ZEP MANUFACTURING COMPANY
Material Safety Data Sheet
Acuity Specialty Products Group, Inc.
P.O. BOX 2015
ATLANTA, GA 30301 and Safe Handling and Disposal Information
1- 877- I - BUY- ZEP
11/27/96
Issue Date
Supersedes
ZEP OIL ONLY RAPID-SORB PADS
Product Name
2299
Product No.
Oil Absorbent Pads
SECTION I - EMERGENCY CONTACTS
For MSDS Information:
Acuity Specialy Products Group, Inc.
Compliance Services 1-877-I-BUY-ZEP
For Medical Emergency:
INFOTRAC
(877) 541-2016 Toll Free - All Calls Recorded
For a Transportation Emergency:
Printing date: 09/10/03
CHEMTREC
(800) 424-9300 - All Calls Recorded
In the District of Columbia (202) 483-7616
SECTION II - HAZARDOUS INGREDIENTS
OSHA'S Hazard Communication Standard (29 CFR 1910. 1200) does not require the listing of any ingredient for this product.; TLV - ;
EFFECTS - ; % IN PROD -
@ -Reportable under the SARA 313 Toxic Release Inventory
SECTION III - HEALTH HAZARD DATA
SPECIAL NOTE: MSDS data pertains to the product as dispensed from the container. Adverse health effects would not be expected under
recommended conditions of use (diluted) so long as prescribed safety precautions are practiced.
ACUTE EFFECTS OF OVEREXPOSURE:
There are no known effects from acute overexposure to this product.
CHRONIC EFFECTS OF OVEREXPOSURE:
There are no known effects from chronic exposure to this product. None of the ingredients are listed as carcinogens by IARC, NTP, or
OSHA.
EST'D PEL/TLV: Not established
PRIMARY ROUTES OF ENTRY: N/A
HMIS CODES: HEALTH 0; FLAM 0; REACT 0; PERS. PROTECT N/A; CHRONIC HAZ NO
FIRST AID PROCEDURES:
SKIN: This route of exposure is not likely due to product nature.
EYES: This route of exposure is not likely due to product nature.
INHALE: This route of exposure is not likely due to product nature.
INGEST: This route of exposure is not likely due to product nature.
SECTION IV - SPECIAL PRECAUTION INFORMATION
PROTECTIVE CLOTHING: Wear protective equipment appropriate for the spilled material.
EYE PROTECTION: Wear protective equipment appropriate for the spilled material.
RESPIRATORY PROTECTION: Wear an approved respirator as required for spilled material.
VENTILATION: Use ventilation which is appropriate for spilled material.
SECTION V - PHYSICAL DATA
BOILING POINT (F) - N/A SPECIFIC GRAVITY -
VAPOR PRESSURE(mmHg) - N/A EVAPORATION RATE (=1) - N/A
VAPOR DENSITY(AIR-1) - N/A pH(CONCENTRATE) - N/A
SOLUBILITY IN WATER - N/A
pH(USE DILUTION OF) - N/A
VOC CONTENT (CONCENTRATE) -
APPERANCE AND ODOR - A SQUARE, WHITE PAD OF FIBROUS MATERIAL
SECTION VI - FIRE AND EXPLOSION DATA
FLASH POINT(F) (METHOD USED): N/A
FLAMMABLE LIMITS:LEL: N/A UEL: N/A
EXTINGUISHING MEDIA: Carbon dioxide, dry chemical, water fog, foam.
SPECIAL FIRE FIGHTING: Wear self-contained positive pres. breathing apparatus.
UNUSUAL FIRE HAZARDS: None
Page: 1/2
Product name: ZEP OIL ONLY RAPID-SORB PADS Material Safety Data Sheet
Product No. 2299
SECTION VII - REACTIVITY DATA
STABILITY: Stable
INCOMPATIBILITY(AVOID): Heat, open flame, spark, and oxidizing agents.
POLYMERIZATION: Will not occur.
HAZARDOUS DECOMPOSITION: None
SECTION VIII - SPILL AND DISPOSAL PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIALS IS RELEASED OR SPILLED:
Spills are not expected due to the nature of the product. Unused product is non-hazardous. Unusable or contaminated product should be
collected and stored in a suitable waste container.
WASTE DISPOSAL METHOD:
Unused product is not hazardous. Used (saturated) product may often be incinerated (burned) as a proper disposal option. However, final
disposal should be in accordance with local regulations governing the material absorbed.
