===================== Product Identification =====================
MSDS NAME:832K220 36173 GRAY; POLYAMINE
NIIN:00F051645
Kit Part:Y
MSDS Number: CCFLW
=== Responsible Party ===
Company:COURTAULDS AEROSPACE INC
Address:5430 SAN FERNANDO RD
Box:1800
City:GLENDALE
State:CA
ZIP:91209-5000
Country:US
Info Phone Num:818-240-2060/800-228-6636
Emergency Phone Num:800-228-6636/818-240-2060
CAGE:83574
=== Contractor Identification ===
Company:PRC-DESOTO INTERNATIONAL, INC. A PPG INDUSTRIES COMPANY
Address:5430 SAN FERNANDO RD
Box:1800
City:GLENDALE
State:CA
ZIP:91209
Country:US
Phone:818-240-2060
CAGE:83574
============= Composition/Information on Ingredients =============
Name:BUTYL ACETATE (N-BUTYL ACETATE) *96-3*
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 40%
Other REC Limits:150 PPM
OSHA PEL:710 MG/CUM
ACGIH TLV:713 MG/CUM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:DIETHYLTOLUENEDIAMINE
CAS:68479-98-1
Fraction by Wt: 5%
Name:TITANIUM DIOXIDE, TITANIUM OXIDE (SUSPECTED ANIMAL
CARCINOGEN, IARC GROUP 3) *96-3*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5%
OSHA PEL:15 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)
Name:AMORPHOUS FUMED SILICA, COLLOIDAL SILICON DIOXIDE,
AMORPHOUS SILICA DUST (IARC CARCINOGEN-GROUP 3) *96-3*
CAS:112945-52-5
RTECS #:VV7310000
Fraction by Wt: <5%
Other REC Limits:20 MPPCF DUST IN AIR
Name:HYDRATED ALUMINA, ALUMINUM HYDROXIDE, ALUMINUM OXIDE
HYDRATEALUMINA TRIHYDRATE, ALUMINUM TRIHYDROXIDE * 96-3 *
CAS:21645-51-2
RTECS #:BD0940000
OSHA PEL:15 MG/CUM (DUST)
ACGIH TLV:2 MG/CUM (DUST)
Name:SILICA ALUMINA CERAMIC
Name:CLAY (KAOLIN), ALUMINUM SILICATE *96-3*
CAS:1332-58-7
RTECS #:GF1670500
ACGIH TLV:10 MG/CUM TOTAL DUST
Name:POLY(TOLUENE 2,4-DIISOCYANATE-POLYETHYLENE
GLYCOL-POLYPROPYLENE GLYCOL) COPOLYMER
CAS:70682-83-6
Name:VOLATILE ORGANIC CONTENT: 284 GM/L MXD 930K089 @ 1.4/1 BY
WT
RTECS #:9999999VO
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYES: MAY CAUSE BURNING, POSSIBLE
TRANSIENT CORNEAL INJURY.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:BURNING, TEARING, REDDENING, DRYING/CRACKING OF
SKIN, DIZZINESS, DROWSINESS, FATIGUE, NAUSEA
======================= First Aid Measures =======================
Eyes: FLUSH W/WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER.
DON'T USE SOLVENTS. INHALATION: REMOVE TO FRESH AIR FROM EXPOSURE.
GIVE CPR IF NEEDED. OBTAIN MEDICAL ATTENTION IN ALL CASES.
===================== Fire Fighting Measures =====================
Flash Point:80F
Extinguishing Media:CO2, DRY CHEMICAL/FOAM
Fire Fighting Procedures:WATER SPRAY MAY BE INEFFECTIVE. COOL FIRE
EXPOSED CONTAINERS W/WATER. FOG NOZZLES ARE PREFERRED. WEAR
NIOSH/MSHA APPROVED SCBA & PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:VAPORS MAY FORM EXPLOSIVE MIXTURES W/AIR,
TRAVEL LONG DISTANCES, FLASHBACK/FLAME TO HANDLING SITE. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT.
================== Accidental Release Measures ==================
Spill Release Procedures:PROTECT FROM IGNITION. WEAR AIR-SUPPLIED
RESPIRATOR FOR UNVENTILATED RELEASE. COVER W/ABSORBENT MATERIAL &
SCOOP INTO CONTAINER. CLEAN RESIDUE W/A SUITABLE SOLVENT
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER TIGHTLY CLOSED. DON'T
STORE >120F. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS &
FLAME. EMPTY DRUMS MAY CONTAIN EXPLOSIVE VAPORS.
Other Precautions:DON'T CUT, PUNCTURE/WELD ON/NEAR DRUM. VAPORS OF THIS
PRODUCT ARE >AIR & MAY COLLECT IN LOW/CONFINED AREAS. VAPORS MAY
ACCUMULATE IN INADEQUATELY VENTILATED AREAS.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:WHEN SPRAYING/APPLYING IN ANY CIRCUMSTANCES
LIKELY TO PRODUCE AIRBORNE LEVEL IN EXCESS OF TLV, USE AN ORGANIC
VAPOR CARTRIDGE/AIR SUPPLIED RESPIRATOR.
Ventilation:GENERAL VENTILATION TO MAINTAIN VAPORS 1
Spec Gravity:1.282
Appearance and Odor:GRAY LIQUID W/SOLVENT ODOR
Percent Volatiles by Volume:60.8
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
NONE
Stability Condition to Avoid:HEAT, SPARKS, FLAME, ELECTRICAL EQUIPMENT
& OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO2, CO
==================== Disposal Considerations ====================
Waste Disposal Methods:WHEN DISPOSING OF THIS MATERIAL, ENSURE THAT IT
IS PACKAGED, STORED, TRANSPORTED & MANAGED IAW/LOCAL, STATE &
FEDERAL REGULATIONS. FLAMMABLE LIQUID UN1263.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|