UNITED ASPHALT CO -- DEL VAL ROOF CEMENT
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CDNGS
MSDS NAME: DEL VAL ROOF CEMENT
Responsible Party
Name: UNITED ASPHALT CO
Box: 91
City: CEDAR BROOK NJ 08018
Info Phone: 609-561-7474
Emergency Phone Number: 800-424-9300 (CHEMTREC)
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: UNITED ASPHALT CO
Address: UNKNOWN
Box: 91
City: CEDAR BROOK NJ 08018
Phone: 609-561-7474
=======================================================
Ingredients
=======================================================
Cas: 64741-46-2
Name: PETROLEUM DISTILLATE
% Wt: 20
OSHA PEL: N/K (FP N)
ACGIH TLV: 100 PPM (MFR)
-----------------------------
Cas: 1332-21-4
RTECS #: CI6425000
Name: ASBESTOS (FRIABLE); (ENCAPSULATED ASBESTOS) (SARA 313) (CERCLA)
% Wt: 8.55
OSHA PEL: 0.2 FIBERS/CC
ACGIH TLV: 0.2 FIBER/CC
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Name: HYGIENE PRACT:& WATER AFTER CONTACT.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: YES
Effects of Exposure: OVEREXPOSURE TO VAPORS CAUSES EYE IRRITATION, BLURRED
VISION, DIZZINESS, HEADACHES AND UNCONSCIOUSNESS. PROLONGED OR REPEATED SKIN
CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS. SWALLOW ING CAN
CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA. ASPIRATION
OF MATERIAL INTO (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: ASBESTOS:IARC MONOGRAPHS, SUPP, VOL 7, PG 106,
1987:GRP 1. NTP 7TH ANNUAL RPT ON CARCINS, 1994:KNOWN TO BE (SUPP DATA)
Signs And Symptions Of Overexposure: HLTH HAZ:LUNGS CAN CAUSE CHEMICAL
PNEUMONITIS WHICH CAN BE FATAL. CONTAINS ENCAPSULATED ASBESTOS. ENCAPSULATION
PREVENTS GENERATION OF AIRBORNE FIBERS. NO RISK OF HAZARD FROM ENCAPSULATED
ASBESTOS HAS BEEN ESTABLISHED.
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE FROM VAPOR IMMEDIATELY. IF OVERDOSED, CALL MD. IF
BREATHING STOPPED OR IRREGULAR, START RESUSCITATION OR ADMINISTER OXYGEN, AS
NEEDED. EYES:FLUSH W/LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES, LIFTING
UPPER & LOWER LIDS OCCASIONALLY. GET MEDICAL ATTN. SKIN:REMOVE CONTAM
CLOTHES & WASH W/WATERLESS HANDCLEANER OR SOAP & WATER. INGEST:DO NOT
INDUCE VOMITING. GET MEDICAL ATTENTION.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: REMOVE SOURCES OF IGNIT. KEEP PEOPLE AWAY. RECOVER
FREE LIQ. ADD ABSORB (SAND, EARTH, SAWDUST, ETC) TO SPILL AREA. AVOID BRTHG
VAPS. VENT CONFINED SPACES. OPEN ALL WINDOWS & DOORS. KEEP PRODS OUT OF S
EWERS & WATERCOURSES BY DIKING/IMPOUNDING (SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). ASSURE CONFORMITY W/APPLICABLE DISPOSAL REGULATIONS.
Handling And Storage Precautions: KEEP CONTAINERS CLOSED WHEN NOT IN USE. DO
NOT HANDLE OR STORE NEAR HEAT, SPARKS, FLAME OR STRONG OXIDANTS. ADEQUATE
VENTILATION REQUIRED.
Other Precautions: AVOID BREATHING VAPORS. AVOID PROLONGED OR REPEATED CONTACT
W/SKIN.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: SCC
Flash Point Text: 125F,52C
Lower Limits: 0.4%
Upper Limits: 7.5%
Extinguishing Media: FOAM, CO*2, DRY CHEMICAL, WATER FOG, WATER SPRAY.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: DO NOT MIX/STORE W/STRONG OXIDANTS LIKE LIQ
CHLORINE/OXYG. KEEP CNTNRS TIGHTLY CLSD. CLSD CNTNRS MAY EXPLODE WHEN EXPOS
TO EXTREME HEAT. APPLICATIONS TO(SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED HYDROCARBON VAPOR CANISTER OR
SUPPLIED AIR RESPIRATORY PROTECTION IN CONFINED OR ENCLOSED SPACES - IF
NEEDED.
Ventilation: LOCAL EXHAUST:FACE VELOCITY 60 FPM. USE ONLY W/ADEQUATE
VENTILATION.
Protective Gloves: CHEMICAL-RESISTANT GLOVES.
Eye Protection: ANSI APPROVED CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment: ANSI APPRVD EYE WASH FOUNTAIN & DELUGE SHOWER (FP
N). USE CHEM-RESIST APRON/OTHER CLTHG TO AVOID RPTD/PRLNG SKIN CONT.
Work Hygienic Practices: REMOVE CONTAM CLTHG & LAUNDER BEFORE REUSE. REMOVE
CONTAM SHOES & THORO DRY BEFORE REUSE. WASH SKIN THORO W/SOAP
Supplemental Safety and Health: EXPLO HAZ:HOT SURFS REQS SPECIAL PRECS. DURING
EMER CNDTNS, OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
IMMED APPARENT. OBTAIN MED ATTN. EXPLAN OF CARCIN:CARCIN. OSHA REGULATED:29
CFR 1910.1001. HUMAN:LUNG TUMORS. SPILL PROC:ALSO ADVISE AUTHS. EYE
PROT:& FULL LENGTH FCSHLD (FP N).
=======================================================
Physical/Chemical Properties
=======================================================
B.P. Text: >350F,>177C
Vapor Pres: 1-10 @100F
Vapor Density: HVR/AIR
Spec Gravity: 1.16 (FP N)
Evaporation Rate & Reference: SLOWER THAN BUTYL ACETATE
Solubility in Water: NONE
Appearance and Odor: BLACK FLUID; ODOR CHARACTERISTIC OF PETROLEUM SOLVENT.
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: STRONG OXIDANTS.
Hazardous Decomposition Products: FUMES, SMOKE & CO*2. CARBON MONOXIDE IF
COMBUSTION IS INCOMPLETE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: DEL VAL ROOF CEMENT
Company: UNITED ASPHALT CO
Street: UNKNOWN
PO Box: 91
City: CEDAR BROOK NJ
Zipcode: 08018
Health Emergency Phone: 800-424-9300 (CHEMTREC)
Label Required IND: Y
Date Of Label Review: 04/15/1997
Status Code: C
Label Date: 04/15/1997
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: WARNING
Respiratory Protection IND: YES
Health Hazard: Moderate
Contact Hazard: Moderate
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: ACUTE:OVEREXPOSURE TO VAPORS CAUSES EYE IRRITATION,
BLURRED VISION, DIZZINESS, HEADACHES AND UNCONSCIOUSNESS. PROLONGED OR
REPEATED SKIN CONTACT CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS. S
WALLOWING CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND
DIARRHEA. ASPIRATION OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS
WHICH CAN BE FATAL. CHRONIC:CANCER HAZARD. CONTAINS ASB ESTOS, WHICH IS
LISTED AS A HUMAN LUNG CARCINOGEN (FP N).
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|