KLEEN-FLO TUMBLER INDUSTRIES LIMITED MATERIAL SAFETY DATA SHEET PAGE 1
SECTION I-MATERIAL IDENTIFICATION AND USE
Material Name/Identifier: Engine Flush Stock No. 637
Manufacturer's Name: Kleen-Flo Tumbler Industries Ltd Street Address: 75 Advance Blvd.
City: Brampton Province: Ontario
Postal Code: L6T 4N1 Emergency Phone #: (905) 793-4311
Chemical Name: N/A (Blended product) Chemical Family: N/A (mixture)
Chemical Formula: N/A (Blended product) Trade Names & Synonyms: None
Material Use: Cleaner Molecular Weight: N/A (Mixture)
SECTION II-HAZARDOUS INGREDIENTS OF MATERIAL
Hazardous Approximate LD50 LC50
Ingredients C.A.S. Concentration Species & Route Species & Route
Hydrotreated Lube Oil 64742-58-1 80-100% > 5000mg/kg-rat N/A
Orthodichlorobenzene 95-50-1 1-5% 500 mg/kg rat-oral N/A
SECTION III-PHYSICAL DATA FOR MATERIAL
Physical State: liquid Odour/Appearance: paint odour/ amber liquid
Specific Gravity: 0.88 @ 28潞C Odour Threshold(p.p.m.): N/E
Boiling Point: over 150潞C Evaporation Rate: 0.15
Freezing Point: N/E Solubility in Water: None
% Volatile(by volume): 5 Vapour Pressure(mm)Hg: N/E
Vapour Density(Air=1): N/E Coefficient of Water/Oil Distribut: N/E
pH N/A
SECTION IV-FIRE AND EXPLOSION HAZARD OF MATERIAL
Flammability Yes/No Combustible If yes under which conditions:
Auto Ignition Temperature: N/E Means of Extinction: Dry chemical, carbon dioxide,foam, water
Flashpoint and Method: > 160 oC Tag CC Hazardous Combustion Products: N/E
Upper Flammable limit (%vol) ,9.2 Lower Flammable Limit (% by volume): 2.2
Explosion Data: Sensitivity to Mechanical Impact: N/E Sensitivity to Static Discharge: N/E
SECTION V-REACTIVITY DATA
Chemical Stability Yes/No: Yes If NO under which conditions?: N.Ap.
Incompatibility to Other Substances Yes/No: Yes If so which ones? Inorganic concentrated acids, Peroxides
Reactivity and under what conditions? Open flames and sparks
Hazardous Decomposition Products: Carbon monoxide, carbon dioxide, Hydrochloride, Chlorine
N/E: not established N/A: Not applicable N. Av.: not available
Material Name/Identifier: Engine Flush Stock No. 637 PAGE 2
SECTION VI-TOXICOLOGICAL PROPERTIES OF PRODUCT
Route of Entry: All Routes --SKIN CONTACT --SKIN ABSORPTION --EYE CONTACT --INHALATION --INGESTION
Effects of Acute Exposure: Skin and mucous irritant. Can cause liver and kidney injury, nausea, vomiting, dizziness.
Effects of Chronic Exposure: None known
LD 50 of Product: >2000 mg/kg LC 50 of Product: N/E
Irritancy of Product: Eye irritant Exposure Limits of Product: 5mg/m3 TLV: TWA oil mist
Sensitization of Product: N/E Toxicologically Synergistic Materials: N/E
--CARCINOGENICITY --REPRODUCTIVE EFFECTS --TERATOGENICITY --MUTAGENICITY none known
SECTION VII-PREVENTIVE MEASURES
Personal Protective Equipment to be used:
Gloves(specify): Plastic or rubber Eye(specify): G): Goggles
Respiratory(specify): Safety mask Clothing: Not required
Respiratory Protection: If used indoors or on a continuous basis, use of cartridge type respirator is recommended
Engineering Controls: Local ventilation
Leak and Spill Procedure: Absorb with inert absorbent and dispose.
Waste Disposal: Methods approved in your plant.
Storage Requirements: Keep container closed when not in use. Keep at room temperature.
Handling Procedures and
Equipment: Keep out of reach of children. Handle with care.
DSL Listing All components are listed in the inventory.
TDG Classification: Not regulated
WHMIS Classification: Non-controlled
SECTION VIII-FIRST AID MEASURES
Eye: Rinse properly 10-15 minutes with clean tap water. Consult physician.
Skin: Rinse properly with clean soapy water 5-10 minutes.
Inhalation/Ingestion: Remove patient from further contamination. Give artificial respiration. Gastric lavage or emesis.
Do not give stimulants. Seek medical help.
SECTION IX-PREPARATION DATE OF M.S.D.S.
Additional Info/Comments:
Phone Number: (905) 793-4311 Prepared By: Quality Control Laboratory
Date: Janaury 31, 2006. Kleen-Flo Tumbler Industries Limited
THIS SHEET SUPERSEDES ANY OTHER M.S.D.S. PREVIOUSLY PREPARED
N/A: not available N/E: not established
|