SECTION 1 - PRODUCT IDENTIFICATION SECTION 4 鈥? FIRE AND EXPLOSION DATA
Flash Point: Not Established
Common Name: Concrete Acid Stain
Flammable Limits: Lower Explosive Limit: N/A
(As appears on label)
Upper Explosive Limit: N/A
Chemical Family:
Manufacturer/Supplier: Camouflaged Concrete Corp.
Special Fire Fighting
PO Box 51
Procedures: Wear self contained breathing apparatus with full face
Farmersville, TX 75442
piece operated in pressure demand or other positive
1-800-650-1157
pressure mode and full body protective clothing when
Prepared by: Linda Choate
fighting fire.
Emergency: 1-800-650-1157 Ext. /3
Unusual Fire/Explosion
MATERIAL SAFETY DATA SHEET Hazards: Releases Hydrogen Chloride gas when heated. Also reacts
Effective January 1, 2006 with most metals to release hydrogen gas, which can form
explosive mixtures with air.
Hazard Rating Scale
SECTION 5 鈥? REACTIVITY DATA
4 = Extreme
Toxicity 3 3 = High Stability: Stable
Flammability 0 2 = Moderate
Conditions to avoid: Avoid contact with strong alkalis, alkali metals.
Reactivity 0 1 = Slight
Incompatible with: N/A
0 = Insignificant
SECTION 2 鈥? HAZARDOUS INGREDIENTS
Hazardous decomposition
products: May evolve highly toxic chloride fumes.
Color Hazardous Components(s) CAS No. % By Weight OSHA PEL ACGIH TLV
Hazardous polymerization: Will not occur.
All colors Hydrochloric Acid 7647-01-0 <4% to <9% 7 mg/m3 7mg/m3
Slate Sodium Dichromate 7789-12-0 Minor 5ppm 5ppm
SECTION 6 HEALTH HAZARD DATA
Cupric Chloride 7447-39-4 Minor 5mg/m3 N.E.
Phosphoric Acid 7664-38-2 Trace 7mg/m3 7mg/m3 Carcinogenicity: NO
Manganese Chloride 7773-01-5 Minor 5mg/m3 N.E. IARC: NO
Island Sand Sodium Dichromate 7789-12-0 Minor 5ppm 5ppm OSHA Regulated?: NO
Honey Oak Sodium Dichromate 7789-12-0 Minor 5ppm 5ppm Threshold Limit Value (TLV): 5 ppm
Ferrous Chloride 7758-94-3 Minor 1mg/m3 1mg/m3 Effects of Overexposure:
Riverstone Sodium Dichromate 7789-12-0 Minor 5ppm 5ppm
Manganese Chloride 7773-01-5 Minor 5mg/m3 N.E.
Ingestion: Can cause severe tissue destruction.
Golden Sand Ferrous Chloride 7758-94-3 Minor 1mg/m3 1mg/m3
Kidney failure may follow and result in death.
Bronze Green Cupric Chloride 7447-39-4 Minor 1mg/m3 1mg/m3
Ferrous Chloride 7758-94-3 Minor 1mg/m3 1mg/m3
Inhalation: TLV and OSHA guide is 5ppm Ceiling for
Onyx Manganese Chloride 7773-01-5 Minor 5mg/m3 N.E.
Hydrogen Chloride; Severely irritating.
Sodium Dichromate 10588-01-9 Minor .5mg/m3 .01mg/m3
Mossy Green* Cupric Chloride 7447-39-4 Minor 5mg/m3 N.E.
Skin Absorption: Massive overexposure could lead to kidney failure and death.
Phosphoric Acid 7664-38-2 Trace 7mg/m3 7mg/m3
Saddle , Manganese Chloride 7773-01-5 Minor 5mg/m3 N.E.
Eye Contact: Rapidly causes severe burns, possible with permanent
Coffee, Ferrous Chloride 7758-94-3 Major 1mg/m3 1mg/m3
impairment of vision burning sensation
Leather Brown Sodium Dichromate 10588-01-9 Minor .5mg/m3 .01mg/m3
Turquoise* Cupric Chloride 7447-39-4 Minor 1mg/m3 1mg/m3
Emergency and First Aid Procedures
Phosphoric Acid 7664-38-2 Minor 1mg/m3 3mg/m3
Canyon Ferrous Chloride 7758-94-3 Major 1mg/m3 1mg/m3
Eyes: Flush thoroughly with running water for at least 30 minutes.
