RICOH CORPORATION -- FT BLACK DEVELOPER TYPE 8800, 889580
=======================================================
Material Safety Data Sheet
=======================================================
MSDS Num: BSJMT
MSDS NAME: FT BLACK DEVELOPER TYPE 8800, 889580
Responsible Party
Name: RICOH CORPORATION
Address: 5 DEDRICK PLACE
City: WEST CALDWELL NJ 07006
Info Phone: 201-882-2000;800-336-6737
Emergency Phone Number: 800-336-6737
Proprietary Ind: Y
Published: Y
=======================================================
Contractor Summary
=======================================================
Name: RICOH CORPORATION
Address: 5 DEDRICK PLACE
City: WEST CALDWELL NJ 07006-6304
Phone: 800-336-6737
=======================================================
Ingredients
=======================================================
Name: *** PROPRIETARY ***
-----------------------------
=======================================================
Health Hazards Data
=======================================================
LD50 LC50 Mixture: NONE SPECIFIED BY MANUFACTURER.
Route Of Entry Inds - Inhalation: YES
Skin: NO
Ingestion: YES
Carcinogenicity Inds - NTP: NO
IARC: NO
OSHA: NO
Effects of Exposure: ACUTE:EYES:MAY CAUSE TEMPORARY EYE DISCOMFORT.
SKIN:NON-IRRIT. INHAL:GASPING. INGEST:>5G/KG BODY-WT, PRACTICALLY NON-TOX.
CHRONIC:IN XEROX SPONSORED CHRONIC INHAL STUDY IN RATS USING SPECIAL TEST
TONE R, THERE WERE NO LUNG CHANGES IN LOWESTEXPOS LEVEL (1MG/M3), MOST
RELEVANT LEVEL TO POTNTL HUMAN (EFTS OF OVEREXP
Explanation Of Carcinogenicity: NOT RELEVANT.
Signs And Symptions Of Overexposure: HLTH HAZ:EXPOS. VERY SLIGHT DEGREE OF
FIBROSIS WAS NOTED IN 25% OF ANIMALS AT MIDDLE EXPOS LEVEL (4MG/M3) WHILE
SLIGHT DEGREE OF FIBROSIS WAS OBSERVED AT HIGHEST EXPOS LEVEL (16MG/M3) IN
ALL ANIMALS. THESE FINDINGS ARE ATTRIBUTED TO "LUNG OVERLOAD" A GENERIC
RESPONSE TO EXCESSIVE AMTS OF ANY DUST RETAINED IN (SUPDAT)
Medical Cond Aggravated By Exposure: NOT RELEVANT.
First Aid: EYES:TRY TO REMOVE WITH EYE DROPS OR FLUSH WITH WATER FOR AT LEAST
15 MINUTES. IF UNSUCCESSFUL, GET MEDICAL ATTENTION. SKIN: WASH THOROUGHLY
WITH SOAP & WATER. INHAL: REMOVE FROM EXPOSURE. INGEST: DIL UTE STOMACH
CONTENTS WITH SEVERAL GLASSES OF WATER.
=======================================================
Handling and Disposal
=======================================================
Spill Release Procedures: IF SPILLED, SWEEP UP USING AN APPRVD TONER VACUUM
CLEANER W/0.5 MICRON FILTER SUCH AS ATRIX AAA TONER VACUUM (RICOH EDP CODE
342MIU). USE OF VACUUM CLEANER NOT RATED FOR TONER PARTICULATE COULD BE POT
NTL FIRE HAZ &/OR RSLT IN PERSONAL INJURY.(SUPDAT)
Neutralizing Agent: NONE SPECIFIED BY MANUFACTURER.
Waste Disposal Methods: DISP MUST BE I/A/W FED, STATE & LOC REGS (FP N).
USED TONER SHOULD BE DISP OF IN AN ENVIRON SAFE MANNER AND I/A/W GOVT REGS.
DO NOT INCIN. DISP REGS VARY FROM LOCALITY TO LOCALITY, THEREFORE CONSULT Y
OUR LOC EPA OFFICE TO DETERM PROPER METH
Handling And Storage Precautions: STORE IN A COOL DRY PLACE. KEEP OUT OF REACH
OF CHILDREN.
