DURON INC -- WALL KOTE EGGSHELL ENAMEL PAINT, NEUTRAL BASE
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CDZSH
MSDS NAME: WALL KOTE EGGSHELL ENAMEL PAINT, NEUTRAL BASE 45-000
Responsible Party
Name: DURON INC
Address: 10406 TUCKER ST
City: BELTSVILLE MD 20705-2297
Info Phone: 301-937-4700
Emergency Phone Number: 301-937-4600; 800-228-5635
Preparer's Name: THOMAS BRICE
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: DURON INC
Address: 10406 TUCKER ST
City: BELTSVILLE MD 20705-2297
Phone: 301-937-4600
Name: DURON INC AMERICAN DIV
Address: 10406 TUCKER ST
City: BELTSVILLE MD 20705-2201
Phone: UNKNOWN
=======================================================
Ingredients
=======================================================
Cas: 1317-65-3
RTECS #: EV9580000
Name: CALCIUM CARBONATE. %:6.5-33.9.
% Wt: <33.9
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 1332-58-7
RTECS #: GF1670500
Name: CLAY (KAOLIN); (KAOLIN)
% Wt: 4-10.2
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 2 MG/M3 TDUST
------------------------------
Cas: 8052-41-3
RTECS #: WJ8925000
Name: STODDARD SOLVENT. %:24.5-34.6.
% Wt: <34.6
OSHA PEL: 500 PPM
ACGIH TLV: 100 PPM
------------------------------
Name: SYNTHETIC RESIN; (SYNTHETIC RESIN COMPLEX). %:25.1-25.7.
% Wt: <25.7
OSHA PEL: N/K (FP N)
ACGIH TLV: N/K (FP N)
-----------------------------
Cas: 13463-67-7
RTECS #: XR2275000
Name: TITANIUM OXIDE; (TITANIUM DIOXIDE)
% Wt: 0-25
OSHA PEL: 15 MG/M3 TDUST
ACGIH TLV: 10 MG/M3 TDUST
------------------------------
Cas: 14808-60-7
RTECS #: VV7330000
Name: SILICA, CRYSTALLINE - QUARTZ; (CRYSTALLINE SILICA (CS))
OSHA PEL: SEE TABLE Z-3
ACGIH TLV: 0.1 MG/M3 RDUST
------------------------------
RTECS #: 9999999VO
Name: VOLATILE ORGANIC COMPOUNDS: 3.65 LBS/GAL.
-----------------------------
Name: SUPDAT:USED FOR COOLING. IF LEAK/SPILL HAS IGNITED, USE WATER SPRAY TO
DISPERSE VAPS & TO PROT MEN ATTEMPTING TO
-----------------------------
Name: ING 8:STOP LEAK. MINIMIZE BREATHING GASES, VAPORS, FUMES OR DECOMPOSITION
PRODUCTS.
-----------------------------
Name: EFTS OF OVEREXP:SHOULD BE MIN. LAB ANIMALS STUDIES HAVE SHOWN THAT PRLNG
& RPTD INHAL TO LIGHT HYDROCARBONS VAPS
-----------------------------
Name: ING 10:IN SAME NAPHTHA BOILING RANGE AS THIS PROD CAN PRDCE ADVERSE
KIDNEY EFTS IN MALE RATS. IN NUMBER OF HUMAN
-----------------------------
Name: ING 11:STUDIES, THERE WAS NO CLINICAL EVID OF SUCH EFTS AS NORMAL OCCUP
LEVELS. CRYSTALLINE SILICA IS CONSIDERED
-----------------------------
Name: ING 12:HAZ BY INHAL; & CAN ALSO CAUSE SILICOSIS, A NONCANCEROUS LUNG
DISEASE. PIGMENT DUST WOULD NOT NORMALLY BE
-----------------------------
Name: ING 13:ENCOUNTERED WHEN HNDLG PACKAGED PAINT PROD CNTNG PRE-WETTED
PIGMENT. PROPER NIOSH APPRVD RESP PROT SHOULD
-----------------------------
Name: ING 14:BE WORN WHEN SANDING DRIED PAINT FILM DUE TO PRESENCE OF
CRYSTALLINE SILICA. ING 5:IN INHAL STUDY, MFR
-----------------------------
Name: ING 15:FOUND EVID OF LUNG CANCER (MALIGNANT TUMORS) IN 1 OUT OF 77 MALE
RATS & 13 OUT OF 74 FEMALE RATS AFTER
-----------------------------
Name: ING 16:THEY WERE EXPOSED TO 250 MG/M3 RESPIRABLE DUST FOR A TWO YEAR
PERIOD.
