MSDS3731
CHEMSORB庐
Flammability 4 - Extreme
0
3 - High
0 0 UNIVERSAL SORBENT
Reactivity 2 - Moderate
Health
1 - Slight
0
0 - Insignificant
Special Hazards
MATERIAL SAFETY DATA SHEET
NFPA FIRE HAZARD SYMBOL
see NFPA 704 for detailed explanation
UPDATED: 9/01/04
I. PRODUCT IDENTIFICATION: CHEMSORB庐 UNIVERSAL SORBENT
MANUFACTURED BY: COMPLIANCE SAFETY, INC. TELEPHONE: 847-596-3010
1429 S. SHIELDS EMERGENCY: 847-596-3010
WAUKEGAN, IL 60085
II. PRODUCT INGREDIENTS / IDENTITY INFORMATION
INGREDIENT NAME CAS NUMBER PERCENT PEL AND TLV
EXPANDED AMORPHOUS SILICATE 93763-70-3 100% 15 mg/m3 TOTAL DUST - OSHA
5 mg/m3 RESPIRABLE DUST - OSHA
10 mg/m3 TOTAL DUST - ACGIH
THIS PRODUCT MAY CONTAIN
CRYSTALLINE SILICA: 14808-60-7 < 0.1% 0.1 mg/m3 RESPIRABLE QUARTZ
QUARTZ (TYPICAL ANALYSIS) (trace) OSHA & ACGIH TLV
III. PHYSICAL / CHEMICAL CHARACTERISTICS
APPEARANCE & ODOR Dry White Powder or Aggregate / No Odor
SPECIFIC GRAVITY (H20=1): 2.35 BOILING POINT: N/A
MELTING POINT: 1600-2000掳 F VAPOR PRESSURE: N/A
WATER SOLUBILITY (%): Negligible N/A
VAPOR DENSITY (AIR=1):
% VOLATILES BY VOLUME: None EVAPORATION RATE: N/A
IV. FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: NONFLAMMABLE
FLAMMABLE LIMITS: LEL - N/A % UEL - N/A %
EXTINGUISHING MEDIA N/A
SPECIAL FIRE FIGHTING PROCEDURES NONE
UNUSUAL FIRE & EXPLOSION HAZARD NONE
V. REACTIVITY DATA
STABILITY: STABLE
CONDITIONS TO AVOID: NONE IN DESIGNED USE.
INCOMPATIBILITY: HYDROFLUORIC ACID AND HYDRAZINE
CANNOT OCCUR
HAZARDOUS POLYMERIZATION:
HAZARDOUS DECOMPOSITION OR BY-PRODUCTS: MAY REACT WITH HYDROFLUORIC ACID AND HYDRAZINE
TO FORM A TOXIC GAS. HEAT IS GENERATED (150-175掳F)
UPON ABSORBTION OF HYDRAZINE.
VI. HEALTH HAZARD DATA
ROUTE(S) OF ENTRY: INHALATION? - YES SKIN? - NO INGESTION? - NO
HEALTH HAZARDS: ACUTE - Upper Respiratory Irritant, Excessive Inhalation of Any Dust May Overload Lungs
CHRONIC: None Known
SIGNS & SYMPTOMS OF EXPOSURE: Upper Respiratory and Eye Irritation
CARCINOGENICITY: NTP? - NO IARC Monographs? - NO OSHA Regulations? - NO
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Pre-Existing Upper Respiratory and Lung Diseases
EMERGENCY & FIRST AID PROCEDURES:
EYE CONTACT - RINSE THOROUGHLY WITH WATER
INHALATION - REMOVE TO FRESH AIR
CHEMSORB 庐 PAGE 2 0F 2
VII. SPILL OR LEAK PROCEDURES
PROCEDURES FOR SPILL / LEAK: VACUUM CLEAN OR SWEEP UP USING A DUST SUPPRESSANT SUCH AS WATER.
UNCONTAMINATED CHEMSORB 庐 MAY BE RE-USED
WASTE MANAGEMENT: NON-HAZARDOUS AS DEFINED BY RCRA (40 CFR part 261)
METHOD OF DISPOSAL - LANDFILL, INCINERATION, LAND BASED REMEDIATION
REPORTABLE QUANTITY - N/A
ALWAYS DISPOSE OF ANY MATERIAL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL LAWS
VIII. SPECIAL PROTECTION INFORMATION
EYE PROTECTION: GOGGLES OR SAFETY GLASSES ARE RECOMMENDED
GLOVES: NOT NORMALLY REQUIRED
RESPIRATOR: MSHA/NIOSH APPROVED RESPIRATOR
VENTILATION: Local Exhaust Ventilation May Be Required to Keep Dust Concentrations Below PEL/TLV
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: NONE
IX. SPECIAL PRECAUTIONS
STORAGE SEGREGATION HAZARD CLASSES: N/A
SPECIAL HANDLING / STORAGE: REPAIR BROKEN PILLOWS AND SOCKS IMMEDIATELY; AVOID CREATING DUST
SPECIAL WORKPLACE ENGINEERING CONTROLS: NOT NORMALLY REQUIRED
CHEMSORB 庐 IS A NATURALLY OCCURRING SUBSTANCE AND IS THEREFORE
INCLUDED, BUT NOT INDIVIDUALLY LISTED, IN THE TSCA INVENTORY
H O
HEALTH
HMIS RATINGS: 0 = MINIMAL HAZARD E = DUST RESPIRATOR
F O
FLAMMABILITY
R O
REACTIVITY
PERSONAL
E
PROTECTION
NC-L503R 漏1981 NCPA
As of the date of preparation of this document, the foregoing information is believed to be accurate and is provided in good
faith to comply with applicable federal and state law(s). However, no warranty or representation with respect to such
information is intended or given. User should independently assess and determine the suitability of this material for a
particular use or application.
|