MATERIAL SAFETY DATA SHEET
HMIS HAZARD RATINGS
OSHA - Meets 29 CFR 1910.1200 Standards
HEALTH * = Chronic Health Hazard 2 = MODERATE
1
FLAMMABILITY 0 = INSIGNIFICANT 3 = HIGH
0
PHYSICAL HAZARD 1 = SLIGHT 4 = EXTREME
0
TRANSPORTATION INFORMATION
PROPER SHIPPING NAME: Not Regulated
HAZARD CLASS / PKG GRP: Not regulated Not Applicable
REF:
IDENTIFICATION NUMBER: None None Required
LABEL:
SECTION 1 - PRODUCT / COMPANY IDENTIFICATION
IDENTITY (AS USED ON LABEL AND LIST)
Page 1 of 2
Orange Power
MANUFACTURER'S NAME EMERGENCY TELEPHONE NUMBER
Gator Chemical CHEM 鈥? TEL (800) 255-3924 Outside USA (813) 248-0585
ADDRESS (NUMBER, STREET, P.O. BOX) TELEPHONE NUMBER FOR INFORMATION
P.O. Box 1990 (727) 584-5174
(CITY, STATE AND ZIP CODE) DATE PREPARED: October 13, 2005
Largo, FL 33779 SUPERSEDES: New
SECTION 2 - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION
OSHA PEL ACGIH TWA
HAZARDOUS COMPONENTS % SARA RQ
CAS #
TITLE III LBS
(OPTIONAL) PPM MG/M3 PPM MG/M3
(SPECIFIC CHEMICAL IDENTITY; COMMON NAME(S))
Sodium metasilicate 6834-92-0 1-5 6
d-Limonene 5989-27-5 1-5 not established
SECTION 3 - HEALTH HAZARD DATA
ROUTES OF ENTRY - SIGNS AND SYMPTOMS OF EXPOSURE EMERGENCY AND FIRST AID PROCEDURES
INHALATION: Breathing concentrated vapors may cause irritation of Remove affected person to fresh air; wash mouth and nasal passages with
respiratory tract. water repeatedly; if breathing difficulties persist seek medical attention.
SKIN: Prolonged contact may cause irritation. Wash contacted area with soap and water; DO NOT attempt to neutralize
with chemical agents; if irritation persists, seek medical attention.
EYES: Contact with eyes will cause irritation. Check for and remove contact lenses. Immediately flush eyes for 15 minutes
in clear running water while holding eyelids open; seek medical attention
immediately.
INGESTION: May cause gastric distress, vomiting and diarrhea. Drink large quantities of water or milk; DO NOT induce vomiting; never give
anything by mouth to an unconscious person; seek medical attention
immediately.
CARCINOGENICITY No No No
NTP? IARC MONOGRAPHS? OSHA REGULATED?
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Preexisting skin, eye, or respiratory disorders may become aggravated through
prolonged exposure.
MATERIAL SAFETY DATA SHEET
IDENTITY (AS USED ON LABEL AND LIST) Page 2 of 2
Orange Power Date: October 13, 2005
SECTION 4 - FIRE FIGHTING MEASURES
FLASH POINT (METHOD USED) NFPA RATING FLAMMABLE LIMITS
Non-flammable None LEL: Not applicable UEL: Not applicable
EXTINGUISHING MEDIA
Carbon dioxide, water, water fog, dry chemical, chemical foam.
SPECIAL FIRE FIGHTING PROCEDURES
Keep containers cool with water spray to prevent container rupture due to steam buildup; floor will become slippery if material is released. Material is alkaline
and will irritate the eyes if product is allowed to directly contact the eyes.
UNUSUAL FIRE AND EXPLOSION HAZARDS
None
SECTION 5 - ACCIDENTAL RELEASE MEASURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Material is alkaline and will irritate the eyes if product is allowed to directly contact the
eyes. Wash small spills to sanitary sewer. Large spills - confine spill, soak up with approved absorbent, shovel product into approved container for disposal.
SECTION 6 - HANDLING AND STORAGE
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: Keep container closed when not in use; protect containers from abuse; protect from extreme
temperatures. Keep this and other chemicals out of reach of children.
SECTION 7 - EXPOSURE CONTROLS / PERSONAL PROTECTION
RESPIRATORY PROTECTION: None required while threshold limits are kept below maximum allowable concentrations; if TWA exceeds limits, NIOSH
approved respirator must be worn. Refer to 29 CFR 1910.134 or European Standard EN 149 for complete regulations.
VENTILATION LOCAL EXHAUST: Required SPECIAL: To maintain minimum TWA and STEL levels.
MECHANICAL (GENERAL): Yes OTHER: Engineering and work controls as required.
PROTECTIVE GLOVES: Neoprene, butyl or nitrile rubber gloves with cuffs. EYE PROTECTION: Chemical safety goggles.
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Coveralls, apron, or other equipment should be worn to minimize skin contact, safety eyewash station
nearby.
WORK / HYGIENIC PRACTICES: Practice safe workplace habits. Minimize body contact with this, as well as all chemicals in general.
SECTION 8 - PHYSICAL / CHEMICAL PROPERTIES
BOILING POINT SPECIFIC GRAVITY (WATER = 1)
212掳 F 1.060
VAPOR PRESSURE (MM Hg) pH
17 mm Hg @ 20 掳 C 13.1
VAPOR DENSITY (AIR = 1) EVAPORATION RATE (WATER = 1)
>1 <1
SOLUBILITY IN WATER % VOLATILE (BY WEIGHT)
Complete 90%
APPEARANCE AND ODOR
Orange liquid, citrus odor
SECTION 9 - STABILITY AND REACTIVITY
CONDITIONS TO AVOID: Extreme temperatures.
STABILITY UNSTABLE:
STABLE: XXX
INCOMPATIBILITY (MATERIALS TO AVOID): Strong oxidizers, strong acids.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS: Decomposition will not occur if handled and stored properly. In case of a fire, oxides of carbon,
hydrocarbons, fumes or vapors, and smoke may be produced.
CONDITIONS TO AVOID: None
HAZARDOUS POLYMERIZATION MAY OCCUR:
WILL NOT OCCUR: XXX
SECTION 10 - DISPOSAL CONSIDERATIONS
WASTE DISPOSAL METHOD: Dispose of in accordance with Local, State, and Federal Regulations. Refer to "40 CFR Protection of Environment Parts 260 -
299" for complete waste disposal regulations for alkaline materials. Consult your local, state, or Federal Environmental Protection Agency before disposing of
any chemicals.
The information contained herein is believed to be accurate but is not warranted to be so. Data and calculations are based on information furnished by the
manufacturer of the product and manufacturers of the components of the product. Users are advised to confirm in advance of need that information is current,
applicable and suited to the circumstances of use. Vendor assumes no responsibility for injury to vendee or third persons proximately caused by the material if
reasonable safety procedures are not adhered to as stipulated in the data sheet. Furthermore, vendor assumes no responsibility for injury caused by abnormal use
of this material even if reasonable safety procedures are followed. Any questions regarding this product should be directed to the manufacturer of the product as
described in Section 1.
MSDS PREPARED BY: CDB, Inc., P.O. Box 5604, Lakeland, FL 33807 (863) 644 - 3298 www.compdatabase.com
|