MATERIAL SAFETY DATA SHEET
May be used to comply with OSHA's Hazard Communication Standard, 29 CFR 1910.1200
Standard must be consulted for specific requirements.
IDENTITY: INCIDE-OUT鈩? SPRAY TANK CLEANER
SECTION I
MANUFACTURER'S NAME: EMERGENCY PHONE NUMBER:
Precision Laboratories, Inc. 800-323-6280
1429 S. Shields Drive 800-424-9300 (Chemtrec - 24 hrs.)
DATE PREPARED: 10/01/05
Waukegan, IL 60085
SECTION II - INGREDIENTS
INGREDIENT CAS # PERCENT (Optional) ACGIH TLV
2ppm(TWA); 2ppm (STEL)
Potassium Hydroxide 1310-58-3 10-15%
Nonylphenolpolyethoxyethanol Surfactant 9016-45-9 Not Established
HAZARD CLASSIFICATION: Corrosive Material UN 3266
HMIS RATING: 3-0-0-X
SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
BOILING POINT (掳F.): 212掳 F. SPECIFIC GRAVITY (H20=1): 1.119 卤 0.005
VAPOR PRESSURE (mm HG): Not Determined
VAPOR DENSITY (AIR=1): Not Determined EVAPORATION RATE (vs. H20): About the Same
SOLUBILITY IN WATER: Complete pH: 14 卤 0.5
APPEARANCE AND ODOR: Clear, red-colored liquid with citrus odor.
SECTION IV - FIRE AND EXPLOSION HAZARD
FLASH POINT (T.C.C.): None
FLAMMABLE LIMITS: N/A LEL: UEL:
EXTINGUISHING MEDIA: Product is noncombustible. Water Spray (Fog); Dry Chemical; CO2; or Foam may be used
where product is stored.
SPECIAL FIRE-FIGHTING PROCEDURES: Do not enter confined fire-spaces without protective clothing and self-
contained air supply.
UNUSUAL FIRE AND EXPLOSION HAZARDS: None.
SECTION V - REACTIVITY DATA
STABILITY
UNSTABLE
STABLE x
INCOMPATIBILITY (MATERIALS TO AVOID): Strong acids; strong oxidizers.
HAZARDOUS DECOMPOSITION PRODUCTS: Burning may produce oxides of carbon and other substances.
IDENTITY: INCIDE-OUT鈩? SPRAY TANK CLEANER - Page Two
SECTION VI - HEALTH HAZARD DATA
PRIMARY ROUTES OF EXPOSURE: EYES: Yes SKIN: N/A INGESTION: Yes INHALATION: Yes
SIGNS AND SYMPTOMS OF OVEREXPOSURE (Acute): Contact with skin can cause severe irritation with pain,
severe redness and swelling with chemical burns and possible tissue destruction. Contact with eyes can cause severe
burns, permanent damage and possible blindness. Harmful or fatal if swallowed--causes severe burns of mouth, throat
and stomach. Aspiration into lungs may occur during ingestion or vomiting, resulting in lung injury.
SIGNS AND SYMPTOMS OF OVEREXPOSURE (Chronic): None currently known.
MEDICAL CONDITIONS AGGRAVATED BY OVEREXPOSURE: An existing dermatitis.
CARCINOGEN OR SUSPECT CARCINOGEN INGREDIENTS: None.
SECTION VII - EMERGENCY AND FIRST AID PROCEDURES
EYES: Flush eyes with water for at least 15 minutes and call a physician immediately. SKIN: Wash with large amounts
of soap and water. If irritation persists, consult a physician. INGESTION: DO NOT induce vomiting. Dilute by drinking
water. Call a physician immediately. INHALATION: Not an expected route of exposure. If vapors or mists cause
irritation, remove subject to fresh air.
SECTION VIII - PRECAUTIONS FOR SAFE HANDLING AND USE
RESPIRATORY PROTECTION: Assure adequate ventilation to prevent release of vapors and/or mists which
exceed regulatory limits.
VENTILATION REQUIREMENTS: Normal
LOCAL EXHAUST
MECHANICAL EXHAUST
EYE PROTECTION: Safety Glasses/Goggles
PROTECTIVE GLOVES: Rubber/PVC
OTHER PROTECTIVE CLOTHING OR EQUIPMENT: Impervious protective clothing appropriate to minimize
contact (i.e. - boots, apron, faceshield) especially where sprayback/misting conditions occur.
SECTION IX - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Do not touch or walk through spilled
material. Stop leak if you can without risk. Dike ahead of large spills to prevent runoff. Mop, pump or take up with sand
or other inert absorbent and reclaim into containers for reuse, recycle, or proper disposal.
WASTE DISPOSAL METHOD: Dispose of in an approved waste facility according to federal, state and local
regulations.
SECTION X - STORAGE AND HANDLING INFORMATION
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Danger. Corrosive liquid. Do not get in eyes, on
skin or clothing. Avoid breathing of dust, spray or mist. Keep container closed when not in use. Wash thoroughly after
handling.
SECTION XI - REGULATORY INFORMATION
SARA HAZARD: Title III, Section 313: Contains no Section 313 listed substances subject to reporting.
WHILE INFORMATION AND RECOMMENDATIONS SET FORTH HEREIN ARE BELIEVED TO BE ACCURATE AS
OF THE DATE HEREON, PRECISION LABORATORIES, INC. MAKES NO WARRANTY WITH RESPECT THERETO
AND DISCLAIMS ALL LIABILITY FROM RELIANCE THEREON.
|