===================== Product Identification =====================
MSDS NAME:URETHANE CATALYST - SEMI-GLOSS/INTERIOR, 340 SG
NIIN:00N027860
Status Code:A
MSDS Number: CHSGL
=== Responsible Party ===
Company:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTRERO AVE
City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Info Phone Num:213-283-9335
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:RICHARD A. STEWART
CAGE:65860
=== Contractor Identification ===
Company:CARDINAL INDUSTRIAL FINISHES
Address:1329 POTERO AVE
Box:City:SOUTH EL MONTE
State:CA
ZIP:91733
Country:US
Phone:818-444-9274 OR 213-283-9335
CAGE:65860
============= Composition/Information on Ingredients =============
Name:METHYL ETHYL KETONE (SARA 313) (CERCLA). VP: 70 @ 20C.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 1.49%
OSHA PEL:200 PPM
ACGIH TLV:200 PPM; 300 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:ETHYL ACETATE (CERCLA). VP: 70 @ 20C.
CAS:141-78-6
RTECS #:AH5425000
Fraction by Wt: 6.59%
OSHA PEL:400 PPM
ACGIH TLV:400 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:N-BUTYL ACETATE (CERCLA). VP: 10 @ 20C.
CAS:123-86-4
RTECS #:AF7350000
Fraction by Wt: 2.44%
OSHA PEL:150 PPM
ACGIH TLV:150 PPM; 200 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:TOLUENE DIISOCYANATE (SARA 302/313) (CERCLA). VP: <0.1 @
20C.
CAS:584-84-9
RTECS #:CZ6300000
Fraction by Wt: 0.18%
OSHA PEL:0.02 PPM, C
ACGIH TLV:0.005 PPM; 0.02 STEL
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS
Name:HEXAMETHYLENE DIISOCYANATE (CERCLA). VP: <0.1 @ 20C.
CAS:822-06-0
RTECS #:MO1740000
Fraction by Wt: 0.20%
OSHA PEL:N/K
ACGIH TLV:0.005 PPM
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB
Name:VOLATILE ORGANIC COMPOUND EXCLUDING EXEMPT: 0.95 LB/GAL;
114 G/L. VOC INCLUDING EXEMPT: 0.95 LB/GAL; 114 G/L
RTECS #:9999999VO
OSHA PEL:N/K
ACGIH TLV:N/K
Name:SUPDAT: ARE PRESENT. IN LIEU OF AIR MONITORING DATA, NIOSH
APPRVD AIR SUPPLIED RESPS ARE SUGGESTED FOR SPRAY (ING 8)
RTECS #:9999999ZZ
Name:ING 7: APPLICATION. OBSERVE OSHA REGS FOR RESP USE (29 CFR
1910.134).
RTECS #:9999999ZZ
Name:OTHER PROT EQUIP: SAFETY EQUIP SUPPLIER). PREVENT
RPTD/PRLNGD SKIN CONTACT W/GB PROTECTIVE HAND CREAM. WEAR (ING 10)
RTECS #:9999999ZZ
Name:ING 9: IMPERVIOUS CLOTHING & CHEMICAL RESISTANT BOOTS.
RTECS #:9999999ZZ
===================== Hazards Identification =====================
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYES: CAN CAUSE IRRITATION AND
REDNESS, TEARING OR BLURRED VISION. SKIN: MODERATE IRRITATION
POSSIBLE FROM PROLONGED EXPOSURE, DEFATTING AND DERMATITIS.
INHALATION: NASAL IRRITATION, HEADACHE, DIZZINE SS, NAUSEA,
WEAKNESS OR VOMITING. LOSS OF CONSCIOUSNESS. INGESTION: GI
IRRITATION, HEADACHE, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:TOLUENE DIISOCYANATE (2,4): IARC
MONOGRAPHS, SUPPLEMENT, VOL 7, PG 56, 1987:GROUP 2B.
Effects of Overexposure:HLTH HAZ: DIZZINESS, NAUSEA, WEAKNESS OR
VOMITING.
Medical Cond Aggravated by Exposure:PRE-EXISTING RESP CNDTNS,
PRE-EXISTING SKIN DISORDERS, LIVER & KIDNEY DISORDERS. ALLERGIC
SKIN OR RESP REACTION MAY OCCUR IN SOME INDIVIDUALS. RESP
SENSITIVITY RSLTS IN ASTHMA-LIKE SYMPS ON (SUPDAT)
======================= First Aid Measures =======================
Eyes: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION IMMEDIATELY. SKIN: WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. INHAL: REMOVE TO FRESH AIR. IF
BREATHING I S DIFFICULT, ADMINISTER OXYGEN. IF BREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
INGEST: DO NOT INDUCE VOMITING. KEEP PERSON WARM AND QUIET. GET
MEDICAL ATTENTION.
