HAWKER ENERGY (FRMLY GATES EN -- SEALED LEAD BATTERY, XT
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: CKNNP
MSDS NAME: SEALED LEAD BATTERY, XT
Responsible Party
Name: HAWKER ENERGY (FRMLY GATES ENERGY PRODUCTS, INC)
Address: 617 N. RIDGEVIEW DR.
City: WARRENSBURG MO 64093-9301
Info Phone: 800-964-2837
Emergency Phone Number: 880-429-2165
Review Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: HAWKER ENERGY PRODUCTS INC
Address: 617 NORTH RIDGEVIEW DR
City: WARRENSBURG MO 64093
Phone: 660-429-7528 / 800-964-2837
=======================================================
Ingredients
=======================================================
Cas: 7439-92-1
RTECS #: OF7525000
Name: LEAD
% low Wt: 45.
% high Wt: 60.
ACGIH TLV: 0.15 MG/M3
ACGIH STEL: NOT ESTABLISHED
EPA Rpt Qty: 1 LB
DOT Rpt Qty: 1 LB
------------------------------
Cas: 1309-60-0
RTECS #: OG0700000
Name: LEAD DIOXIDE
% low Wt: 15.
% high Wt: 25.
------------------------------
Cas: 7664-93-9
RTECS #: WS5600000
Name: SULPHURIC ACID; (SULFURIC ACID ELECTROLYTE)
% low Wt: 15.
% high Wt: 20.
OSHA PEL: 1 MG/M3
ACGIH TLV: 1 MG/M3
ACGIH STEL: 3 MG/M3
EPA Rpt Qty: 1000 LBS
DOT Rpt Qty: 1000 LBS
------------------------------
Name: NON-HAZARDOUS MATERIALS
% low Wt: 5.
% high Wt: 10.
=======================================================
Health Hazards Data
=======================================================
Route Of Entry Inds - Inhalation: NO
Skin: NO
Ingestion: NO
Carcinogenicity Inds - NTP: NO
IARC: YES
OSHA: NO
Explanation Of Carcinogenicity: SULFURIC ACID: SULFURIC ACID: IARC MONOGRAPHS,
VOL 54, PG 41, 1992:GROUP 1.
Signs And Symptions Of Overexposure: SEE HEALTH HAZARDS.
First Aid: BATTERY CONTAINS ACID ELECTROLYTE WHICH IS ABSORBED IN THE SEPARATOR
MATERIAL. IF BATTERY CASE IS PUNCTURED, COMPLETELY FLUSH ANY RELEASED
MATERIAL FROM SKIN OR EYES WITH WATER.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: AVOID CONTACT WITH ACID MATERIALS. USE SODA ASH OR
LIME TO NEUTRALIZE. FLUSH WITH WATER.
Neutralizing Agent: SODA ASH OR LIME.
Waste Disposal Methods: DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND LOCAL
REGULATIONS. DO NOT INCINERATE. BATTERIES SHOULD BE SHIPPED TO A RECLAMATION
FACILITY FOR RECOVERY OF THE METAL AND PLASTIC COMPONENTS AS THE PRO PER
METHOD OF WASTE MANAGEMENT. CONTACT DISTRIBUTOR FOR APPROPRIATE PRODUCT
RETURN PROCEDURES.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: MULTIPURPOSE DRY CHEMICAL, CARBON DIOXIDE OR WATER SPRAY.
Fire Fighting Procedures: USE NIOSH APPROVED SCBA AND FULL PROTECTIVE EQUIPMENT
(FP N). COOL BATTERY EXTERIOR TO PREVENT RUPTURE. ACID MISTS AND VAPORS IN A
FIRE ARE TOXIC AND CORROSIVE.
Unusual Fire/Explosion Hazard: HYDROGEN GAS MAY BE PRODUCED AND MAY EXPLODE IF
IGNITED. REMOVE ALL SOURCES OF IGNITION. NFPA 704 RATING: HEALTH: 1; FIRE: 1;
REACTIVITY: 0.
