===================== Product Identification =====================
MSDS NAME:CARBON GREASE PAINT REMOVER
NIIN:00N002431
MSDS Number: BCJDJ
=== Responsible Party ===
Company:CLEANING COMPOUNDS CORPS
Country:US
Emergency Phone Num:1-800-424-9300
CAGE:4E387
=== Contractor Identification ===
Company:CLEANING COMPOUNDS CORPS
CAGE:4E387
============= Composition/Information on Ingredients =============
Name:METHYLENE CHLORIDE (SARA III)
CAS:75-09-2
RTECS #:PA8050000
Fraction by Wt: 40%
OSHA PEL:500 PPM/C,1000; Z2
ACGIH TLV:50 PPM, A2; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:CRESOL, ALL ISOMERS (CRESYLIC ACID) (SARA III)
CAS:1319-77-3
RTECS #:GO5950000
Fraction by Wt: 20%
OSHA PEL:S, 5 PPM
ACGIH TLV:S, 5 PPM; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:AROMATIC HYDROCARBON
Fraction by Wt: 10%
Name:POTASSIUM HYDROXIDE (SARA III)
CAS:1310-58-3
RTECS #:TT2100000
Fraction by Wt: 2%
OSHA PEL:C, 2 MG/M3
ACGIH TLV:C 2 MG/M3; 9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Name:FATTY ACID
Fraction by Wt: 7%
===================== Hazards Identification =====================
Effects of Overexposure:PRODUCT TOXIC BY INHALATION & INGESTION. SEVERE
IRRITANT TO EYES & SKIN.
======================= First Aid Measures =======================
Eyes: FLUSH W/WATER FOR 15 MINUTES. SKIN: FLUSH W/WATER.
INHAL: REMOVE FROM EXPOSURE. IN ALL CASES OF OVEREXPOSURE GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point:NONE TO BOILING
Fire Fighting Procedures:WEAR PRESSURE DEMAND SCBA & FULL PROTECTIVE
CLOTHING
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL & PHOSGENE
====================== Handling and Storage ======================
Handling and Storage Precautions:STORE UNDER 70F,21C. IF STORED HIGHER
THE EXPANSION FACTOR OF METHYLENE CHLORZDE MIGHT CAUSE SWELLING &
SPURTING OF THE PRODUCT UPON OPENING.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN GENERAL
VICINITY OF ARC WELDING,OPEN FLAME OR HOT SURFACES. HEAT AND/OR UV
RADIATION MAY CAUSE THE FORMATION OF HCL AND/OR PHOSGENE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATOR IF REQUIRED.
Ventilation:ADEQUATE TO KEEP BELOW TLV.
Protective Gloves:RECOMND
Eye Protection:RECOMND
Supplemental Safety and Health
OTHER INGREDIENTS: WATER = 20%. EMERGENCY PHONE NUMBER IS FOR
CHEM-TREC.
================== Physical/Chemical Properties ==================
HCC:T4
Spec Gravity:1.2
Appearance and Odor:STRONG CRESOL ODOR.
================= Stability and Reactivity Data =================
SYNTHETIC & NATURAL RUBBER PRODUCTS- VERY HARMFUL
Hazardous Decomposition Products:HCL, PHOSGENE
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF IAW FEDERAL STATE & LOCAL REGULATIONS
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|
|