===================== Fire Fighting Measures =====================
Flash Point Method:TCC
Flash Point:24.0F,-4.4C
Lower Limits:0.9%
Upper Limits:11.4%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPROVED SCBA AND FULL PROTECTIVE
EQUIPMENT .
Unusual Fire/Explosion Hazard:CONTAINERS MAY DEFORM OR EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DECOMPOSITION PRODUCTS MAY YIELD OXIDES OF
CARBON AND NITROGEN.
================== Accidental Release Measures ==================
Spill Release Procedures:REFER TO OTHER SECTIONS IV, V, VI VII & VIII
OF MSDS. ELIMINATE ALL IGNITION SOURCES. ABSORB LIQUID IN ABSORBENT
MATERIAL AND PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
====================== Handling and Storage ======================
Handling and Storage Precautions:CNTNRS OF THIS MATL MAY BE HAZ WHEN
EMPTIED, SINCE EMPTIED CNTNRS RETAIN PROD RESIDUALS (VAP, LIQ &/OR
SOLID). ALL HAZ PRECS IN MSDS MUST BE OBSERVED.
Other Precautions:PAINT AND SOLVENTS HAVE BEEN LINKED TO LIVER
ABNORMALITIES, KIDNEY AND LUNG DAMAGE. FOR INDUSTRIAL USE ONLY WITH
ADEQUATE VENTILATION. FOLLOW PRECAUTIONS OF MSDS TO PREVENT
OVEREXPOSURE.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF TLV OF PROD OR ANY COMPONENT IS EXCEEDED, A
NIOSH APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF
ENVIRONMENTAL CONTROL. OSHA REGS ALSO PERMIT OTHER NIOSH APPRVD
RESPS UNDER SPECIFIED CNDTNS. (SE E SAFETY EQUIP SUPPLIER.)
(SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECH(GEN &/OR LOC EXHST) VENT TO
MAINTAIN EXPOS BELOW TLV(S) &/OR USE NIOSH APPRVD AIR SUPPLIED
RESP.
Protective Gloves:CHEMICAL AND SOLVENT RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
SPLASH ARPONG SUGGESTED FOR MIXING OPERATIONS (CONSULT YOUR (ING 9)
Work Hygienic Practices:"WASH HANDS BEFORE EATING OR USING RESTROOM.
SMOKE IN SMOKING AREAS ONLY."
Supplemental Safety and Health
% VOLAT: 10.7 (WT). MED CNDTNS: SUBSEQUENT EXPOS EVEN BELOW TLV. SKIN
SENSITIVITY RSLTS IN ALLERGIC DERM WHICH MAY INCL RASH, ITCHING,
HIVES & SWELLING OF EXTREMITIES. RESP PROT: ENGINEERING OR ADMINI
STRATIVE CONTROLS SHOULD BE IMPLEMENTEDTO REDUCE EXPOS. WHEN
COATING IS CATALYZED, LOW LEVELS OF ISOCYANATES (ING 7)
================== Physical/Chemical Properties ==================
Boiling Pt:B.P. Text:>171F,>77C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.18
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:SUPDAT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
AVOID CONTAMINATION WITH WATER, ALCOHOLS, AMINES, ALKALIS AND STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:EXTREME TEMPERATURES AND CONTACT WITH
MOISTURE.
Hazardous Decomposition Products:BY FIRE: CO*2, CO, OXIDES OF NITROGEN,
TRACES OF HCN, TDI.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORM CNDTNS OF
USE. PROD WILL REACT W/WATER,ALCOHOLS & AMINES GENERATING HEAT &
GASES SUCH AS CO*2.
==================== Disposal Considerations ====================
Waste Disposal Methods:DESTROY BY LIQUID INCINERATION IN ACCORDANCE
WITH APPLICABLE FEDERAL, STATE AND LOCAL REGULATIONS. CONTAMINATED
ABSORBENT SHOULD BE INCINERATED OR SENT TO APPROVED LANDFILL IN
ACCORDANCE WITH LOCAL, S TATE AND FEDERAL REGULATIONS.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|