-----------------------------
Name: SPILL PROC:ASSURE CONFORMITY W/APPLIC GOVT REGS. CONTINUE TO OBSERVE
PRECS FOR VOLAT, COMBUST VAPS FROM ABSORBED MATL.
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: LD50:(ORAL,RAT) >5 G/KG OF BODY WT.
Route Of Entry Inds - Inhalation: YES
Skin: YES
Ingestion: YES
Carcinogenicity Inds - NTP: YES
IARC: YES
OSHA: NO
Effects of Exposure: INHAL:EXCESS INHAL OF VAPS CAN CAUSE EYE, NASAL & RESP
IRRIT, DIZZ, WEAK, FATG, NAUS, HDCH. HIGH VAP CONCS MAY RSLT IN CNS DEPRESS;
ARE ANESTH & MAY HAVE OTHER CNS EFTS INCL DEATH. SKIN:PRLNG/RPTD CON T
CAN CAUSE MOD IRRIT, DEFAT &/OR DERM.EYES:CAN CAUSE SEV IRRIT, REDNESS,
TEARING, BLURRED VISION. (EFTS OF OVEREXP)
Explanation Of Carcinogenicity: SILICA, CRYSTALLINE-QUARTZ:IARC MONO, SUPP, VOL
7, PG 341, 1987:GRP 2A. NTP 7TH ANNUAL REPORT ON CARCINS, 1994: (SUPDAT)
Signs And Symptions Of Overexposure: HLTH HAZ:INGEST:CAN CAUSE GI IRRIT, NAUS,
VOMIT & DIARR. ASPIR OF MATL INTO LUNGS CAN CAUSE CHEM PNEUM WHICH CAN BE
FATAL. TOX INFO:HLTH STUDIES HAVE SHOWN THAT MANY PETRO HYDROCARBONS &
SYNTHETIC LUB RICANTS POSE POTNTL HUMAN HLTH RISKS WHICH MAY VARY FROM PERS
TO PERS. AS PREC, EXPOS TO LIQS, VAPS, MISTS/FUMES
Medical Cond Aggravated By Exposure: NONE SPECIFIED BY MANUFACTURER.
First Aid: INHAL:REMOVE VICTIM TO FRESH AIR & PROVIDE OXYG IF BRTHG IS
DFCLT. IF BRTHG STOPS, BEGIN ARTF RESP & SEEK IMMED MED ATTN. SKIN:REMOVE
CONTAM CLTHG/SHOES. FLUSH W/WATER. FOLLOW BY WASHING W/SOAP & WATE R. IF
IRRIT OCCURS, GET MED ATTN. DO NOT REUSE CLTHG UNTIL CLEANED. EYES:FLUSH
W/CLEAR WATER FOR AT LST 15 MINS/UNTIL IRRIT SUBSIDES. IF IRRIT PERSISTS,
CALL MD. INGEST:DO NOT INDUCE VOMIT. IF(SUPDAT)
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: ELIM ALL IGNIT SOURCES (FLARES, FLAMES INCL PILOT
LIGHTS, ELEC SPKS). RECOVER FREE PROD. ADD SAND, EARTH/OTHER SUITABLE ABSORB
TO SPILL AREA. MIN SKIN CONT. VENT CONFINED SPACES. KEEP PROD OUT OF SEWE RS
& WATERCOURSES BY DIKING/IMPOUNDING.
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISPOSE OF PRODUCT I/A/W APPLICABLE LOCAL, COUNTY,
STATE & FEDERAL REGULATIONS.
Handling And Storage Precautions: COMBUSTIBLE LIQUID.