Other Precautions: DO NOT HANDLE IN WINDY AREAS. FLYING POWDER MAY ENTER EYES.
MINIMIZE INHALATION OF DUST.
=======================================================
Fire and Explosion Hazard Information
=======================================================
Extinguishing Media: CO2, DRY CHEMICALS, FOAM OR WATER SPRAY (FOG)
Fire Fighting Procedures: USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT (FP N).
Unusual Fire/Explosion Hazard: WILL NOT OCCUR.
=======================================================
Control Measures
=======================================================
Respiratory Protection: NONE REQD UNDER NORMAL CONDTNS OF USE. NIOSH/MSHA
APPROVED RESPIRATOR APPROPRIATE FOR EXPOSURE OF CONCERN (FP N). MECH
(GENERAL):ADEQUATE VENT.
Ventilation: NONE REQD UNDER NORMAL CONDITIONS OF USE. MECH (GENERAL): ADEQUATE
VENT.
Protective Gloves: NONE UNDER NORMAL USE.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGLES (FP N).
Other Protective Equipment: NONE REQUIRED UNDER NORMAL CONDITIONS OF USE.
Work Hygienic Practices: MINIMIZE BREATHING DUST. CLEANSE SKIN THOROUGHLY AFTER
CONTACT, BEFORE BREAKS AND MEALS AND AT END OF WORK PERIODS.
Supplemental Safety and Health: EFTS OF OVEREXP:LUNGS FOR PRLNG INTERVAL.
SPECIAL TEST TONER WAS 20 TIMES MORE RESPIRABLE THAN COMMERCIALLY AVAIL TONER
TO COMPLY W/EPA TESTING PROTOCOL & WOULD NOT FUNC PROPERLY IN XEROGRAPHIC
EQUIP. SPILL PROCS:REMOVE RESIDUE WITH SOAP &WATER.
=======================================================
Physical/Chemical Properties
=======================================================
HCC: N1
Spec Gravity: 2.1
Solubility in Water: LESS THAN 0.1
Appearance and Odor: BLACK POWDER WITH SLIGHT PLASTIC ODOR
=======================================================
Reactivity Data
=======================================================
Stability Indicator: YES
Hazardous Decomposition Products: CARBON MONOXIDE AND OTHER DECOMPOSITION
PRODUCTS IN CASE OF INCOMPLETE COMBUSTION.
Hazardous Polymerization Indicator: NO
=======================================================
Toxicological Information
=======================================================
=======================================================
Ecological Information
=======================================================
=======================================================
MSDS Transport Information
=======================================================
=======================================================
Regulatory Information
=======================================================
=======================================================
Other Information
=======================================================
=======================================================
HAZCOM Label
=======================================================
MSDS NAME: FT BLACK DEVELOPER TYPE 8800, 889580
Company: RICOH CORPORATION
Street: 5 DEDRICK PLACE
City: WEST CALDWELL NJ
Zipcode: 07006-6304
Health Emergency Phone: 800-336-6737
Label Required IND: Y
Date Of Label Review: 11/22/1993
Status Code: C
Label Date: 11/22/1993
Origination Code: G
Eye Protection IND: YES
Skin Protection IND: YES
Signal Word: CAUTION
Respiratory Protection IND: YES
Health Hazard: Slight
Contact Hazard: Slight
Fire Hazard: None
Reactivity Hazard: None
Hazard And Precautions: ACUTE:MAY CAUSE TEMP EYE DISCOMFORT. INHALATION OF
DUSTS MAY CAUSE GASPING. CHRONIC:NONE SPECIFIED BY MANUFACTURER.
=======================================================
Disclaimer (provided with this information by the compiling agencies): This
information is formulated for use by elements of the Department of Defense.
The United States of America in no manner whatsoever expressly or implied
warrants, states, or intends said information to have any application, use or
viability by or to any person or persons outside the Department of Defense
nor any person or persons contracting with any instrumentality of the United
States of America and disclaims all liability for such use. Any person
utilizing this instruction who is not a military or civilian employee of the
United States of America should seek competent professional advice to verify
and assume responsibility for the suitability of this information to their
particular situation regardless of similarity to a corresponding Department
of Defense or other government situation.