=======================================================
Control Measures
=======================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE
OF CONCERN (FP N). NOT APPLICABLE FOR FINISHED PRODUCT USED IN NORMAL
CONDITIONS.
Protective Gloves: IMPERVIOUS GLOVES (FP N).
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGS & FULL LENGTH FACESHIELD (FP N).
Other Protective Equipment: ANSI APPROVED EYE WASH & DELUGE SHOWER (FP N). NOT
APPLICABLE FOR FINISHED PRODUCT USED IN NORMAL CONDITIONS.
Supplemental Safety and Health: THE HAWKER SEALED LEAD ACID BATTERY IS
DETERMINED TO BE AN "ARTICLE" ACCORDING TO THE OSHA HAZARD COMMUNICATION
STANDARD AND IS THEREBY EXCLUDED FROM ANY REQUIREMENTS OF THE STANDARD. THE
MSDS IS THER EFORE SUPPLIED FOR INFORMATIONAL PURPOSES ONLY.
=======================================================
Physical/Chemical Properties
=======================================================
=======================================================
Reactivity Data
=======================================================
Stability Condition To Avoid: AVOID SHORTING. AVOID OVER-CHARGING. USE ONLY
APPROVED CHARGING METHODS. DO NOT CHARGE IN GAS TIGHT CONTAINERS.
=======================================================
Toxicological Information
=======================================================
Toxicological Information: OTHER INFO: IN 49 CFR 173.159, OTHER THAN PARAGRAPH
(D). BATTERY SHIPMENTS FROM HAWKER ENERGY PRODS INC'S WARRENSBURG LOCATION,
WILL BE PROPERLY LABELED I/A/W APPLIC DOT REGS. PACKAGING CHANGES PERFOR MED
AT OTHER LOCATIONS MAY REQ ADDNL LABELING, SINCE IN ADDN TO BATTERY ITSELF
CONTAINING REQD MARKING, OUTER PACKAGING OF BATTERY MUST ALSO CONTAIN REQD
MARKING. BECAUSE THE BATTERIES ARE CLASSIFIED AS "NONSPILLABLE" & MEET
THE THREE CNDTNS ABOVE (FROM 173.159(D)), THEY DO NOT HAVE AN ASSIGNED UN
NUMBER NOR DO THEY REQ ADDNL DOT HAZ LABELING. REG CHANGE EFTIVE SEPT 1995,
WAS TO (ECOLOGICAL INFO)
=======================================================
Ecological Information
=======================================================
Ecological: OTHER INFO: CLARIFY & DISTINGUISH TO SHIPPERS &
TRANSPORTERS, ALL BATTERIES THAT HAVE BEEN TESTED & DETERMINED TO BE IN
COMPLIANCE WITH DOT HAZ MATL REGS, INTERNATIONAL CIVIL AERONAUTICS
ORGANIZATION (CAO) & THE INTERNATIONAL AIR TRANSPORT ASSOC (ATA) PACKING
INSTRUCTION 806 & SPECIAL PROVISION A67 VIBRATION & PRESSURE
DIFFERENTIAL TESTS & THEREFORE UNREGULATED & CLASSIFIED AS A
"NONSPILLABLE BATT ERY."