Rosewood Ferric Chloride 7705-08-0 Major N/A N/A
Skin: Skin burn likely. An Immediate, continuous, and thorough
*Does not contain Hydrochloric Acid wash in flowing water for 30 minutes. Remove clothing
immediately. Destroy contaminated shoes.
SECTION 3 鈥? PHYSICAL/CHEMICAL CHARACTERISTICS
Boiling Point: N/A
Inhalation: Move victim to fresh air if effects occur. Call physician
Melting Point: N/A
and/or transport to medical facility.
Specific Gravity (Water = 1): 1.30+/- .03
Vapor Pressure (mm Hg): N/A
Ingestion: Corrosive. Do not induce vomiting. Give large amounts of water of
Vapor Density (Air = 1): N/A
milk if available and immediately transport to a medical facility.
Solubility in Water: N/A
Evaporation Rate Note To Physician Massive overexposure to solutions of this product could lead
(Butyl Acetate=1) Slower than Butyl Acetate to kidney failure and death.
Appearance & Odor Dark Liquid with sharp, pungent odor.
PH: 8.0 鈥? 9.0
SECTION 7 鈥? SPILL OR LEAK PROCEDURES
If Material Spills or Leaks: Shovel or soak up spilled material into a plastic container and reuse or remove to
approved chemical waste disposal area. Flush area with water, directing runoff to
appropriate treatment or disposal container. Never flush to sewer. Major spills
should be reported according to regulations.
Waste Disposal: Dispose of in accordance with local, state and federal regulations.
SECTION 8 鈥? SAFE HANDLING AND STORAGE INFORMATION
Respiratory Protection NIOSH/MSHA approved respirator whenever exposure to vapor/mist is likely to
occur, unless level are below applicable limits. For emergencies, a self-contained
breathing apparatus or full-face respirator is recommended.
Ventilation: Ventilation must be sufficient to control vapors. Breathing of vapors must be
avoided. This material should be confined as far as possible within sealed or
covered equipment in which case normal ventilation should be adequate. Special
(local) ventilation will be needed in areas where vapors are expected to be vented.
Protective Equipment: Impervious gloves, neoprene or rubber; safety glasses with splash guards or side
shields, chemical goggles, or face shields.
Other Equipment and
Practices: Clean, body covering clothing. Further safety equipment (apron, footwear, etc.)
should be used as necessary to prevent contact with material.
Special Precautions for
Handling and Storage: Prevent all skin and eye contact. Avoid breathing vapors. Re-seal partially used
containers. Ensure that all containers are properly labeled to prevent accidental
ingestion. Wash with soap and water before eating, drinking, smoking, or using
toilet facilities. Observe conditions of good industrial hygiene and safe working
practices. Remove and thoroughly launder contaminated clothing before reuse.
Discard contaminated shoes. Store under cool, dry conditions and away from
open flames and high temperatures.
SECTION 9 鈥? SHIPPING INFORMATION
DOT Shipping Name: Hydrochloric Acid Solution
DOT Hazard Class: 8 - Corrosive
DOT Reportable Quantity: N/A
USERS RESPONSIBILITY & DISCLAIMER OF LIABILITY: A bulletin such as this cannot be expected to cover all possible situations. As the user has the responsibility to provide a safe workplace,
all aspects of an individual operation should be examined to determine if, or where precautions 鈥? in addition to those described herein are required. Although the information contained herein is based on
data considered to be accurate, all materials present unknown health hazards, and should be used with caution and by properly trained personnel. Although certain hazards are described herein, we
cannot guarantee that these are the only hazards that exist. Any health hazard and safety information should be passed onto your customers or employees, as the case may be. Final suitability of the
chemical for each circumstance is the sole responsibility of the end user. No representation or warranties either expressed or implied, of merchantability, fitness for a particular purpose, or any other
nature are made hereunder with respect to the information contained herein, or the chemical to which the information refers. It is the sole responsibility of the end user to comply with all applicable
federal, state and local laws and regulations. Vendor assumes no responsibility for injury to vendee or third persons proximately caused by the material if reasonable safety procedures are not adhered
to as stipulated in the data sheet. Additionally, vendor assumes no responsibility for injury to vendee or third persons proximately caused by abnormal use of the material even if reasonable safety
procedures are followed.
|