===================== Product Identification =====================
MSDS NAME:IGEPAL CO-630 SURFACTANT
NIIN:00N010136
MSDS Number: CBVQH
=== Responsible Party ===
Company:GAF CHEMICALS CORP
Address:1361 ALPS RD
City:WAYNE
State:NJ
ZIP:07470
Country:US
Info Phone Num:201-628-3000
Emergency Phone Num:800-228-5635;800-424-9300(CHEMTREC)
CAGE:46575
=== Contractor Identification ===
Company:GAF CHEMICALS CORP, SUB OF GAF CORP
Address:1361 APLS RD
Box:City:WAYNE
State:NJ
ZIP:07470
Country:US
Phone:201-628-3341
CAGE:46575
============= Composition/Information on Ingredients =============
Name:GLYCOLS, POLYETHYLENE, MONO(NONYLPHENYL)ETHER;
(POLY(OXY-1,2-ETHANEDIYL), ALPHA(NONYLPHENYL)-OMEGA HYDROXY-)
CAS:9016-45-9
RTECS #:MD0900000
OSHA PEL:N/K
ACGIH TLV:N/K
Name:ETHYLENE OXIDE (SARA 302/313) (CERCLA)
CAS:75-21-8
RTECS #:KX2450000
Fraction by Wt: <0.0002%
OSHA PEL:1 PPM
ACGIH TLV:1 PPM
EPA Rpt Qty:10 LBS
DOT Rpt Qty:10 LBS
Name:HNDLG/STOR PRECS: IN THIS PROD. RPTD EXPOS MAY BE HARMFUL.
IF CONTROL PROCEDURES ARE FOLLOWED, AIR SPACE CONCS (ING 4)
RTECS #:9999999ZZ
Name:ING 3: SHOULD BE BELOW THE OSHA ESTABLISHED "ACTION LEVEL."
RTECS #:9999999ZZ
Name:VENT: ARE BEING OPENED.
RTECS #:9999999ZZ
Name:EYE PROT: & FULL LENGTH FACESHIELD .
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:LD50: (ORAL, RAT) 3000 MG/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INGEST:NO EFTS OF EXPOS EXPECTED.
INHAL:IF MISTED, CAUSES IRRIT OF MUC MEMBS, NOSE, EYES & THROAT,
COUGH, DFCLTY BRTHG. SKIN:NO EFTS OF EXPOS EXPECTED DUE TO CNTCT.
MAY POSS CAUSE IRRIT/DERM IN SOME I NDIVIDUALS UPON PRLNGD CNTCT.
EYES:CAUSES PAINFUL STINGING/BURNING OF EYES & LIDS. WATERING EYES,
CONJ,(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: OPAQUENESS OF CORNEA, POSS LEADING TO
LOSS OF SIGHT. NTP LISTS ETHYLENE OXIDE (EO) IN 4TH ANNUAL RPT ON
CARCINS REFERENCING IARC RPT PUBLISHED IN 1984. RPT STATES THERE IS
SUFFICIENT EVID FO R CARCIN TO EXPERIMENTAL ANIMALS, HOWEVER, WHEN
PROD IS HNDLD I/A/W OCCUP CTL PROCS NEITHER ACUTE NOR LONG TERM
(SUPDAT)
Medical Cond Aggravated by Exposure:NO DATA FOUND.
======================= First Aid Measures =======================
First Aid:INGEST:GEN PREC MEASURES SUGGEST INDUCING VOMIT IMMED BY
GIVING 2 GLASSES OF WATER & STICKING FINGER DOWN THROAT. NEVER GIVE
ANYTHING BY MOUTH TO UNCON PERSON. CALL MD. INHAL: REMOVE TO FRESH
AIR. IF NOT BRTHG GIVE ARTF RESP, PREF MOUTH-TO-MOUTH. IF BRTHG IS
DFCLT, GIVE OXYGEN. CALL MD. SKIN: FOR ALL FOREIGN MATLS, WASH
AFTER EXPOS. EYES: IMMED FLUSH W/PLENTY OF WATER FOR AT LEAST 15
MIN. CALL MD.
===================== Fire Fighting Measures =====================
Flash Point Method:PMCC
Flash Point:>535F,>279C
Extinguishing Media:USE MEDIA PROPER TO PRIMARY CAUSE OF FIRE.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NONE KNOWN.
================== Accidental Release Measures ==================
Spill Release Procedures:ABSORB WITH EARTH, SAND OR SIMILAR INERT
MATERIAL AND DISPOSE OF WITH SOLID WASTE ACCORDING TO FEDERAL,
STATE AND LOCAL REGULATIONS. FLUSH SPILL AREA WITH WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:DO NOT GET IN EYES, WASH THORO AFTER
HNDLG. AVOID BRTHG MIST. USE W/ADEQ VENT FOR MISTING OPERATIONS.
EO, CANCER & REPRO HAZ, MAY BE PRESENT (ING 3)
Other Precautions:PROT MEASURES DURING REPAIR/MAINT OF EQUIP:WASH EQUIP
THORO W/STEAM OR WARM WATER UNTIL CLEAN. CHECK FOR FLAMMS W/"EXPLO
METER" & ALSO CHECK OXYGEN LEVEL W/OXYGEN METER. IN ALL CASES
FOLLOW GOOD INDUS TRIAL SFTY PRACTS BEFORE ENTERING EQUIP.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:USE NIOSH/MSHA APPROVED RESPIRATOR IF ADEQUATE
VENTILATION CANNOT BE PROVIDED AT ANY TIME OR IF THERE IS A
POSSIBILITY OF EXCESSIVE CONTACT WITH HEADSPACE ABOVE THE DRUM OR
TANKWAGON.
Ventilation:TRACES OF EO COULD ACCUM IN HEADSPACE OF STORAGE/TRANSPORT
VESSELS. USE W/ADEQ VENT ESP WHERE DRUMS/TANKWAGONS (ING 5)
Protective Gloves:IMPERVIOUS GLOVES .
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS (ING 6)
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
PH OF SOLN: 5-9 10% SOLN IN DISTILLED WATER. % VOLAT: 0.50 WATER-MAX.
EFTS OF OVEREXP: HAZ FROM EO IS EXPECTED. EO APPEARS ON THE NAVY
LIST OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FROM APPROP HLTH
PROFESSINALS CONCERNING LATEST HAZ LIST INFO & SAFE HANDLG & EXPOS
INFO .
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>392F,>200C
Vapor Pres:NOT VOLAT
Vapor Density:NOT VOLAT
Spec Gravity:1.06 (H*2O=1)
pH:SUPDAT
Evaporation Rate & Reference:NOT VOLATILE
Solubility in Water:SOLUBLE
Appearance and Odor:FREE FLOWING, SLIGHTLY VISCOUS LIQUID; AROMATIC
ODOR.
Percent Volatiles by Volume:SUDPAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING OR REDUCING AGENTS.
Stability Condition to Avoid:NONE KNOWN.
Hazardous Decomposition Products:ACRID SMOKE AND FUMES EMITTED WHEN
HEATED TO DECOMPOSITION.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISPOSE OF WITH LIQUID WASTE ACCORDING TO
FEDERAL, STATE AND LOCAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|