RCRA HAZ WASTE NOS: N/A
SECTION IX - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN WHEN HANDLING AND STORING
Information contained herein is ONLY for the absorbent as delivered, and does not apply to the absorbed material. Keep out of the reach of
children.
SECTION X - REGULATORY INFORMATION
DOT PROPER SHIPPING NAME: COMPOUND, FLOOR SWEEPING, NOT DISINFECTANT
NOTE: DOT information applies to larger package sizes of affected products. For some products, DOT may require alternate names and
labeling in accordance with packaging group requirements.
DOT HAZARD CLASS: NA DOT PACKING GROUP:
DOT I.D. NUMBER: DOT LABEL/PLACARD:
EPA TSCA CHEMICAL INVENTORY - ALL INGREDIENTS ARE LISTED
EPA CWA 40CFR PART 117 SUBSTANCE(RQ IN A SINGLE CONTAINER): NONE
EPA CAA: N/A
MATERIAL SAFETY DATA SHEET
CHRONIC EFFECT: Adverse effects that are most likely to occur from re-
NOTICE
peated exposure over a long period of time.
Thank you for your interest in, and use of, this product. Acuity Specialty Prod- EST'D PEL/TLV: This estimated, time-weighted-average, exposure limit, de-
ucts Group is pleased to be of service to you by supplying this Material Safety veloped by using a formula provided by the ACGIH, pertains to airborne con-
Data Sheet for your files. Acuity Specialty Products Group is concerned for centrations from the product as a whole. This value should serve as guide for
your health and safety. This product and all others supplied by Acuity Specialty
providing safe workplace conditions to nearly all workers.
Products Group companies can be used safely with proper protective equipment
HMIS CODES: Hazardous Material Identification System - a rating system
and proper handling practices consistent with label instructions and the MSDS.
developed, by the National Paint and Coating Association for estimating the
Before using any this product, be sure to read the complete label and the Material
hazard potential of a chemical under normal workplace conditions. These risk
Safety Data Sheet.
estimates are indicated by a numerical rating given in each of three hazard areas
As a further word of caution, Acuity Specialty Products Group wishes to advise (Health/ Flammability/Reactivity) ranging from a low of zero to a high of 4.
that serious accidents have resulted from the misuse of 鈥渆mptied鈥? containers. The presence of a chronic hazard is indicated by a "YES". Consult HMIS train-
鈥淓mpty鈥? containers retain residue (liquid and/or vapor) and can be dangerous. ing guides for Personal Protection letter codes, which indicate necessary protec-
DO NOT pressurize, cut, weld, braze, solder, drill, grind or expose such con- tive equipment.
tainers to heat, flame, sparks, or other sources of ignition; they may explode or PRIMARY ROUTE OF ENTRY: The way one or more hazardous ingredients
develop harmful vapors and possibly cause injury or death. Clean empty con- may enter the body and cause a generalized systemic or specific-organ toxic effect.
tainers by triple rinsing with water or an appropriate solvent. Empty containers ING: Ingestion - A primary route of exposure through swallowing of mate-
must be sent to a drum reconditioner before reuse. rial.
INH: Inhalation - A primary route of exposure through breathing of vapors.
TERMS AND ABBREVIATIONS
SKIN: A primary route of exposure through contact with the skin.
Listed Alphabetically by Section
SECTION IV: SPECIAL PROTECTION INFORMATION
SECTION II: HAZARDOUS INGREDIENTS
Where respiratory protection is recommended, use only MSHA and NIOSH ap-
CAR: Carcinogen - A chemical listed by the National Toxicology Program
proved respirators and dust masks.
(NTP), the International Agency for Research on Cancer (IARC) or OSHA as a
MSHA: Mine Safety and Health Administration
definite or possible human cancer causing agent.
NIOSH: National Institute for Occupational Safety and Health.
CAS#: Chemical Abstract Services Registry Number - A universally accepted
numbering system for chemical substances. SECTION V: PHYSICAL DATA
CBL: Combustible - At temperatures between 100掳F and 200掳F chemical gives
EVAPORATION RATE: Refers to the rate of change from the liquid state to
off enough vapor to ignite if a source of ignition is present as tested with a
the vapor state at ambient temperature and pressure in comparison to a given
closed cup tester.
substance (e.g. water).
CNS: Central Nervous System depressant that reduces the activity of the brain
pH: A value representing the acidity or alkalinity of an aqueous solution
and spinal cord.
(Highly Acidic pH = 1; Neutral pH = 7; Highly Alkaline pH = 14)
COR: Corrosive - Causes irreversible injury to living tissue (e.g. burns).
