000
In Section 9
(Group Field) for Vapor Pressure (Group Field) for Vapor Pressure Density Odor Threshold (text) (Group Field)
for Boiling Point (Group Field) for Freezing Point (Group Field) for Evaporation Rate (Group Field) for Viscosity
Coeff Oil/Water (text)
In Section 10
Hazardous Decomposition Products (text)
In Section 15
OSHA Hazard Comm. Rule (text) WHMIS Class
APPROVED BY: EH&S/Regulatory Affairs
APPROVAL DATE: 06/07/2000
The information on this data sheet represents our current data and best opinion as to the proper use in handling
of the product under normal foreseeable conditions. Any use of this product which is not in conformance with
this data sheet or product label, or which involves using the product in combination with any other product or
any other process is the responsibility of the user.
MSDS No: 4032 Page: 7 of 7
|