=======================================================
MSDS Transport Information
=======================================================
Transport Information: HAWKER ENERGY PRODS INC BATTERIES ARE STARVED
ELECTROLYTE BATTERIES WHICH MEANS THE ELECTROLYTE IS ABSORBED IN THE
SEPARATOR MATL. THE BATTERIES ARE ALSO SEALED. AS OF SEPT 30, 1995, HAWKER
ENERGY PRO DS INC BATTERIES WERE CLASSIFIED AS "NONSPILLABLE BATTERIES,"
& AS SUCH ARE NOT SUBJECT TO THE FULL REQS OF 40 CFR 173.159. THE
PREVIOUS EXEMPT CLASSIFICATION, "DRY BATTERIES, NOT RESTRICTED" WAS DISC
ONTINUED EFTIVE SEPT 30, 1995. "NONSPILLABLE" BATTERIES ARE EXCEPTED FROM THE
REG'S COMPREHENSIVE PACKAGING REQS IF THE FOLLOWING CNDTNS ARE SATISFIED: (1)
BATTERY IS PROTECTED AGAINST SHORT (OTHER IN FO)
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
Other Information: TRANSPORT INFO: CIRCUITS & IS SECURELY PACKAGED. (2) FOR
BATTERIES MANUFACTURED AFTER SEPT 30, 1995, BATTERY & OUTER PACKAGING
MUST BE PLAINLY & DURABLY MARKED "NONSPILLABLE" OR "NONSPILLABLE BATTERY"
& (3) BATTERY IS CAPABLE OF W/STANDINGVIBRATION & PRESS DIFFERENTIAL
TESTS SPECIFIED IN 40 CFR 173.159(D). HAWKER ENERGY PRODS INC BATTERIES HAVE
BEEN TESTED BY WYLE SCIENTIFIC SERVICES & SYSTEMS LAB S GROUP &
DETERMINED TO BE IN COMPLIANCE W/VIBRATION & PRESSURE DIFFERENTIAL TESTS
CONTAINED IN 49 CFR 173.159(D), & THEREFORE, AS OF SEPT 30, 1995,
EXCEPTED FROM THE DOT REQS SET FORTH (TOXICOLOGICAL INFO)
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: SEALED LEAD BATTERY, XT
Company: HAWKER ENERGY PRODUCTS INC
Street: 617 NORTH RIDGEVIEW DR
City: WARRENSBURG MO
Zipcode: 64093
Health Emergency Phone: 880-429-2165
Label Required IND: Y
Date Of Label Review: 06/09/2000
Status Code: A
Origination Code: F
Chronic Hazard IND: Y
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: None
Fire Hazard: Slight
Reactivity Hazard: None
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.
*** END OF RECORD *** |
|
|
| ALL PAGES On Chemical Property IN THIS GROUP
| | NAME | CAS |
|
PG0004, HYSOL PC28-STD AEROSOL
| |
|
CAAPCOAT PLYURETHANE CURING AGENT
| |
|
SEALED LEAD BATTERY, SBS
| 7439-92-1
1309-60-0
7664-93-9 |
|
SEALED LEAD BATTERY, XT
| 7439-92-1
1309-60-0
7664-93-9 |
|
822 1376, KODAK DIGITAL SCIENCE SUPER 12 BLACK INK CARTRIDGE
| |
|
V-6282 PHOSPHATE ACID REAGENT (SEE SUPPL DATA)
| 7664-93-9
12054-85-2
28300-74-5
7732-18-5 |
|
V-6283 PHOSPHATE REDUCING REAGENT (SEE SUPPL)
| 89-65-6
57-50-1 |
|
FAST DRYING POLYURETHANE, ALL SHEENS (NAT'L FORMULA) M060813
| |
|
FAST DRYING POLYURETHANE,ALL SHEENS (NAT'L FORMULA) M060814
| |
|
FAST DRYING POLYURETHANE,ALL SHEENS (NAT'L FORMULA) M060815
| |
|
PCR REACTION BUFFER,10X Y02028,10966
| 1185-53-1 |
|
LUBRICATING OIL AGMA COMPOUND 7 MILITARY SYMBOL 6135
| |
|
PCR REACTION BUFFER, 10X Y02028, 11447
| 1185-53-1 |
|
PCR REACTION BUFFER,10X Y02028,11448
| 1185-53-1 |
|
PCR REACTION BUFFER,10X Y02028,18038
| 1185-53-1 |
|
PCR REACTION BUFFER,10X Y02028,18067
| 1185-53-1 |
|
PCR REACTION BUFFER,10X Y02028,18089
| 1185-53-1 |
|
PCR REACTION BUFFER,10X Y02028,18373
| 1185-53-1 |
|
PCR REACTION BUFFER,10X Y02028,18374
| 1185-53-1 |
|
SIERRA ANTIFREEZE-COOLANT
| |
|
LUBRIGUARD MULTI-PURPOSE LITHIUM EP2 GREASE,70 2616(35 LBS.)
