=====================  Product Identification  =====================

MSDS NAME:SKD-NF/ZP-9B DEVELOPER, (NEW FORMULATION)
NIIN:00-826-0981
Kit Part:Y
MSDS Number: BHMWH
=== Responsible Party ===
Company:MAGNAFLUX CORPORATION
Address:7300 W. LAWRENCE AVENUE
City:CHICAGO
State:IL
ZIP:60656-3504
Country:US
Info Phone Num:312-867-8000
Emergency Phone Num:312-867-8000
Preparer's Name:BRUCE C. GRAHAM
CAGE:37676
=== Contractor Identification ===
Company:ILLINOIS TOOL WORKS INC MAGNAFLUX DIV
Address:3624 WEST LAKE AVENUE
Box:City:GLENVIEW
State:IL
ZIP:60025
Country:US
Phone:847-657-5300/
CAGE:37676

=============  Composition/Information on Ingredients  =============

Name:METHYL CHLOROFORM (1,1,1-TRICHLOROEHANE)  (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 90.0%
OSHA PEL:350 PPM/450 STEL
ACGIH TLV:350 PPM/450STEL;9192
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1

Name:METHYLAL (DIMETHOXYMETHANE)
CAS:109-87-5
RTECS #:PA8750000
Fraction by Wt: 2%
OSHA PEL:1000 PPM
ACGIH TLV:1000 PPM; 9192

Name:TERT-BUTYL ALCOHOL	(SARA III)
CAS:75-65-0
RTECS #:EO1925000
Fraction by Wt: 1%
OSHA PEL:100 PPM
ACGIH TLV:100PPM  9394

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Explanation of Carcinogenicity:THIRD LISTED INGREDIENT HAS BEEN UNDER
    INVESTIGATION AS A	 POSSIBLE CARCINOGEN.
Effects of Overexposure:INHAL: DIZZ, DROWS, NAUSEA. UNCONSCIOUS AT HIGH
    EXPOSURE. SKIN: IRRI BY DISSOLVING SKIN OILS. NOT ABSORBED THROUGH
    IN SIGNIFICANT AMOUNTS EYES: IRRITATING DUE TO STRONG SOLVENT
    ACTION. AND INGESTION:  LOW SINGLE DOSE TOXICITY IN TEST ANIMALS
Medical Cond Aggravated by Exposure:NONE

=======================  First Aid Measures  =======================

First Aid:INHAL: REMOVE TO FRESH AIR. IF NOT BREATHING, CALL EMERGENCY
    IMMED. GIVE CPR/OXYGEN, IF BREATHING IS DIFF. SKIN: WASH OFF IN
    FLOWING WATER/SHOWER. REMOVE CONTAMCLOTHES & LAUNDER. USE SOOTHING
    LOTION.  EYE: FLUSH EYE WITH STEADY, GENTLE FLOWOF WATER, LIFTING
    LIDS. ROLLING EYEBALL ALL DIRECTIONS. INGESTION: DO NOT
    INDUCEVOMIT; IF VOMIT IS INHALED, MAY CAUSE ASPHYXIATION. CONTACT
    PHYSICIAN IMMED

=====================  Fire Fighting Measures  =====================

Flash Point:NONE
Extinguishing Media:USE SUITABLE EXTINGUISHING MEDIA FOR SURROUNDING
    FIRES.
Fire Fighting Procedures:KEEP CONTAINERS COOL WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:VAPORS PARTIALLY DECOMPOSE TO TOXIC GASES
    WHEN EXPOSED TO FLAME,ARCS,OR RED HOT SURFACES; AEROSOL CANS MAY
    BURST AT TEMPERATURE OVER 130F.

==================  Accidental Release Measures  ==================

Spill Release Procedures:CLEAN UP CREW SHOULD WEAR ALL PERSONAL SAFETY
    WEARAS PRESENTED. THE NOSE IS NOT A RELIABLE GAUGE OF AIR
    CONTAMINATION. DO NOT BREATHE VAPORS. AVOID   PROLONGED/REPEATED
    EXPOSURE. DO NOT USE AROUND     INGNITION SOURCES.

======================	Handling and Storage  ======================

Handling and Storage Precautions:DO NOT HEAT AEROSOL CANS ABOVE 130F TO
    ELIMINATE  POSSIBLE BURSTING/RELEASING UNWANTED VAPORS. STOREAWAY
    FROM HEAT SOURCES.
Other Precautions:IMPORTANT: IN ALL SEVERE CASES, CONTACT PHYSICIAN
    IMMED. LOCAL TELEPHONE OPERAT-ORS. ARE ABLE TO FURNISH NUMBER OF
    REGIONAL POISON CONTROL CENTER TO ASSIST	 PHYSICIAN.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IN POORLY VENT AREAS SUCH AS SMALL ROOMS WITH NO
    WINDOWS OR IN SUMPS, OTHER LOW AREAS (SKD-NF VAPORS ARE DENSE &
    SINK TO LOW SPOTS) THE USER SHOULD WEAR A RESPIRATOR WITH CHEMICAL
    CARTRIDGE. CONFINED:  FULL MASK W/SEPARATE AIR SUPPLY
Ventilation:GENERAL VENTILATION MUST BE SUFFICIENT TO KEEP THE
    CONCENTRATION BELOW 350 PPM. BASE VENT RATE ON CONSUMPTION.
Protective Gloves:NITRILE RUBBER GLOVES
Eye Protection:FULL GOGGLES
Work Hygienic Practices:GOOD HYGIENE PRACTICES
Supplemental Safety and Health
NK

==================  Physical/Chemical Properties  ==================

HCC:T4
Vapor Pres:230MM @100
Vapor Density:4.0
Spec Gravity:1.3
pH:7.0LIQ
Evaporation Rate & Reference:3.0(ETHYL ALCOHOL=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR,COLORLESS,MOBIL LIQUID IN AEROSOL CANS UNDER
    PRESSURE.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
POWDERED ZINC AND ALUMINUM
Stability Condition to Avoid:HIGH TEMPERATURE/HEAT.
Hazardous Decomposition Products:PHOSGENE, HYDROCHLORIC ACID-EXTREMELY
    TOXIC TLV 0.1 PPM CANNOT BE RELIABLY DETECTED BY ODOR. HYDROCHORIC
    CAN, IS IRRI

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE #F002. MAY BE
    SENT TO SOLVENT RECLAIMER. ENSURE THAT AEROSOL CANS ARE EMPTY &
    DEPRESSURIZED BEFORE DISCARDING,UNLESSWASTE TREATMENT FACILITY IS
    APPROVED TO ACCEPT	   THEM AS IS

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.

*** END OF RECORD ***