LORD CORP -- CHEMGLAZE A170
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BXWVN
MSDS NAME: CHEMGLAZE A170
Responsible Party
Name: LORD CORP
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514
Info Phone: 814-868-3611
Emergency Phone Number: 814-763-2345
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: LORD CORP
Address: 2000 W GRANDVIEW BLVD
Box: 10038
City: ERIE PA 16514
Phone: 814-868-3611
Name: LORD CORPORATION, CHEMICAL PRODUCTS DIVISION
Address: 2000 WEST GRANDVIEW BLVD
City: ERIE PA 16514-0038
Phone: 814-868-3611
=======================================================
Ingredients
=======================================================
Cas: 5124-30-1
RTECS #: NQ9250000
Name: ISOCYANIC ACID, METHYLENEDI-4,1-CYCLOHEXYLENE ESTER; (METHYLENE
BIS(4-CYCLOHEXYLISOCYANATE))
% Wt: <1
OSHA PEL: C 0.01 PPM
ACGIH TLV: 0.005 PPM
------------------------------
Cas: 4098-71-9
RTECS #: NQ9370000
Name: ISOCYANIC ACID, METHYLENE(3,5,5-TRIMETHYL-3,1-CYCLOHEXYLENE) ESTER;
(ISOPHORONE DIISOCYANATE) (SARA 302)
% Wt: <2
ACGIH TLV: 0.005 PPM
------------------------------
Cas: 67-63-0
RTECS #: NT8050000
Name: ISOPROPYL ALCOHOL (SARA 313)
OSHA PEL: 400 PPM
ACGIH TLV: 400 PPM/500 STEL
------------------------------
Cas: 88917-22-0
Name: DIPROPYLENE GLYCOL METHYL ETHER ACETATE
% Wt: <5
OSHA PEL: 100 PPM ,S
ACGIH TLV: 100 PPM,S
------------------------------
Cas: 1330-20-7
RTECS #: ZE2100000
Name: XYLENE (SARA 313) (CERCLA)
% Wt: <25
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM/150 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Cas: 108-65-6
RTECS #: AI8295000
Name: ACETIC ACID, 2-METHOXY-1-METHYLETHYL ESTER; (1-METHOXY-2-PROPYL ACETATE)
% Wt: <30
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
------------------------------
Cas: 100-41-4
RTECS #: DA0700000
Name: BENZENE, ETHYL-; (ETHYL BENZENE) (SARA 313)
% Wt: <10
OSHA PEL: 100 PPM
ACGIH TLV: 100 PPM/125 STEL
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: TOLUENE APPEARS ON NAVY LIST OF OCCUP CHEM REPROD HAZS.
SEEK CONSULTATION FROM APPROP HLTH PROFESSIONALS CONCERNING LATEST HAZ LIST
INFO & SAFE HNDLG & EXPOS INFO (FP N). ACUTE:EYE:CAUSES IRRIT. SKIN:
MAY BE ABSORB THRU SKIN IN HARMFUL AMTS. MAY CAUSE SKIN SENSITIZ. MAY CAUSE
DERM. CAUSES IRRIT. INHAL: POSS IRRIT OF RESP SYS CAN OCCUR CAUSING VARIETY
OF SYMPS SUCH AS DRYNESS OF THROAT, TIGHTNESS OF CHEST, & SHORTNESS OF
BREATH. ALLERGIC CNDTNS CAN OCCUR IN CERTAIN INDIVIDUALS W/HIGH SENSITIVITY
TO ISOCYANATES; THIS MAY RSLT IN ASTHMA-LIKE SYMPS. MAY CAUSE CNS DEPRESS
CHARACT BY FOLLOWING PROGRE SSIVE STEPS: HDCH, (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ: DIZZ, STAGG GAIT, CONFUSN,
UNCON/COMA. MAY CAUSE RESP SENSITIZ. MAY CAUSE LUNG DMG. INGEST:HARMFUL IF
SWALLOWED. INGEST IS NOT EXPECTED RTE OF ENTRY IN INDUST/COMMERCIAL USES.