Other Precautions: DO NOT EAT, DRINK OR SMOKE WHILE USING THIS PRODUCT.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Flash Point Method: TCC
Flash Point Text: 104F,40C
Lower Limits: 0.9%
Upper Limits: 6%
Extinguishing Media: USE DRY CHEMICAL, FOAM OR CARBON DIOXIDE. WATER MAY BE
INEFT, BUT WATER SHOULD BE USED TO KEEP FIRE-EXPOS CNTNRS COOL.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
WATER MAY BE UNSUITABLE AS EXTING MEDIA, BUT HELPFUL IN KEEPING ADJACENT
CNTNRS COOL. AVOID SPREADING(SUPP DATA)
Unusual Fire/Explosion Hazard: VAPS ARE HVR/AIR & MAY TRAVEL ALONG
GROUND/BE MOVED BY VENT & IGNITED BY HEAT, PILOT LIGHTS, OTHER FLAME
& IGNIT SOURCES AT LOCATIONS DIST FROM HNDLG (SUPDAT)
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE OF RESPIRATORY PROTECTION DEPENDS ON VAPOR
CONCENTRATION ABOVE TIME WEIGHTED TLV'S: USE NIOSH APPROVED RESPIRATOR.
Ventilation: PROVIDE SUFFICIENT MECHANICAL (GENERAL) &/OR LOCAL EXHAUST
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV.
Protective Gloves: CHEM RESISTANT PLASTIC/RUBBER GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGS &(SUPDAT)
Other Protective Equipment: EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET ANSI
DESIGN CRITERIA (FP N). CHEMICAL RESISTANT PLASTIC/RUBBER SKIN PROT.
Work Hygienic Practices: THOROUGHLY WASH HANDS BEFORE EATING OR SMOKING.
Supplemental Safety and Health: EXPLO HAZ:POINT. NEVER USE WELDING/CUTTING
TORCH ON/NEAR CNTNR (EVEN EMPTY) BECAUSE VAPS MAY IGNITE. EXPLAN OF
CARCIN:ANTIC TO BE CARCIN. FIRST AID PROC:VOMIT OCCURS SPONT, KEEP HEAD BELOW
HIPS TO PVN T ASPIR OF LIQ INTO LUNGS. GET MED ATTN. EYE PROT:FULL LGTH
FCSHLD (FP N). FIRE FIGHT PROC:BURNING LIQ W/WATER
=======================================================
Physical/Chemical Properties
=======================================================
Vapor Pres: 2 @ 20F
Vapor Density: 4.9
Spec Gravity: 1.18
Evaporation Rate & Reference: 0.1 (BUTYL ACETATE=1)
Solubility in Water: NEGLIGIBLE;
Appearance and Odor: VISCOUS LIQUID; HYDROCARBON ODOR.
Percent Volatiles by Volume: 55.5
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Stability Condition To Avoid: NONE SPECIFIED BY MANUFACTURER.
Materials To Avoid: PRODUCT IS INCOMPATIBLE W/STRONG OXIDIZING AGENTS, STRONG
ACIDS OR BASES & SELECTED AMINES.
Hazardous Decomposition Products: THERMAL DECOMPOSITION IN PRESENCE OF AIR MAY
YIELD CARBON MONOXIDE &/OR CARBON DIOXIDE.
Hazardous Polymerization Indicator: NO
Conditions To Avoid Polymerization: NOT RELEVANT
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: WALL KOTE EGGSHELL ENAMEL PAINT, NEUTRAL BASE 45-000
Company: DURON INC
Street: 10406 TUCKER ST
City: BELTSVILLE MD
Zipcode: 20705-2297
Health Emergency Phone: 301-937-4600; 800-228-5635
Label Required IND: Y
Date Of Label Review: 07/10/1997
Status Code: C
Label Date: 07/10/1997
Origination Code: G
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: DANGER
Respiratory Protection IND: YES
Health Hazard: Severe
Contact Hazard: Severe
Fire Hazard: Moderate
Reactivity Hazard: None
Hazard And Precautions: COMBUSTIBLE. ACUTE:INHALATION:EYE, NASAL AND
RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIGUE, NAUSEA, HEADACHE.
CENTRAL NERVOUS SYSTEM DEPRESSION; DEATH. SKIN:IRRITATION, DEFATTING AND/OR
DERMATI TIS. EYES:SEVERE IRRITATION, REDNESS, TEARING, BLURRED VISION.
INGESTION:GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA.
ASPIRATION HAZARD - CHEMICAL PNEUMONITIS. CAN BE FATAL. CHRONIC:CAN CER
HAZARD. CONTAINS SILICA, CRYSTALLINE-QUARTZ, WHICH IS LISTED AS AN ANIMAL
LUNG CARCINOGEN (FP N). KIDNEY DAMAGE. SILICOSIS, LUNG DISEASE.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|