VOC CONTENT: The percentage or amount in pounds per gallon of the prod-
DESIGNATIONS: Chemical and common names of hazardous ingredients.
uct that is regulated as a Volatile Organic Compound under the Clean Air Act
EIR: Eye Irritant Only - Causes reversible reddening and/or inflammation of eye tis-
of 1990 and various state jurisdictions.
sues.
SOLUBILITY IN WATER: A description of the ability of the product to dis-
EXPOSURE LIMITS: The time weighted average (TWA) airborne concentra-
solve in water.
tion at which most workers can be exposed without any expected adverse ef-
SECTION VII: REACTIVITY DATA
fects. Primary sources include ACGIH TLVs, and OSHA PELs.
ACGIH: American Conference of Governmental Industrial Hygienists HAZARDOUS DECOMPOSITION: Breakdown products expected to be
CEILING: "The concentration that should not be exceeded in the workplace produced upon product decomposition by extreme heat or fire.
during any part of the working exposure." Source, ACGIH INCOMPATIBILITY: Keep product away from listed substances or condi-
OSHA: Occupational Safety and Health Administration. tions to prevent hazardous reactions.
PEL: Permissible Exposure Limit - A set of time weighted average exposure POLYMERIZATION: Indicates the tendency of the product's molecules to com-
values, established by OSHA, for a normal 8-hour day and a 40-hour work- bine with themselves in a chemical reaction releasing excess pressure and heat.
week. STABILITY: Indicates the susceptibility of the product to decompose sponta-
PPM: Parts per million - unit of measure for exposure limits. neously and dangerously.
(S) SKIN: Skin contact with substance can contribute to overall exposure.
SECTION VIII: SPILL AND DISPOSAL PROCEDURES
STEL: Short Term Exposure Limit - Maximum concentration for a continu-
RCRA WASTE NOs: RCRA (Resource Conservation and Recovery Act)
ous 15-minute exposure period.
waste codes (40 CFR 261) applicable to the disposal of spilled or unusable
TLV: Threshold Limit Value - A set of time weighted average exposure lim-
product from the original container.
its, established by the ACGIH, for a normal 8-hour day and a 40-hour work-
week. SECTION X: TRANSPORTATION DATA
FBL: Flammable - At temperatures under 100掳F, chemical gives off enough va-
CWA: Clean Water Act - Federal law that regulates chemical releases to bodies
pors to ignite if a source of ignition is present as tested with a closed cup tester.
of water.
HAZARDOUS INGREDIENTS: Chemical substances that are determined to
RQ: Reportable Quantity - The amount of the specific ingredient that, when
be potential health or physical hazards based on the criteria established in the
spilled to the ground and, can enter a storm sewer or natural watershed, must be
OSHA Hazard Communication Standard - 29 CFR 1910.1200
reported to the National Response Center, and other regulatory agencies.
HTX: Highly toxic - the probable lethal dose for a 70 kg (150 lb.) man, which
TSCA: Toxic Substances Control Act - A federal law requiring all commercial
may be approximated as less than 6 teaspoons (2 tablespoons)
chemical substances to appear on an inventory maintained by the EPA.
IRR: Irritant - Causes reversible effects in living tissues (e.g. inflammation) -
DISCLAIMER
primarily skin and eyes.
N/A: Not Applicable - Category is not appropriate for this product. All statements, technical information, and recommendations contained herein
N/D: Not Determined - Insufficient information to make a determination for this are based on available scientific tests or data that we believe to be reliable. The
item. accuracy and completeness of such data are not warranted or guaranteed. We
RTECS#: Registry of Toxic Effects of Chemical Substances - an unreviewed cannot anticipate all conditions under which this information and our products,
or the products of other manufacturers in combination with our products, may
listing of published toxicology data on chemical substances.
be used. Acuity Specialty Products Group assumes no liability or responsibility
SARA: Superfund Amendment and Reauthorization Act - Section 313 designates
for loss or damage resulting from the improper use or handling of our products,
certain chemicals for possible reporting for the Toxic Chemical Release Inventory.
from incompatible product combinations, or from the failure to follow instruc-
SEN: Sensitizer - Causes allergic reaction after repeated exposure.
tions, warnings, and advisories in the product label and Material Safety Data
TOX: Toxic - The probable lethal dose for a 70 kg (150 kg) man is one ounce
Sheet
(2 tablespoons) or more.
SECTION III: HEALTH HAZARD DATA (rev 06/02)
ACUTE EFFECT: An adverse effect on the human body from a single expo-
sure with symptoms developing almost immediately after exposure or within a
relatively short time.
|