CHRONIC:MAY CA USE LIVER/KIDNEY DMG. PRTD/PRLNGD SOLV OVEREXP MAY RSLT IN
PERM CNS DMG. MAY CAUSE LONG-TERM LUNG DMG. MAY AFFECT GI SYS, BLOOD &
BLOOD-FORMING ORGANS. CHRONIC:SKIN CONT MAY CAUSE DERM.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: EYE:FLUSH IMMED W/LG AMTS OF H*2O FOR @ LEAST 15 MINS HOLDING
EYELIDS OPEN WHILE FLUSHING. GET PROMPT MED ATTN. SKIN:FLUSH CONTAMD SKIN
W/LG AMTS OF WATER WHILE REMOVING CONTAMD CLTHG. WASH AFFECTED S KIN AREAS
W/SOAP & WATER. GET MED ATTN IF SYMPS OCCUR. INHAL:MOVE PERSON TO FRESH
AIR. RESTORE & SUPPORT CONTINUED BRTHG. IF BRTHG IS DFCLT, GIVE OXYG. GET
IMMED MED ATTN. INGEST:IF SWALLOWED, DO NOT INDUCE VOMIT. GIVE VICTIM 1-2
GLASSES OF WATER/MILK. CALL PHYS/POIS CTL CTR IMMED FOR FURTHER INSTRUCTION.
NEVER GIVE ANYTHING BY MOUTH TO UNCONSCIOUS PERSON.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: KEEP NON-ESSNTL PERS SAFE DIST AWAY FROM SPILL AREA.
REMOVE ALL SOURCES OF IGNIT (FLAME, HOT SURFS, & ELEC, STATIC/FRICTIONAL
SPRAKS). AVOID BRTHG VAPS. USE NIOSH/MSHA APPRVD SCBA. NOTIFY APPROP AUTH IF
NEC. CNTN & REMOVE W/INERT ABSORB MATL & NON-SPK TOOLS. AVOID CONT.
BEFORE CLEANUP, REFER TO HAZ CAUTION INFO IN OTHER SECTIONS OF MSDS FORM.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL SHOULD BE DONE IN ACCORDANCE WITH FEDERAL
(40CFR PART 261), STATE & LOCAL ENVIRONMENTAL CONTROL REGS. IF WASTE IS
DETERM TO BE HAZ, USE LICENSED HAZ WASTE TRANSPORTER & DISPOSAL FACILITY.
Handling And Storage Precautions: KEEP CLOSURE TIGHT & CNTNR UPRIGHT TO
PVNT LEAKAGE. GROUND & BOND CNTNRS WHEN TRANSFERRING MATL. AVOID SKIN
& EYE CONT. WASH THORO AFTER HANDLING.
Other Precautions: AVOID BRTHG VAP/SPRAY MISTS. DO NOT HNDL UNTIL ALL SFTY PREC
ARE READ & UNDERSTOOD. EMPTY CNTNRS SHOULD NOT BE REUSED. USE W/ADEQ
VENT. BECAUSE EMTPY CNTNRS MAY RETAIN PROD RESIDUE & FLAM VAPS, KEEP A
WAY FROM HEAT, SPK & FLAME; DO NO CUT, PUNCTURE/WELD ON/NEAR EMPTY CNTNR.
DO NOT SMOKE WHERE PROD IS USED OR (SUPDAT)
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 81.0F,27.2C
Lower Limits: 1.0%
Upper Limits: 13.1%
Extinguishing Media: CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures: NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER SPRAY MAY BE INEFTIVE. IF WATER IS USED, FOG NOZZ ARE PREF. DURING
FIRE, IRRITATING &/OR TOX GASES & PARTICULATE MAY BE GENERATED BY
THERM DECOMP /COMBUST.
Unusual Fire/Explosion Hazard: FLAM LIQ & VAP. KEEP CNTNRS TIGHTLY CLSD.
ISOLATE FROM HEAT, ELEC EQUIP, SPARKS, OPEN FLAME, & OTHER SOURCES OF
IGNIT. CLSD CNTNRS MAY RUPTURE WHEN EXPOS TO EXTREME HEAT. USE WATER SPRAY TO
KEEP FIRE EXPOS CNTNRS COOL.
=======================================================
Control Measures
=======================================================
Respiratory Protection: PROD CNTNS ISOCYANATES WHICH HAVE POOR ODOR WARNING
PROPERTIES. IF OCCUP EXPOS LIMS ARE EXCEEDED, NIOSH/MSHA APPRVD SUPPLIED-AIR
RESP IS REQD. OBSERVE OSHA REGS (29CFR 1910.134) FOR RESPIRATOR USE.
Ventilation: SUFFICIENT VENT IN PATTERN & VOL SHOULD BE PROVIDED IN ORDER
TO MAINTAIN AIR CONTAMINANT LEVS BELOW REC EXPOS LIMS. CAUTION:SOLV VAPS ARE
HVR/AIR & (SUPDAT)
Protective Gloves: NEOPRENE GLOVES.
