===================== Product Identification =====================
MSDS NAME:824 9906,CONC,KODAK REVERSAL BATH,PROCESS E-6
NIIN:01-301-8779
Status Code:A
Kit Part:Y
MSDS Number: CLHNV
=== Responsible Party ===
Company:EASTMAN KODAK CO GOVERNMENT MARKETS CONTRACTS
Address:343 STATE ST
City:ROCHESTER
State:NY
ZIP:14650-1115
Country:US
Info Phone Num:716-722-5151/(800) 242-2424
Emergency Phone Num:716-722-5151
CAGE:19139
=== Contractor Identification ===
Company:EASTMAN KODAK CO GOVERNMENT MARKETS CONTRACTS
Address:343 STATE ST
Box:City:ROCHESTER
State:NY
ZIP:14650-1115
Country:US
Phone:716-722-5151/(800) 242-2424
CAGE:19139
============= Composition/Information on Ingredients =============
Name:WATER
CAS:7732-18-5
RTECS #:ZC0110000
Minumum % Wt:65.
Maxumum % Wt:70.
Other REC Limits:NONE RECOMMENDED
Name:SODIUM PROPIONATE
CAS:137-40-6
RTECS #:UF7525000
Minumum % Wt:15.
Maxumum % Wt:20.
Other REC Limits:NONE RECOMMENDED
Name:SUBSTITUTED PHOSPHATE (1)
CAS:2235-43-0
Minumum % Wt:5.
Maxumum % Wt:10.
Other REC Limits:NONE RECOMMENDED
Name:SUBSTITUTED PHOSPHATE (2)
CAS:6419-19-8
RTECS #:SZ9860000
Minumum % Wt:5.
Maxumum % Wt:10.
Other REC Limits:NONE RECOMMENDED
Name:PROPIONIC ACID (CERCLA)
CAS:79-09-4
RTECS #:UE5950000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:10 PPM
ACGIH TLV:10 PPM; 9596
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS
Name:STANNOUS CHLORIDE, SOLID
CAS:7772-99-8
RTECS #:XP8700000
Minumum % Wt:1.
Maxumum % Wt:5.
Other REC Limits:NONE RECOMMENDED
OSHA PEL:2 MG SN/M3
ACGIH TLV:2 MG SN/M3
===================== Hazards Identification =====================
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:GENERAL: PROPIONIC ACID. THE
TOXICOLOGICAL PROPERTIES OF THIS MATERIAL HAVE NOT BEEN FULLY
INVESTIGATED AND ITS HANDLING AND USE MAY PRESENT ADDITIONAL
HAZARDS. INHALATION: LOW HAZARD FOR USUAL INDUST RIAL HANDLING BY
TRAINED PERSONNEL. EYES: CAUSES IRRITATION. HOWEVER, IMMEDIATE
FLUSHING OF THE EYES WITH WATER WILL MINIMIZE ANY IRRITATIVE
EFFECT. SKIN: CAUSES IRRITATION. INGESTION: MAY CAUSE IRRIT ATION
OF THE GASTROINTESTINAL TRACT. INGESTION CAN CAUSE ABDOMINAL PAIN,
VOMITING AND DIARRHEA.
Explanation of Carcinogenicity:CARCINOGENICITY CLASSIFICATION
(COMPONENTS PRESENT AT 0.1% OR MORE): - INTERNATIONAL AGENCY FOR
RESEARCH ON CANCER (IARC): NONE - AMERICAN CONFERENCE OF
GOVERNMENTAL INDUSTRIAL HYGIENISTS (ACGIH): NON E - NATIONAL
TOXICOLOGY PROGRAM (NTP): NONE - OCCUPATIONAL SAFETY AND HEALTH
ADMINISTRATION (OSHA): NONE
Effects of Overexposure:GENERAL: PROPIONIC ACID. THE TOXICOLOGICAL
PROPERTIES OF THIS MATERIAL HAVE NOT BEEN FULLY INVESTIGATED AND
ITS HANDLING AND USE MAY PRESENT ADDITIONAL HAZARDS. INHALATION:
LOW HAZARD FOR USUAL INDUST RIAL HANDLING BY TRAINED PERSONNEL.
EYES: CAUSES IRRITATION. HOWEVER, IMMEDIATE FLUSHING OF THE EYES
WITH WATER WILL MINIMIZE ANY IRRITATIVE EFFECT. SKIN: CAUSES
IRRITATION. INGESTION: MAY CAUSE IRRIT ATION OF THE
GASTROINTESTINAL TRACT. INGESTION CAN CAUSE ABDOMINAL PAIN,
VOMITING AND DIARRHEA.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.
======================= First Aid Measures =======================
First Aid:INHALATION: IF SYMPTOMATIC, MOVE TO FRESH AIR. TREAT
SYMPTOMATICALLY. GET MEDICAL ATTENTION IF SYMPTOMS PERSIST. EYES:
IMMEDIATELY FLUSH WITH PLENTY OF WATER AT LEAST 15 MINS. GET
MEDICAL ATTENTION IF SYMPTOMS OCCUR. SKIN: IMMEDIATELY FLUSH WITH
PLENTY OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING CONTAMINATED
CLOTHING AND SHOES. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. WASH
CONTAMINATED CLOTHIN G BEFORE REUSE. DESTROY OR THOROUGHLY CLEAN
CONTAMINATED SHOES. DRINK 1-2 GLASSES OF WATER. SEEK MEDICAL
ATTENTION. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
===================== Fire Fighting Measures =====================
Flash Point:NONE
Extinguishing Media:WATER SPRAY, CARBON DIOXIDE (CO2), DRY CHEMICAL,
ALCOHOL FOAM.