| |
|
LUBRIGUARD MULTI-PURPOSE LITHIUM EP2 GREASE,70 2618 (120 LBS
| |
|
LUBRIGUARD MULTI-PURPOSE LITHIUM EP2 GREASE,70 2619 (400 LBS
| |
|
LUBRIGUARD MULTI-PURPOSE LITHIUM EP2 GREASE,3-02-11004
| |
|
LUBRIGUARD MULTI-PURPOSE LITHIUM EP2 GREASE,3-02-11005
| |
|
15290,FUNGIZONE ANTIMYCOTIC,LIQUID
| 1397-89-3
302-95-4
7732-18-5 |
|
SLYDE II (OZONE SAFE)
| |
|
ULANO STA-SHARP ADHERING LIQUID UN1993
| 142-82-5
141-78-6
123-86-4
67-63-0 |
|
STA SHARP ADHERING LIQUID
| 142-82-5
141-78-6
123-86-4
67-63-0 |
|
AERO CHEM 1090G
| |
|
XYLENE
| |
|
TOLUENE
| |
|
RED (M-6) MARKER BASE,84906
| |
|
GACOFLEX
| |
|
7542 SCOTCHBOND MULTI-PURPOSE PRIMER
| 7732-18-5
868-77-9 |
|
UNITED 40 P.S.I.
| |
|
UNITED 880 SUN SOLV
| 5989-27-5 |
|
NYE UNIFLOR 8991MT
| |
|
SILV-COP-PHOSPHORUS BRAZING ALLOYS,SIL-FOS&SIL-FOS15(71-150)
| 7440-50-8
7723-14-0
7440-22-4 |
|
SILVER-COPPER-PHOSPHORUS BRAZING ALLOYS,SIL-FOS 2 (71-020)
| 7440-50-8
7723-14-0
7440-22-4 |
|
SILVER-COPPER-PHOSPHORUS BRAZING ALLOYS,SIL-FOS 2M (71-017)
| 7440-50-8
7723-14-0
7440-22-4 |
|
SILVER-COPPER-PHOSPHORUS BRAZING ALLOYS,SIL-FOS 5 (71-050)
| 7440-50-8
7723-14-0
7440-22-4 |
|
EVERLUBE 811 (PEV811)
| |
|
SILVER-COPPER-PHOSPHORUS SIL-FOS 5F (71-052)
| 7440-50-8
7723-14-0
7440-22-4 |
|
SILVER-COPPER-PHOSPHORUS BRAZING ALLOYS,SIL-FOS 6 (71-060)
| 7440-50-8
7723-14-0
7440-22-4 |
|
SILVER-COPPER-PHOSPHORUS BRAZING ALLOYS,SIL-FOS 6M(71-062)
| 7440-50-8
7723-14-0
7440-22-4 |
|
SILVER-COPPER-PHOSPHORUS BRAZING ALLOYS,SIL-FOS 61 (71-063)
| 7440-50-8
7723-14-0
7440-22-4 |
|
SILVER-COPPER-PHOSPHORUS BRAZING ALLOYS, SIL-FOS 10 (71-100)
| 7440-50-8
7723-14-0
7440-22-4 |
|
KONFORM AR (FORMERLY KONFORM AR2000)
| |
|
EMGARD 2809-A SAE OW-20 SYNTHETIC ARCTIC LUBRICANT
| |
|
|