Eye Protection: ANSI APPRVD CHEM WORK GOGGLES (FP N).
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA (FP N). DISPOSABLE/IMPERVIOUS CLTHG IF WORK CLTHG CONTAM IS
LIKELY. REMOVE & WASH CONTAMD CLTHG BEFORE REUSE. WHEN SPRAY- (OTHER INFO)
Work Hygienic Practices: WASH HANDS BEFORE EATING, SMKNG/USING TOILET FACILITY.
DO NOT SMOKE IN ANY CHEM HNDLG/STOR AREA. FOOD/BEVERAGES SHOULD NOT BE
CONSUMED ANYWHERE PROD IS HNDLD/STORED. WASH THORO AFTER HANDLING.
Supplemental Safety and Health: OTHER PRECS: STORED. DO NOT STORE/USE NEAR
HEAT, SPK/OPEN FLAME. REFER TO OSHA 29CFR 1910.106 "FLAM & COMBUST LIQS"
FOR SPECIFIC STOR REQS. STORE ONLY IN WELL-VENT AREAS. DO NOT PUNCTURE,
DRAG/SLIDE C NTNR. KEEP CNTNR CLSD WHEN NOT IN USE. VENT: COLLECT IN LOWER
LEVS OF WORK AREA. SUFFICIENT VENT (USING (OTHER INFO)
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >277F,>136C
Vapor Density: HVR/AIR
Spec Gravity: 0.98
VOC Grams/Liter: 717
Evaporation Rate & Reference: SLOWER THAN ETHER
Solubility in Water: INSOLUBLE
Appearance and Odor: BLACK LIQUID, SOLVENT ODOR.
Percent Volatiles by Volume: 79.6
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: HIGH TEMPERATURES. SOURCES OF IGNITION.
Materials To Avoid: AMINES, ACIDS, WATER, HYDROXYL, OR ACTIVE HYDROGEN
COMPOUNDS.
Hazardous Decomposition Products: MONOMERIC ISOCYANATE, TRACES OF HYDROGEN
CYANIDE, NITROGEN DIOXIDE. CARBON MONOXIDE, CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT.
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: SUPDAT: EXPLO- PROOF EQUIP) SHOULD BE PROVIDED TO PVNT FLAM
VAP/AIR MIXTURES FROM ACCUMULATING. OTHER PROT EQUIP: APPLYING MATL &
EXPOS TO OVERSPRAY MAY OCCUR, IMPERVIOUS PROT CLTHG, INCLDG HEAD COVER ING
& FSHLD, GLOVES & OVERSHOES ARE RECOMMENDED.
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: CHEMGLAZE A170
Assigned IND: Y
Company: LORD CORP
Street: 2000 W GRANDVIEW BLVD
PO Box: 10038
City: ERIE PA
Zipcode: 16514
Health Emergency Phone: 814-763-2345
Label Required IND: Y
Date Of Label Review: 05/24/1995
Status Code: C
Label Date: 05/24/1995
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Severe
Reactivity Hazard: None
Hazard And Precautions: FLAM. AVOID H*2O.ACUTE:EYE:CAUSES IRRIT. SKIN:MAY BE
ABSORB THRU SKIN IN HARMFUL AMTS. MAY CAUSE DERM. INHAL:POSS IRRIT OF RESP
SYS CAN OCCUR CAUSING VARIETY OF SYMPS AS DRYNESS OF THROAT, TIGHTNESS O F
CHEST, & SHORTNESS OF BREATH. ALLERGIC CNDTNS CAN OCCUR IN CERTAIN
INDIVIDUALS W/HIGH SENSITIVITY TO ISOCYANATES; MAY RSLT IN ASTHMA-LIKE SYMPS.
MAY CAUSE CNS DEPRESS CHARACT BY FOLLOWING PROGRESSIV E STEPS:HDCH, DIZZ,
STAGG GAIT, CONFUSN, UNCON/COMA. MAY CAUSE LUNG DMG. CHRONIC:TOLUENE APPEARS
ON NAVY LIST OF OCCUP REPROD HAZ LIST (FP N). MAY CAUSE LIVER/KIDNEY DMG.
PERM CNS DMG, LUNG DMG, DERM. MAY CAUSE SKIN AND RESPIRATORY SENSITIZATION.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|