Fire Fighting Procedures:WEAR SELF-CONTAINED BREATHING APPARATUS AND
PROTECTIVE CLOTHING. FIRE OR EXCESSIVE HEAT MAY PRODUCE HAZARDOUS
DECOMPOSITION PRODUCTS.
Unusual Fire/Explosion Hazard:NONE
================== Accidental Release Measures ==================
Spill Release Procedures:FLUSH TO SEWER WITH LARGE AMOUNTS OF WATER.
OTHERWISE, ABSORB SPILL WITH VERMICULITE OR OTHER INERT MATERIAL,
THEN PLACE IN A CONTAINER FOR CHEMICAL WASTE. CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
====================== Handling and Storage ======================
Handling and Storage Precautions:KEEP CONTAINER CLOSED. KEEP FROM
CONTACT WITH OXIDIZING MATERIALS.
Other Precautions:AVOID BREATHING MIST OR VAPOR AT CONCENTRATIONS
GREATER THAN THE EXPOSURE LIMITS. AVOID CONTACT WITH EYES, SKIN,
AND CLOTHING. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING.
============= Exposure Controls/Personal Protection =============
Respiratory Protection:IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE
CONCENTRATIONS BELOW RECOMMENDED EXPOSURE LIMITS, AN APPROVED
RESPIRATOR MUST BE WORN. RESPIRATOR TYPE: FULL-FACE ORGANIC VAPOR
CARTRIDGE. IF RESPIRATO RS ARE USED, A PROGRAM SHOULD BE INSTITUTED
TO ASSURE COMPLIANCE WITH OSHA STANDARD 29 CFR 1910.134.
Ventilation:GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER
HOUR) SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS.
Protective Gloves:WEAR IMPERVIOUS GLOVES AND PROTECTIVE CLOTHING
APPROPRIATE FOR RISK OF EXPOSURE
Eye Protection:IF A FULL-FACE RESPIRATOR IS NOT WORN, WEAR VAPOR-TIGHT
CHEMICAL GOGGLES.
Other Protective Equipment:EYE BATH, WASHING FACILITIES, SAFETY SHOWER
Supplemental Safety and Health
SUPPLEMENTARY LOCAL EXHAUST VENTILATION, CLOSED SYSTEMS, OR RESPIRATORY
PROTECTION MAY BE NEEDED IN SPECIAL CIRCUMSTANCES SUCH AS POORLY
VENTILATED SPACES, EVAPORATION FROM LARGE SURFACES, SPRAYING ,
HEATING, ETC.
================== Physical/Chemical Properties ==================
HCC:C2
Boiling Pt:>100.C, 212.F
Vapor Pres:68F: 24MBAR (18 MM HG)
Vapor Density:0.6
Spec Gravity:1.203
pH:5.9
Solubility in Water:COMPLETE
Appearance and Odor:LIQUID;COLORLESS; ODOR: SLIGHTLY SWEET.
Percent Volatiles by Volume:65-70 WT
================= Stability and Reactivity Data =================
Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:STABLE.
Hazardous Decomposition Products:CARBON DIOXIDE,CARBON MONOXIDE,OXIDES
OF PHOSPHOROUS.
Conditions to Avoid Polymerization:WILL NOT OCCUR.
===================== Ecological Information =====================
Ecological:THE FOLLOWING PROPERTIES ARE ESTIMATED FROM THE COMPONENTS
OF THE PREPARATIONS. POTENTIAL TOXICITY- FISH LC50 MG/L: >100,
DAPHNID EC50 MG/L: >100, ALGAL IC50 MG/L: >100. ORGANICS READILY
DEGRADABLE (>70%): YES (7 DAYS). POTENTIAL BIOACCUMULATION: LOG
POW <1. COD (APPROXIMATE G/L): 358. BOD5 (APPROXIMATE G/L): 306.
POTENTIAL TOXICITY WASTE TREATMENT MICROORGANISMS EC50 (MG/L):
>100.
==================== Disposal Considerations ====================
Waste Disposal Methods:DISCHARGE, TREATMENT, OR DISPOSAL MAY BE SUBJECT
TO NATIONAL, STATE, OR LOCAL LAWS. FLUSH TO SEWER WITH LARGE
AMOUNTS OF WATER. SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS E VEN AFTER CONTAINER IS EMPTIED.
=================== MSDS Transport Information ===================
Transport Information:FOR TRANSPORTATION INFORMATION REGARDING THIS
PRODUCT CALL THE KODAK WORLDWIDE TRANSPORTATION HAZMAT HOT LINE:
(716) 722-2400 BETWEEN 8 AM AND 5 PM (EASTERN STANDARD TIME),
MONDAY THROUGH FRIDAY.
===================== Regulatory Information =====================
SARA Title III Information:CHEMICAL(S) SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OR TITLE III OF THE SUPERFUND
AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986 AND 40 CFR PART
372: NONE.
State Regulatory Information:MATERIAL(S) KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE CANCER: NONE. MATERIAL(S) KNOWN TO THE STATE
OF CALIFORNIA TO CAUSE ADVERSE REPRODUCTIVE EFFECTS: NONE.
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.
*** END OF RECORD *** |
|